IllustrationKEY COMES OUT IF THE IGNITION WHILE CAR IS RUNNING/ IN RUN POSITION
2001 Chevrolet Cavalier
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Chevrolet Cavalier do not stand out strongly from the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
3225–50K
1950–75K
1675–100K
10100–150K
7150K+
104 reports with mileage · 139 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports8 fire reports14 injury reports
Unknown Or Other complaints
7 reports05-17/01 REPLACE LEFT FRONT STRUT & BEARING SUBLET: INSTALL NEW CLIPS 12-26-01 REPLACE SURGE TANK CAP 01-28-02 REPLACE WIRE ENDS AT EVAP CANISTER VENT SWITCH 12-06-02 REPLACED LEFT REAR WHEEL HUB REPLACED EVAP CORE AND EVAC 04-03-03 REPLACED 2 SENSORS 06-05-03 AIR QUIT - GOT ESTIMATE TO REPLACE SUCTION LINE & SHAFT SEAL…
Read full complaint
05-17/01 REPLACE LEFT FRONT STRUT & BEARING SUBLET: INSTALL NEW CLIPS 12-26-01 REPLACE SURGE TANK CAP 01-28-02 REPLACE WIRE ENDS AT EVAP CANISTER VENT SWITCH 12-06-02 REPLACED LEFT REAR WHEEL HUB REPLACED EVAP CORE AND EVAC 04-03-03 REPLACED 2 SENSORS 06-05-03 AIR QUIT - GOT ESTIMATE TO REPLACE SUCTION LINE & SHAFT SEAL FOR AIR CONDITIONER 06-09-03 CRUISE CONTROL QUIT COOLANT LIGHT CAME ON TWICE WHILE DRIVING - HAVEN'T GOTTEN ESTIMATE ON YET
WHIRRING NOISE COMING FROM THE RIGHT SIDE OF THE CAR( APPROX.THE REAR) AT DRIVING SPEED OF 65-70 MPH. HAVE REPLACED RIGHT REAR WHEEL BEARINGS(STILL NOISY). ALSO REPLACED FACTORY MOUNTED TIRES.(STILL NOISY). WHAT ELSE COULD IT BE?BOUGHT CAR IN JAN.2002 WITH 23800 MILES. STARTING REPORTING PROBLEM WITHIN 1-2 MOS LATER
THE POWERTRAIN CONTROL MODULE HAS BEEN IN FOR SERVICE TWICE. *JG *TS
WHILE IN MOTION, VEHICLES DASHBOARD LIGHTS ILLUMINATED CAUSING THE RADIO TO LOCK. DEALER CLAIMS THEY COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE. *JG
WINDSHIELD FOGS UP . FACTORY REPRESENTATIVE STATED PLASTIC USED FOR DASHBOARD GIVES OFF FUMES THAT CAUSE THE FOGGING. ONLY REMEDY OFFERED BY DEALER IS FOR CONSUMER TO PURCHASE A SPECIAL CLEANER . PLEASE PROVIDE ADDITIONAL INFORMATION. *AK
TRANSMISSION IS SLIPING AND IT'S KIND OF BURNING. THSI HAS HAPPENED 11 TIMES. CONTACTED DEALER, AND DEALER SAID THAT ENGINE CHECK LIGHT NEEDED TO COME ON BEFORE THEY WILL DO ANYTHING.*AK
Official recalls
104V036000 · Electrical System:ignition:switch
Jan 27, 2004
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available