Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 88 of 540 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
70 crash reports25 fire reports60 injury reports
What owners actually said
540 reports
135,000 miles · Oct 26, 2009
Air Bags
WHILE DRIVING AT 55MPH THE PASSENGER SIDE AIRBAG DEPLOYED. WHEN THE AIRBAG DEPLOYED IT RIPPED APART THE DASH AND BUSTED THE WINDSHIELD. LUCKILY MY SON WAS NOT INJURED AND MANAGED TO KEEP THE CAR UNDER CONTROL TO GET IT OFF THE HIGHWAY WITHOUT HAVING AN ACCIDENT. WHEN GM WAS CONTACTED THEY SAID SORRY THIS CAR WAS NOT AFFECTED BY …
Read full complaint
WHILE DRIVING AT 55MPH THE PASSENGER SIDE AIRBAG DEPLOYED. WHEN THE AIRBAG DEPLOYED IT RIPPED APART THE DASH AND BUSTED THE WINDSHIELD. LUCKILY MY SON WAS NOT INJURED AND MANAGED TO KEEP THE CAR UNDER CONTROL TO GET IT OFF THE HIGHWAY WITHOUT HAVING AN ACCIDENT. WHEN GM WAS CONTACTED THEY SAID SORRY THIS CAR WAS NOT AFFECTED BY THE RECALL FOR THE AIRBAGS. *TR
NHTSA ODI #10289883
Mileage unknown · Oct 5, 2009
Electrical SystemFire
I BOUGHT THIS CAR USED LAST YEAR FOR MY DAUGHTER. WE HAVE BEEN HAVING PROBLEMS WITH THE KEY TO START, THE KEY WAS LEFT IN THE START POSITION A FEW TIMES TRYING TO GET STARTED. WE NOTICED A SPARK COME FROM THE COLUMN AND NOTHING. I NOTICED THAT THERE WAS A RECALL ON THE IGNITION SWITCH DOING THE SAME THING AS I STATED ABOVE. D…
Read full complaint
I BOUGHT THIS CAR USED LAST YEAR FOR MY DAUGHTER. WE HAVE BEEN HAVING PROBLEMS WITH THE KEY TO START, THE KEY WAS LEFT IN THE START POSITION A FEW TIMES TRYING TO GET STARTED. WE NOTICED A SPARK COME FROM THE COLUMN AND NOTHING. I NOTICED THAT THERE WAS A RECALL ON THE IGNITION SWITCH DOING THE SAME THING AS I STATED ABOVE. DEALERSHIP WILL NOT HONOR RECALL BECAUSE NOW THEY ARE STATING THE LOCK CYLINDER MECHANISM IS BROKE AND THEY CANT GET INTO THE COLUMN WITHOUT BREAKING IT. THIS IS RIDICULOUS THAT NOW THAT IT IS FAILED THEY WON'T FIX THE CAR. *TR
NHTSA ODI #10286349
Mileage unknown · Apr 11, 2009
Fuel System, Gasoline
HAVE HAD FUEL LINE, AND FUEL PUMP REPLACED. STILL GET A STRONG SMELL OF GAS.... CAN NOT GET RID OF THE ODOR. THERE IS NOT A GAS LEAK THAT IS VISIBLE TO THE HUMAN EYE BUT THE SCENT STILL LINGERS INSIDE AND OUT. *TR
NHTSA ODI #10264997
Mileage unknown · Feb 16, 2009
Fuel System, Other
CALLED TO HAVE RECALL NUMBER 07E015000 AT DELPHI. PAUL (CUSTOMER SERVICE REP) CLEARLY WOULD NOT LET ME HAVE THE RECALL., AFTER ANSWERING ALL THE QUESTION. *TR
NHTSA ODI #10258771
135,000 miles · Dec 15, 2008
Structure
MY SUB-FRAME HAS BROKEN TWICE ON MY CAVALIER. I DON'T WANT TO REPAIR IT ANYMORE!!! *TR
NHTSA ODI #10251849
137,000 miles · Dec 15, 2008
Structure
MY CAVALIER FRAME ROTTED AND BROKE. THIS IS VERY SERIOUS DO TO THE FACT THAT I LOST CONTROL OF MY VEHICLE AND ALMOST CRASHED. *TR
NHTSA ODI #10251847
13,600 miles · Sep 10, 2008
Tires
I HAVEN'T HAD AN INCIDENT YET. ALL 4 OF MY TIRES ARE CRACKED IN THE SAME AREA AROUND THE TIRE. LEADING ME TO BELIEVE IT IS A MANUFACTURES DEFECT. *TR
NHTSA ODI #10241702
Mileage unknown · Aug 22, 2008
Air BagsVisibility
1997 CHEVROLET CAVALIER AIR BAGS DEPLOYED FOR NO REASON. *NJ AN INSPECTION REVEALED NO MECHANICAL REASON FOR THE DEPLOYMENT OF THE AIR BAG. ALSO, THE SUNROOF WAS INOPERATIVE. THE CONSUMER WAS INFORMED HER VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL FOR THE AIR BAG. *JB
NHTSA ODI #10239352
Mileage unknown · Jun 21, 2008
Engine And Engine Cooling
I JUST GOT A USED CHEVY CAVALIER A 97 MODEL AND IT OVER HEATS CONSTANTLY AND THERE IS A POP AN SPARKS WHEN STARTING THE CAR AND THE LIGHTS WON'T TURN OFF AND NOW THERE IS WOBBLING IN THE PASSENGER SIDE WHEEL AND WHITE SMOKE COMING OUT THE BACK . I ONLY HAD IT FOR MAYBE TWO DAYS NOW AND THE FAN TO THE MOTOR WON'T COME ON NOW …
Read full complaint
I JUST GOT A USED CHEVY CAVALIER A 97 MODEL AND IT OVER HEATS CONSTANTLY AND THERE IS A POP AN SPARKS WHEN STARTING THE CAR AND THE LIGHTS WON'T TURN OFF AND NOW THERE IS WOBBLING IN THE PASSENGER SIDE WHEEL AND WHITE SMOKE COMING OUT THE BACK . I ONLY HAD IT FOR MAYBE TWO DAYS NOW AND THE FAN TO THE MOTOR WON'T COME ON NOW AND I TOOK IT BACK TO THE CAR LOT WHERE I BOUGHT IT FROM THEY HAVE REPLACES THE THERMOSTAT( AIRCONDITIONER THING ) BUT IT' STILL OVER HEATS .. AND THEN I LOOK IN MY BOOK , AND IT GIVES A WEB SITE AND THERE IS ALL THESE RECALLS AND THE GUY TELLS ME WHEN I CALL THAT THE THINGS GOING ON WITH MY CAR ARE NOT IN THE RECALL LIST ACCEPT FOR THE SOMETHING TO DO WITH SPEED BUT IF THAT IS THE CASE WHY IS THE LIGHTS NOT CUTTING OFF AND THE CAR DOING ALL THESE THINGS .. I HAD A PERSON LOOK AT IT WHO WORKS ON CARS AND THEY TOLD ME THAT THE SPARK IS ON THE FUEL INJECTION SIDE OF THE MOTOR AND I WAS LUCKY I DIDN'T GO UP IN FLAMES .. IS THERE ANY HELP IN FIXING THIS CAR SINCE THESE ARE DEFECTS ? *TR
NHTSA ODI #10231874
75,000 miles · Jun 5, 2008
Electrical System
I HAVE BEEN HAVING TROUBLE STARTING MY CHEVY CAVALIER. THE PROBLEM IS THE THEFT SYSTEM. I AM A SINGLE MOTHER AND THE CHEVY PLACE SAID IT WOULD BE 400 DOLLARS TO FIX. I HAVE READ THAT ALOT OF CHEVY OWNERS HAVE THE SAME PROBLEM. PLEASE HAVE THIS RECALL. I BEG YOU THANKS *TR
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence & remedy
Consequence: AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Remedy: DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH MIS-LOCATED WELDS AT THE JOINT BETWEEN THE LEFT ROCKER PANEL INNER REINFORCEMENT AND THE BODY SIDE RING. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 214, "SIDE DOOR STRENGTH."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SHEET METAL STRUCTURE WOULD NOT PERFORM AS DESIRED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE WELDS AND, IF NECESSARY, PLACE FIVE WELDS BETWEEN THE INVOLVED PANELS AND APPLY PRIMER AND TOPCOAT FINISH MATERIALS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COMPACT SPARE TIRE ASSEMBLIES WERE ASSEMBLED WITH INCORRECT RIMS. IF THE SPARE TIRE IS UNDERINFLATED, THE BEAD CAN SEPARATE FROM THE RIM CAUSING A RAPID LOSS OF AIR. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: A RAPID LOSS OF AIR CAN INCREASE THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE RIM ON THE COMPACT SPARE TIRE ASSEMBLY. OWNERS ARE REQUESTED NOT TO USE THE SPARE TIRE UNTIL THE RIM HAS BEEN REPLACED.
THESE VEHICLES WERE BUILT WITH AN INCORRECT WIPER BLADE ASSEMBLY (17" LONG INSTEAD OF 22" LONG) ON THE DRIVER'S SIDE. THIS DOES NOT COMPLY WITH FMVSS NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS."
Consequence & remedy
Consequence: THE AREA AND PATTERN WIPED ON THE WINDSHIELD WILL BE REDUCED AND COULD AFFECT THE DRIVER'S VIEW IN WET WEATHER INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR THE CORRECT WIPER BLADE ASSEMBLY AND INSTALL A CORRECT LENGTH WIPER BLADE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP03007 · Unintended Vehicle Acceleration
Opened Oct 14, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Fuel System, Other:delivery
ON SEPTEMBER 23, 2003, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) RECEIVED A LETTER DATED SEPTEMBER 8, 2003 FROM MR. DONALD FRIEDMAN, PETITIONING THE AGENCY TO OPEN A DEFECT INVESTIGATION INTO UNINTENDED ACCELERATION INVOLVING [MODEL YEAR] 1996 AND 1997 GENERAL MOTORS J-CARS.IN SUPPORT OF HIS PETITION, MR. FRIEDMAN CITED A REPORT HE RECEIVED FOR GM SHOWING IT HAD RECEIVED FAR MORE REPORTS OF ALLEGED UNINTENDED ACCELERATION FOR THESE MODELS THAN FOR OTHERS.AFTER ASSESSING THE DATA CLAIMED BY THE PETITIONER TO JUSTIFY HIS REQUEST, ODI FOUND NO INDICATION THAT DEFECT TREND RELATED TO THE PETITIONER'S ALLEGATIONS EXISTS AT THIS TIME.THEREFORE, THERE IS NO REASONABLE POSIBILITY THAT AN ORDER CONCERNING THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT WOULD BE ISSUED AS A RESULT OF GRANTING MR. FRIEDMAN'S PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE ATTACHED FEDERAL REGISTER NOTICE.
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
EA98001 · Oversensitive Air Bag Deployments
Opened Jan 23, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE97041 · Inadvertent Air Bag Deployments
Opened Sep 9, 1997 · Closed Jan 23, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
1997 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration