Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 88 of 540 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
70 crash reports25 fire reports60 injury reports
What owners actually said
540 reports
Mileage unknown · Sep 28, 2000
Air BagsInjury
THE CONSUMER SLAMMED ON THE BRAKE TO AVOID A COLLISION AND ALMOST SIMULTANEOUSLY THE AIR BAGS VIOLENTLY DEPLOYED CAUSING THE DRIVER TO REAR END THE VEHICLE AHEAD OF IT, THE DEPLOYMENT BURNED BOTH OF THE DRIVERS UPPER ARMS AND FOREARMS, CUT AND BRUISED THE CHIN, BROKE ONE TOOTH AND LOOSED PORCELAIN BRIDGE, DAMAGED ESOPHAGUS AND D…
Read full complaint
THE CONSUMER SLAMMED ON THE BRAKE TO AVOID A COLLISION AND ALMOST SIMULTANEOUSLY THE AIR BAGS VIOLENTLY DEPLOYED CAUSING THE DRIVER TO REAR END THE VEHICLE AHEAD OF IT, THE DEPLOYMENT BURNED BOTH OF THE DRIVERS UPPER ARMS AND FOREARMS, CUT AND BRUISED THE CHIN, BROKE ONE TOOTH AND LOOSED PORCELAIN BRIDGE, DAMAGED ESOPHAGUS AND DAMAGED STERNUM, THE PASSENGER SUSTAINED BURNS TO THE FACE AND DAMAGE TO THE RIGHT EARDRUM, THE NEXT DAY THE CONSUMER RECIEVED RECALL 98V-146 FOR INADVERTENT AIR BAG DEPLOYMENT . NLM
NHTSA ODI #555498
Mileage unknown · Sep 25, 2000
Engine And Engine CoolingSuspension
WHEN STARTING VEHICLE A STRONG ODOR ENTERS PASSENGER'S COMPARTMENT, FOLLOWING EXTREME VIBRATION IN THE FRONT END, CAUSE UNKNOWN. DEALER CAN NOT IDENTIFY THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS.*AK
NHTSA ODI #871454
Mileage unknown · Sep 24, 2000
Steering
ERRATIC POPPING NOISE AND EXCESSIVE PLAY IN THE STEERING WHEEL. DEALER NOTIFIED. *AK RACK AND PINION HOUSING WAS POPPING AND FREEZING UP, DEALER IS GOING TO REPLACE IT. *YH
NHTSA ODI #871364
Mileage unknown · Sep 12, 2000
SuspensionCrashInjury
WHEN DRIVING 80-85 MPH VEHICLE SUDDENLY DRIFTED TO LEFT, CONSUMER LOST CONTROL OF VEHICLE, CAUSING VEHICLE TO FLIP AND ROLL OVER FOUR TIMES, RESULTING IN INJURIES TO DRIVER SIDE OCCUPANT, AND KILLING THE PASSENGER'S SIDE OCCUPANT. *AK
NHTSA ODI #870274
Mileage unknown · Sep 4, 2000
Air Bags
VEHICLE INVOVLED IN A FRONTAL COLLISION, SPEED WAS UNDETERMINED; BUT THE DRIVER SIDE AIR BAG DID NOT DEPLOYED. DEALER/MFR'S NOTIFIED. PLEASE PROVIDE ANY FURTHER DETAILS.
NHTSA ODI #869410
Mileage unknown · Sep 2, 2000
Tires
WHEN I PURCHASED MY CAR LAST YEAR ;THEY TOLD ME THAT THEY PUT NEW TIRES ON MY CAR,BUT WHEN IT RAINED MY CAR TIRES WOULD SLIDE IN PUDDLES OF WATER;I WAS FRANTIC.MY KIDS WERE IN THE CAR WITH ME AND WAS SCREAMING AND HOWLING BECAUSE WE ALMOST HAD A ACCIDENT.SO I STOPPED DRIVING THE CAR UNTIL I PURCHASED NEW TIRES.I BOUGHT TIRES FRO…
Read full complaint
WHEN I PURCHASED MY CAR LAST YEAR ;THEY TOLD ME THAT THEY PUT NEW TIRES ON MY CAR,BUT WHEN IT RAINED MY CAR TIRES WOULD SLIDE IN PUDDLES OF WATER;I WAS FRANTIC.MY KIDS WERE IN THE CAR WITH ME AND WAS SCREAMING AND HOWLING BECAUSE WE ALMOST HAD A ACCIDENT.SO I STOPPED DRIVING THE CAR UNTIL I PURCHASED NEW TIRES.I BOUGHT TIRES FROM WAL MART AUTOMOTIVE [THAT WAS IN DECEMBER]BUT IN FEBURARY I EXPERICENCED THE SAME PROBLEM EXCEPT THESE TIRES SPLITTED OPEN AND I PURCHASED TWO MORE TIRES FROM WALMART AND THE GUY THAT CHANGED MY TIRE SAID IT'S NOT AWANNDER IF I DIDN'T KILL MYSELF....BUT HE TOLD ME THAT FIRESTONE WAS RECALLING THESE TIRES AND TOLD ME ABOUT IT.SO WHAT CAN I DO NOW I HAVE THE TIRES AT HOMEO
NHTSA ODI #729984
Mileage unknown · Aug 20, 2000
Suspension
WHEN DRIVING ON ANY SORT OF BUMPY ROAD THERE IS A CONSTANT 'SQUEAK, RUSTY SOUND' IN THE FRONT SUSPENSION. IT SOUNDS LIKE A OLD SQUEAKY BED. ALSO WITH BACKING UP A LOUD LONG SQUEAK COMES FROM THE FRONT END SUPSPENSION. I'VE HAD THE FRONT BRAKES CHANGED AND PADS REPLACED TWICE (DUE TO MECHANICS NEGLIGENCE). AT THIS SAME TIME I…
Read full complaint
WHEN DRIVING ON ANY SORT OF BUMPY ROAD THERE IS A CONSTANT 'SQUEAK, RUSTY SOUND' IN THE FRONT SUSPENSION. IT SOUNDS LIKE A OLD SQUEAKY BED. ALSO WITH BACKING UP A LOUD LONG SQUEAK COMES FROM THE FRONT END SUPSPENSION. I'VE HAD THE FRONT BRAKES CHANGED AND PADS REPLACED TWICE (DUE TO MECHANICS NEGLIGENCE). AT THIS SAME TIME I COMPLAINED ABOUT THE NOISE AND THEY CHECKED IT OUT AND FOUND NO PROBLEMS, BUT THE NOISE IS STILL THERE. IT'S A VERY ANNOYING SOUND ESPECIALLY WHEN DRIVING, YOU THINK EVERYONE AROUND CAN HEAR IT AND ALSO IT SOUNDS AS IF SOMETHING IS GOING TO FALL APART FROM THE FRONT END (?) SUSPENSION!
NHTSA ODI #728488
Mileage unknown · Jul 30, 2000
Engine And Engine Cooling
THE ENGINE HAS STALLED MULTIPLE TIMES WHILE DRIVING. THE DEALER HAS BEEN UNABLE TO IDENTIFY OR RECTIFY THE PROBLEM. THE POWER STEERING AND BRAKES BECOME DIFFICULT TO OPERATE WHEN THE VEHICLE STALLS, AND BECAUSE IT SEEMS TO OCCUR RANDOMLY MAY LEAD TO SUBSTANTIAL INJURY IF THE VEHICLE STALLS WHILE IN TRAFFIC. *AK
NHTSA ODI #726257
Mileage unknown · Jul 29, 2000
Engine And Engine CoolingEquipmentService Brakes, HydraulicCrashInjury
MY CONCERN IS THE CAR IS ONLY 3 YRS OLD AND WE ARE CONTINUEING TO HAVE PROBLEMS OCCUR, THE CIGARETTE LIGHTER HAS A SHORT IN IT AS WELL. *AK
NHTSA ODI #726197
Mileage unknown · Jul 28, 2000
Service Brakes, Hydraulic
BRAKES LOCK WHEN STOPPING RELEASE AND STOP RELEASE AND FINALLY STOP. DISTANCE TRAVELED UNTIL COMPLETE STOP IS ABOUT 10 TO 12 FEET. MY DAUGHTER HAS A 97 CAVALIER AND IT DOES THE SAME THING. THIS IS A VERY SERIOUS SAFETY PROBLEM AND MUST BE FIXED. THE DEALER PERSON SAID THAT IT IS NORMAL ADS ENGAGEMENT. BUT THAT DOESN'T PREVE…
Read full complaint
BRAKES LOCK WHEN STOPPING RELEASE AND STOP RELEASE AND FINALLY STOP. DISTANCE TRAVELED UNTIL COMPLETE STOP IS ABOUT 10 TO 12 FEET. MY DAUGHTER HAS A 97 CAVALIER AND IT DOES THE SAME THING. THIS IS A VERY SERIOUS SAFETY PROBLEM AND MUST BE FIXED. THE DEALER PERSON SAID THAT IT IS NORMAL ADS ENGAGEMENT. BUT THAT DOESN'T PREVENT A CRASH. HE SAID THAT WHEN ONE WHEEL IS NOT ON THE SAME SURFACE AS THE OTHER A DIFFERENT SIGNAL IS SENT TO EACH WHEEL AND THUS THE PROBLEM OF LOCKING AND RELEASING BRAKES. IT SEEMS TO ME THAT THIS IS A SYSTEMIC PROBLEM WITH ANTI LOCK BREAKS THAT ARE PLACING DRIVERS IN A PRECARIOUS POSITION. LUCKY FOR ME THERE WERE NOT VEHICLES IN FRONT OF ME WHEN THE BRAKES ACTED AS THEY DID. OTHERWISE I WOULD HAVE REAR ENDED THE VEHICLE IN FRONT OF ME WITH DAMAGE AND POSSIBLE INJURY TO BOTH OF US. *AK
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence & remedy
Consequence: AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Remedy: DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH MIS-LOCATED WELDS AT THE JOINT BETWEEN THE LEFT ROCKER PANEL INNER REINFORCEMENT AND THE BODY SIDE RING. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 214, "SIDE DOOR STRENGTH."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SHEET METAL STRUCTURE WOULD NOT PERFORM AS DESIRED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE WELDS AND, IF NECESSARY, PLACE FIVE WELDS BETWEEN THE INVOLVED PANELS AND APPLY PRIMER AND TOPCOAT FINISH MATERIALS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COMPACT SPARE TIRE ASSEMBLIES WERE ASSEMBLED WITH INCORRECT RIMS. IF THE SPARE TIRE IS UNDERINFLATED, THE BEAD CAN SEPARATE FROM THE RIM CAUSING A RAPID LOSS OF AIR. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: A RAPID LOSS OF AIR CAN INCREASE THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE RIM ON THE COMPACT SPARE TIRE ASSEMBLY. OWNERS ARE REQUESTED NOT TO USE THE SPARE TIRE UNTIL THE RIM HAS BEEN REPLACED.
THESE VEHICLES WERE BUILT WITH AN INCORRECT WIPER BLADE ASSEMBLY (17" LONG INSTEAD OF 22" LONG) ON THE DRIVER'S SIDE. THIS DOES NOT COMPLY WITH FMVSS NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS."
Consequence & remedy
Consequence: THE AREA AND PATTERN WIPED ON THE WINDSHIELD WILL BE REDUCED AND COULD AFFECT THE DRIVER'S VIEW IN WET WEATHER INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR THE CORRECT WIPER BLADE ASSEMBLY AND INSTALL A CORRECT LENGTH WIPER BLADE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP03007 · Unintended Vehicle Acceleration
Opened Oct 14, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Fuel System, Other:delivery
ON SEPTEMBER 23, 2003, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) RECEIVED A LETTER DATED SEPTEMBER 8, 2003 FROM MR. DONALD FRIEDMAN, PETITIONING THE AGENCY TO OPEN A DEFECT INVESTIGATION INTO UNINTENDED ACCELERATION INVOLVING [MODEL YEAR] 1996 AND 1997 GENERAL MOTORS J-CARS.IN SUPPORT OF HIS PETITION, MR. FRIEDMAN CITED A REPORT HE RECEIVED FOR GM SHOWING IT HAD RECEIVED FAR MORE REPORTS OF ALLEGED UNINTENDED ACCELERATION FOR THESE MODELS THAN FOR OTHERS.AFTER ASSESSING THE DATA CLAIMED BY THE PETITIONER TO JUSTIFY HIS REQUEST, ODI FOUND NO INDICATION THAT DEFECT TREND RELATED TO THE PETITIONER'S ALLEGATIONS EXISTS AT THIS TIME.THEREFORE, THERE IS NO REASONABLE POSIBILITY THAT AN ORDER CONCERNING THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT WOULD BE ISSUED AS A RESULT OF GRANTING MR. FRIEDMAN'S PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE ATTACHED FEDERAL REGISTER NOTICE.
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
EA98001 · Oversensitive Air Bag Deployments
Opened Jan 23, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE97041 · Inadvertent Air Bag Deployments
Opened Sep 9, 1997 · Closed Jan 23, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
1997 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration