IllustrationMY 2001 CHEVY BLAZER CHANGES FROM 2WH TO 4 WHEEL DRIVE AUTOMATICALLY WHILE THE VEHICLE IS MOVING. THIS ISN'T THE FIRST TIME THIS HAS HAPPENED. I WAS ABLE TO GET MY CAR OFF OF THE ROAD SAFELY AND CHANGE IT BACK INTO 2WH, BUT IT KEPT SWITCHING BACK INTO 4 WHEEL DRIVE. THERE IS EVIDENTLY A DEFECT. *TR
2001 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2001 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
3525–50K
4550–75K
2275–100K
18100–150K
7150K+
142 reports with mileage · 184 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
35 crash reports5 fire reports19 injury reports
What owners actually said
326 reportsTL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE STEERING COLUMN AND THE BRAKE LIGHTS WERE INOPERABLE. WHEN THE IGNITION WAS TURNED OFF, THE ENGINE WOULD STILL OPERATE. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS TO TURN OFF THE VEHICLE. THERE WERE NO WAR…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE STEERING COLUMN AND THE BRAKE LIGHTS WERE INOPERABLE. WHEN THE IGNITION WAS TURNED OFF, THE ENGINE WOULD STILL OPERATE. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS TO TURN OFF THE VEHICLE. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURES WERE RELATED TO A DEFECTIVE MULTI-FUNCTION SWITCH. THE VEHICLE WAS REPAIRED. THE CONTACT EXPERIENCED FAILURES IDENTICAL TO THE ONES MENTIONED IN A PRIOR TWO PART RECALL. THE CONSUMER ASSUMED THE RECALL WAS PERFORMED, HOWEVER SHE LEARNED THAT THE RECALL WAS NOT PERFORMED COMPLETELY. THE CONSUMER BEGAN HAVING PROBLEMS WITH THE MULTI-FUNCTION SWITCH. THE PART THAT THE CONSUMER THOUGHT WAS REPLACED BACK IN 2002 WAS NEVER REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 31,138. THE CONSUMER IS SEEKING REIBURSEMENT. UPDATED 09/19/08. *JB
TL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. THE CONTACT RECEIVED A SAFETY RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 01V364000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH). THE CONTACT STATED THAT THE MULTIFUNCTIONAL SWITCH FAILED, AND THE DEALER WILL NOT REPAIR IT UNDER RECALL. THE CURRENT AND FAILURE MILEAGES WERE 122,300.
THE "ABS" AND "BRAKE SYSTEM" LIGHTS STAY COME ON AND STAY ON AT DIFFERENT TIMES. I HAVE HAD THE BRAKES CHECKED AND THE SYSTEM CHECKED AND THEY ARE COMING ON FOR NO REASON. *TR
THE EVENTS THAT LEAD UP TO THE FAILURE OF THE FUEL INJECTION SYSTEM EQUIPPED ON MY 2001 CHEVROLET BLAZER ARE IN CORRELATION TO THE MANUFACTURERS KNOWLEDGE OF HAVING INSTALLED A DEFECTIVE PRODUCT ON 1996 - 2002 VEHICLES WITH SEQUENTIAL CENTRAL PORT INJECTION. AFTER HAVING TO DEAL WITH THE PROBLEM OF FIGURING OUT HOW TO FIX THE C…
Read full complaint
THE EVENTS THAT LEAD UP TO THE FAILURE OF THE FUEL INJECTION SYSTEM EQUIPPED ON MY 2001 CHEVROLET BLAZER ARE IN CORRELATION TO THE MANUFACTURERS KNOWLEDGE OF HAVING INSTALLED A DEFECTIVE PRODUCT ON 1996 - 2002 VEHICLES WITH SEQUENTIAL CENTRAL PORT INJECTION. AFTER HAVING TO DEAL WITH THE PROBLEM OF FIGURING OUT HOW TO FIX THE CODE P0300( RANDOM CYLINDER MISFIRE) ON MY 01 BLAZER, I REALIZED IT WAS TIME TO GET MORE HELP FROM OUTSIDE SOURCES WHO HAVE EXPERIENCED SIMILAR ISSUES WITH THEIR VEHICLES. I'VE DONE ENOUGH RESEARCH TO KNOW NOW THAT AFTER EIGHT YEARS OF OWNING THE TRUCK AND DUMPING MONEY INTO UNNECESSARY REPAIRS THAT CHEVROLET SHOULD FIX THIS PROBLEM AT THEIR COST SINCE THEY KNEW ABOUT IT AFTER BEING INVESTIGATED BY THE CALIFORNIA EPA RESEARCH DIVISION ON AIR POLLUTION BACK IN 2003. THEY FOUND THE SCPI SYSTEM INSTALLED ON MODELS BETWEEN 1996 AND 2002 TO BE FAULTY CREATING A PROBLEM WITH THE START UP OF MANY SUVS WHICH LEAD TO EMISSIONS FAILURE. I'M