ABOUT A TWO YEARS AGO I NOTICED THE AIR WAS BLOWING WARMER THAN USUAL SO I TOOK MY CAR IN TO GET FREON PUT IN MY CAR THINKING IT WAS LOW....AFTER ABOUT 3 DAYS, IT STARTED BLOWING WARM AGAIN. I TOOK IT BACK AND THEY THOUGHT THERE WAS MAYBE A LEAK, SO THEY PUT DYE IN THE SYSTEM...I TOOK IT BACK 2 DAYS LATER, AND THEY FOUND THERE W…
Read full complaint
ABOUT A TWO YEARS AGO I NOTICED THE AIR WAS BLOWING WARMER THAN USUAL SO I TOOK MY CAR IN TO GET FREON PUT IN MY CAR THINKING IT WAS LOW....AFTER ABOUT 3 DAYS, IT STARTED BLOWING WARM AGAIN. I TOOK IT BACK AND THEY THOUGHT THERE WAS MAYBE A LEAK, SO THEY PUT DYE IN THE SYSTEM...I TOOK IT BACK 2 DAYS LATER, AND THEY FOUND THERE WERE LEAKS THROUGHOUT THE ENTIRE SYSTEM. I WAS TOLD THE ENTIRE SYSTEM NEEDED TO BE REPLACED, WHICH WAS GOING TO COST ABOUT $1500-$2000 (INCL. LABOR) I WAS OUTRAGED BY THIS, AS THE CAR WASN'T EVEN 5 YEARS OLD!! I MAINTAINED THE CAR JUST AS I SHOULD HAVE BEEN. (I HAVE A RELATIVE WHO IS A MECHANIC, AND SO HE ALWAYS DOES THE SERVICE ON MY CAR!) I AM JUST CURIOUS IF THERE ARE OTHERS WITH THIS SAME PROBLEM, AND IF SO, WHAT WAS DONE ABOUT IT? *JB
NHTSA ODI #10159943
62,000 miles · Jan 15, 2004
Electrical SystemEngine And Engine CoolingEquipment
CD WILL NOT PLAY. GET ERROR MESSAGE. KNOB ON MIRROR FELL OFF. BATTERY WAS REPLACED IN SEPTEMBER 2000. BATTERY KEPT DYING ON ME.
NHTSA ODI #10069579
Mileage unknown · May 25, 2003
Equipment
I GOT A FLAT TIRE WHILE DRIVING ON THE HIGHWAY. I USED THE JACK ISSUED BY GENERAL MOTORS TO LIFT UP MY CAR TO CHANGE MY TIRE. I PROCEEDED TO REMOVE THE FLAT TIRE WHEN THE JACK BROKE AND DROPPED MY CAR ON THE GROUND WITH NO TIRE FOR SUPPORT. I WAS NOT PHYSICALLY INJURED BUT IT WAS QUITE POSSIBLE THAT I COULD HAVE BEEN HAD I NO…
Read full complaint
I GOT A FLAT TIRE WHILE DRIVING ON THE HIGHWAY. I USED THE JACK ISSUED BY GENERAL MOTORS TO LIFT UP MY CAR TO CHANGE MY TIRE. I PROCEEDED TO REMOVE THE FLAT TIRE WHEN THE JACK BROKE AND DROPPED MY CAR ON THE GROUND WITH NO TIRE FOR SUPPORT. I WAS NOT PHYSICALLY INJURED BUT IT WAS QUITE POSSIBLE THAT I COULD HAVE BEEN HAD I NOT BEEN BENDING OVER TO CHANGE THE TIRE. *NLM
NHTSA ODI #10019270
Mileage unknown · Oct 28, 2002
Equipment
ON MORE THAN ONE OCCASION, THE CIGARETTE LIGHTER HAS BEEN LAUNCHED OUT AFTER BEING HEATED UP. IT HAS LANDED IN MY LAP WHILE DRIVING AS WELL AS GOING UNDER THE CAR SEAT WHILE DRIVING. THIS IS VERY DANGEROUS AND I DO NOT WANT TO BURN MYSELF OR HAVE TO TRY TO FIND A RED HOT LIGHTER UNDER MY SEAT WHILE DRIVING. I BELIEVE THAT THIS C…
Read full complaint
ON MORE THAN ONE OCCASION, THE CIGARETTE LIGHTER HAS BEEN LAUNCHED OUT AFTER BEING HEATED UP. IT HAS LANDED IN MY LAP WHILE DRIVING AS WELL AS GOING UNDER THE CAR SEAT WHILE DRIVING. THIS IS VERY DANGEROUS AND I DO NOT WANT TO BURN MYSELF OR HAVE TO TRY TO FIND A RED HOT LIGHTER UNDER MY SEAT WHILE DRIVING. I BELIEVE THAT THIS COULD CAUSE AN ACCIDENT IF SOMEONE WAS NOT AWARE THAT THE LIGHTER LIKES TO LAUNCH ITSELF OUT. DT
NHTSA ODI #769017
Mileage unknown · Aug 12, 2001
EquipmentSeat Belts
THE DRIVER SIDE SEAT BELT FAILS TO CONNECT, ONLY AFTER NUMEROUS TRIES WILL IT FINALLY CONNECT AND STAY FASTENED. THE HIGH PRESSURE AIR CONDITIONING LINE IS RUBBING ON THE RADIATOR FAN CAUSING A HOLE IN THE LINE, WHICH NOW NEEDS TO BE FIXED.*AK
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION." THE INSTRUMENT PANEL BACKLIGHTING MAY NOT FUNCTION AFTER ADJUSTING THE INTERIOR LIGHT INTENSITY.
Consequence & remedy
Consequence: IF THE INSTRUMENT PANEL IS NOT LIT AT NIGHT, THE DRIVER MAY NOT BE ABLE TO SEE THE CONTROLS AND DISPLAYS.
Remedy: DEALERS WILL TEST THE BODY CONTROL MODULE, AND IF NECESSARY, REPLACE IT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1999 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration