NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
10 reportsClear category filter147,000 miles · Jun 6, 2019
StructureSuspension
MY DRIVERS DOOR WOULD NOT OPEN FROM THE INSIDE FOR 3 DAYS ABOUT MAY 15TH-18TH. I TRIED ALL THE "TRICKS" AND NOTHING WORKED. I FINALLY AM ABLE TO OPEN IT BUT THE DOOR HAMDLE BROKE OFF SHORTLY AFTER. AND NOW TODAY 6/6/19 MY DRIVER DOOR WONT LATCH EVERY TIME I CLOSE IT EVEN AFTER DEGREASING ANE REGREASING THE LATCH. ALSO MY TORSION…
Read full complaint
MY DRIVERS DOOR WOULD NOT OPEN FROM THE INSIDE FOR 3 DAYS ABOUT MAY 15TH-18TH. I TRIED ALL THE "TRICKS" AND NOTHING WORKED. I FINALLY AM ABLE TO OPEN IT BUT THE DOOR HAMDLE BROKE OFF SHORTLY AFTER. AND NOW TODAY 6/6/19 MY DRIVER DOOR WONT LATCH EVERY TIME I CLOSE IT EVEN AFTER DEGREASING ANE REGREASING THE LATCH. ALSO MY TORSION BARS AND STEERING BAR HAVE BEEN REPLACED BUT THEY ONCE AGAIN HAVE COME LOOSE. THE DOORS HAPPEN IN PARK INNA DRIVEWAY AMD THE CAR SWAYING ISSUE I FEEL WHILE DRIVING DOWN THE HIGHWAY.
NHTSA ODI #11218405
115,000 miles · Feb 11, 2019
Electrical SystemEngineSuspension
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS NO SAFETY PRE-INSPECTION STICKER WHEN THE VEHICLE WAS PURCHASED FROM DEL CHEVROLET (1644 LANCASTER AVE, PAOLI, PA 19301, (484) 324-4265). AS A RESULT, THE VEHICLE FAILED INSPECTION. THE INSPECTION SHOP INFORMED THE CONTACT THAT THE BATTERY NEEDED REP…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS NO SAFETY PRE-INSPECTION STICKER WHEN THE VEHICLE WAS PURCHASED FROM DEL CHEVROLET (1644 LANCASTER AVE, PAOLI, PA 19301, (484) 324-4265). AS A RESULT, THE VEHICLE FAILED INSPECTION. THE INSPECTION SHOP INFORMED THE CONTACT THAT THE BATTERY NEEDED REPLACEMENT, THE VEHICLE NEEDED AN ALIGNMENT, FOUR NEW TIRES, AND A NEW LOWER CONTROL ARM AND BALL JOINT. IN ADDITION, THE VEHICLE STALLED ON MORE THAN ONCE OCCASION. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V171000 (ELECTRICAL SYSTEM, 14E021000 (ELECTRICAL SYSTEM), AND 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
NHTSA ODI #11176204
90,000 miles · Sep 12, 2014
Power TrainSuspension
BETWEEN APPROX 45 AND 60 MPH VEHICLE SOUNDS AS IF DRIVING OVER RUMBLE STRIPS. WILL STOP VIBRATING INTERMITTENTLY ABOVE 60 MPH. VIBRATION IS FELT FROM FRONT PASSENGER SIDE. THE STEERING WHEEL DOES NOT SWAY. NO TROUBLE SHIFTING. BETWEEN 3 MECHANICS HAVE BEEN GIVEN 3 DIFFERENT ANSWERS: LOOSE BODY PART VIBRATING IN WIND, SUSPENSION,…
Read full complaint
BETWEEN APPROX 45 AND 60 MPH VEHICLE SOUNDS AS IF DRIVING OVER RUMBLE STRIPS. WILL STOP VIBRATING INTERMITTENTLY ABOVE 60 MPH. VIBRATION IS FELT FROM FRONT PASSENGER SIDE. THE STEERING WHEEL DOES NOT SWAY. NO TROUBLE SHIFTING. BETWEEN 3 MECHANICS HAVE BEEN GIVEN 3 DIFFERENT ANSWERS: LOOSE BODY PART VIBRATING IN WIND, SUSPENSION, TRANSMISSION. HAD BALANCE AND ALIGNMENT CHECKED WITH NO ISSUES. CONTACTED GM DEALER TO CHECK RECALLS AND OTHER KNOWN ISSUES, NONE FOUND. NO PREVIOUS SYMPTOMS, VEHICLE DROVE NORMALLY UNTIL 6/18. DO NOT CURRENTLY DRIVE VEHICLE OUT OF FEAR OF SOMETHING BREAKING OR FALLING APART. AM STILL TRYING TO GET DIAGNOSED. *TR
NHTSA ODI #10632632
50,209 miles · Aug 5, 2014
SteeringSuspension
I TOOK THE CAR INTO THE DEALERSHIP BECAUSE OF A NOISE ON DRIVER SIDE NEAR TIRE DURING LOW SPEED WHILE GOING OVER A BUMP. DEALER STATED THE STEERING COLUMN WAS BAD. REPLACED THE PART AT A TOTAL COST OF $874.62. THERE ARE SEVERAL COMPLAINTS ABOUT THE STEERING COLUMN LOWER BEARING THAT IS FAILING ON THE NHTSA WEB SITE, WITH SOME…
Read full complaint
I TOOK THE CAR INTO THE DEALERSHIP BECAUSE OF A NOISE ON DRIVER SIDE NEAR TIRE DURING LOW SPEED WHILE GOING OVER A BUMP. DEALER STATED THE STEERING COLUMN WAS BAD. REPLACED THE PART AT A TOTAL COST OF $874.62. THERE ARE SEVERAL COMPLAINTS ABOUT THE STEERING COLUMN LOWER BEARING THAT IS FAILING ON THE NHTSA WEB SITE, WITH SOME INDICATING THEY HAD TO REPLACE THIS PART MULTIPLE TIMES. I FEEL THE PART IS DEFECTIVE AND SHOULD BE RECALLED BECAUSE IT CAN CAUSE THE STEERING TO SEIZE AND THE OPERATOR WILL NOT BE ABLE TO CONTROL THE VEHICLE. I CONTACTED THE MANUFACTURER AND THEY TOOK MY COMPLIANT OVER THE PHONE, BUT THEY MOST LIKELY WILL NOT REIMBURSE ME FOR THE REPAIRS UNLESS THEY DETERMINE THE PART IS DEFECTIVE. I WANT THIS TO FURTHER INVESTIGATED BECAUSE I FEAR THE NEW PART CAN FAIL AT ANY TIME CAUSING A CRASH AND A POTENTIAL FATALITY. *TR
NHTSA ODI #10618989
Mileage unknown · Jun 10, 2014
Electrical SystemPower TrainSteering
2009 CHEVROLET COBALT. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH AND SEVERAL OTHER PROBLEMS WITH VEHICLE. *SMD THE CONSUMER THE VEHICLE WAS TAKEN TO THE DEALER, SEVERAL TIMES. THREE TIMES, FOR THE IGNITION. THE STEERING MODULE, STRUTS, AND CONTROL ARMS WERE REPLACE. THE DRIVE TRAIN WAS IN THE PROCESS OF FAILING. *JB
NHTSA ODI #10594061
59,998 miles · Dec 2, 2013
Suspension
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE WHEEL BEARING FAILED, CAUSING THE VEHICLE TO EMIT A LOUD NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE TWO FRONT WHEEL BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MA…
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE WHEEL BEARING FAILED, CAUSING THE VEHICLE TO EMIT A LOUD NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE TWO FRONT WHEEL BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 59,998.
NHTSA ODI #10554320
93,242 miles · Jul 25, 2013
Engine And Engine CoolingSuspension
I TOOK MY 2009 CHEVROLET COBALT 1LT SEDAN TO THE DEALERSHIP FROM WHERE I PURCHASED IT FROM TODAY TO GET MY VEHICLE INSPECTED AS REQUIRED PER MY STATE. PRIOR TO TODAY, FOR ABOUT THE PAST WEEK OR SO, MY CHECK ENGINE LIGHT CAME ON. WENT TO AUTOZONE AND THEY RAN A DIAGNOSTIC ON IT SAYING A CAM SHAFT POSITION SENSOR NEEDED REPLACEMEN…
Read full complaint
I TOOK MY 2009 CHEVROLET COBALT 1LT SEDAN TO THE DEALERSHIP FROM WHERE I PURCHASED IT FROM TODAY TO GET MY VEHICLE INSPECTED AS REQUIRED PER MY STATE. PRIOR TO TODAY, FOR ABOUT THE PAST WEEK OR SO, MY CHECK ENGINE LIGHT CAME ON. WENT TO AUTOZONE AND THEY RAN A DIAGNOSTIC ON IT SAYING A CAM SHAFT POSITION SENSOR NEEDED REPLACEMENT. REPLACED IT AND CHECK ENGINE LIGHT WENT AWAY FOR ABOUT A WEEK THEN CAME BACK ON. (REPLACED BOTH OF THE SENSORS TO BE SAFE) CHECK ENGINE LIGHT WOULD TURN OFF FOR DAYS THEN RANDOMLY COME ON. WENT TO DEALERSHIP AND THEY STATED I NEEDED A NEW FRONT RIGHT STRUT SINCE MINE'S WAS LEAKING. CALLED UP A FEW OTHER MECHANICS AND THEY HAVE SAID THIS IS A COMMON ISSUE WITH COBALTS. IF YOU GOOGLE "COBALT STRUT LEAKING", THERE ARE MANY RESULTS, YET NO RECALL. THIS ISN'T JUST COMMON IN MY VEHICLE'S MODEL YEAR BUT WITH ALL COBALTS. I FEEL THERE SHOULD BE A RECALL SINCE THIS IS COMMON AMONG THIS MAKE/MODEL. *TR
NHTSA ODI #10531879
86,000 miles · Jun 15, 2012
SteeringSuspension
CAR IS PULLING TO THE LEFT AND HAD CAR ALIGNMENT DONE AND NEW TIRES PUT ON. STILL PULLING TO THE LEFT AND HEAR RATTLING NOISE IN THE STEERING COLUMN WHEN TURNING TO THE LEFT AND WHEN SPEED AT 50 MPH. IT ALSO RATTLES WHEN I SLOW DOWN TO STOP. THIS IS NOT SAFE FOR ME OR MY FAMILY. THIS SHOULD BE RECALLED IMMEDIATELY. TOOK CAR TO…
Read full complaint
CAR IS PULLING TO THE LEFT AND HAD CAR ALIGNMENT DONE AND NEW TIRES PUT ON. STILL PULLING TO THE LEFT AND HEAR RATTLING NOISE IN THE STEERING COLUMN WHEN TURNING TO THE LEFT AND WHEN SPEED AT 50 MPH. IT ALSO RATTLES WHEN I SLOW DOWN TO STOP. THIS IS NOT SAFE FOR ME OR MY FAMILY. THIS SHOULD BE RECALLED IMMEDIATELY. TOOK CAR TO MECHANIC DIAGNOSIS IS THE STEERING COLUMN. PRODUCTION ERROR. I AM NOT GOING TO BE PAYING HIGH COST FOR SOMETHING THAT SHOULD BE RECALLED AND FAULT OF A PRODUCTION ERROR. *JB
NHTSA ODI #10461871
55,200 miles · Sep 25, 2011
SteeringSuspensionWheels
VEHICLE IS MAKING WEIRD FRONT END NOISES, KNOCKING, RATTLES, SHAKES IN THE STEERING COLUMN, VIBRATIONS WHEN DRIVING ON THE DRIVER SIDE BEHIND THE STEERING WHEEL AND IN THE FLOOR, TIRES ARE MAKING A NOISE WHEN DRIVING LIKE SOMETHING IS HANGING. *TR
NHTSA ODI #10427068
51,000 miles · Jun 14, 2011
Electrical SystemSuspension
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THE KEY WOULD NOT TURN OFF THE IGNITION. THE CONTACT HAD TO DISCONNECT THE RALLY FOR THE FUEL INJECTORS IN ORDER FOR THE VEHICLE TO BE SHUT OFF. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER ADVISED THAT THE IGNITION SWITCH LOCK CYLINDER NEEDED TO BE …
Read full complaint
TL* THE CONTACT OWNS A 2009 CHEVROLET COBALT. THE CONTACT STATED THE KEY WOULD NOT TURN OFF THE IGNITION. THE CONTACT HAD TO DISCONNECT THE RALLY FOR THE FUEL INJECTORS IN ORDER FOR THE VEHICLE TO BE SHUT OFF. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER ADVISED THAT THE IGNITION SWITCH LOCK CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE CONTACT STATED THAT VEHICLE WOULD DRIFT FROM LEFT TO RIGHT WHEN DRIVING AT LEAST 60 MPH. THE VEHICLE WAS NOT INSPECTED FOR THE DRIFTING FAILURE. THE FAILURE MILEAGE WAS 51,000.
NHTSA ODI #10406270
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20011 · Fuel Line Leak
Opened Jul 5, 2020 · Closed Aug 17, 2023
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Additional source detail variants (3)
Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Gasoline
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
Illustration