RESEARCHING THIS NOW BECAUSE I'VE FINALLY CONNECTED THE DOTS AND REALIZE THAT CHEVROLET KNEW ABOUT THIS PROBLEM MANY YEARS AGO AND THEY CUT A DEAL WITH THE EPA TO EXTEND THE WARRANTY COVERAGE ON SUCH VEHICLES FOR 10 YEARS OR 200K MILES IN AN ATTEMPT TO SATISFY CALIFORNIA REGULATIONS. WELL, WHAT ABOUT THE REST OF THE UNITED STATES AND HOW WE DEAL WITH AIR POLLUTION. I THOUGHT GM AND CHEVROLET WANTED TO BE THE COMPANY THAT WOULD SET THE EXAMPLE IN "GOING GREEN" FOR OUR PLANET. IT DOESN'T MAKE SENSE UNTIL YOU REALIZE THE AMOUNT OF MONEY THAT THEY SAVE BY NOT HAVING TO REPLACE FAULTY FUEL SYSTEMS ON OLDER MODEL VEHICLES WHICH HAPPEN TO BE DRIVEN BY PEOPLE WHO ARE A LOT SMARTER THAN THEY THINK. I'VE TAKEN THE LIBERTY OF FILING MY CLAIM WITH CHEVY TO RESOLVE THIS ISSUE. I'M HOPING THAT THIS COMPLAINT ALONG WITH VALUABLE INFORMATION ON THE INTERNET AS WELL AS YOUR WEB SITE CAN INFORM OTHERS OF THEIR RIGHTS AND HOW WE SHOULD ALL BE COVERED UNDER WARRANTY TO FIX THE PROBLEM PERMANENTLY. THANK YOU FOR YOUR TIME. *TR
TL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. THE VEHICLE HAS FATE RANGE RUNNER HT TIRES, SIZE 235/75R15 (NA). THE CONTACT DISCOVERED THAT THE DOT NUMBER HAD BEEN MECHANICALLY REMOVED FROM ALL FOUR TIRES WHEN HE HAD THEM ROTATED AND BALANCED. HE INTENDS TO CALL THE DEALER AND THE MANUFACTURER AS SOON AS POSSIBLE. THE CURRENT …
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. THE VEHICLE HAS FATE RANGE RUNNER HT TIRES, SIZE 235/75R15 (NA). THE CONTACT DISCOVERED THAT THE DOT NUMBER HAD BEEN MECHANICALLY REMOVED FROM ALL FOUR TIRES WHEN HE HAD THEM ROTATED AND BALANCED. HE INTENDS TO CALL THE DEALER AND THE MANUFACTURER AS SOON AS POSSIBLE. THE CURRENT MILEAGE WAS 101,886 AND FAILURE MILEAGE WAS 101,851.
LOST DASH LIGHT AND GAUGES. *TR
AFTER PULLING INTO THE PARKING LOT OF WORK, I WAS GETTING OUT OF THE VEHICLE AND THE SPRING THAT WAS ATTACHED TO THE TRUCK DOOR JUST FELL OFF AND ON THE GROUND. NOW, AS THE TIME IS PASSING THE INTERIOR LIGHT DOESN'T WORK AND THE ELECTRICAL PANEL ON THE DRIVER'S DOOR IS GETTING WORSE. I CAN ONLY LOCK THE DRIVER'S DOOR FROM THE O…
Read full complaint
AFTER PULLING INTO THE PARKING LOT OF WORK, I WAS GETTING OUT OF THE VEHICLE AND THE SPRING THAT WAS ATTACHED TO THE TRUCK DOOR JUST FELL OFF AND ON THE GROUND. NOW, AS THE TIME IS PASSING THE INTERIOR LIGHT DOESN'T WORK AND THE ELECTRICAL PANEL ON THE DRIVER'S DOOR IS GETTING WORSE. I CAN ONLY LOCK THE DRIVER'S DOOR FROM THE OUTSIDE AND THE ALARM GOES OFF EVERYTIME I OPEN THE DOOR. I HAVE TO KEEP SLAMMING IT TO MAKE THE DOOR COMPLETELY CLOSE. I HAVEN'T BEEN TO ANYONE YET BECAUSE I BELIEVE THIS WILL BE A BIG EXPENSE. *TR
TL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. ALL OF THE BRAKE LIGHTS MALFUNCTIONED EXCEPT FOR THE WINDOW BRAKE LIGHT. THE VEHICLE WAS NOT INSPECTED BY A DEALER. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 01V364000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH). THE CURRENT AN…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. ALL OF THE BRAKE LIGHTS MALFUNCTIONED EXCEPT FOR THE WINDOW BRAKE LIGHT. THE VEHICLE WAS NOT INSPECTED BY A DEALER. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 01V364000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH). THE CURRENT AND FAILURE MILEAGES WERE 31,000.
I HAVE A 2001 CHEVROLET BLAZER THAT RECENTLY HAD TO BE REPAIRED. I FEEL THAT A RECALL ITEM SHOULD COVER COST OF THE REPAIR. THE CHEVROLET CUSTOMER REPRESENTATIVE THAT I SPOKE TO SAID THAT IT IS NOT COVERED BY THE RECALL. IN A NUTSHELL, THE SYMPTOMS THAT THE CAR HAD ARE EXACTLY THE SAME AS THOSE MENTIONED IN NHTSA CAMPAIGN ID NUM…
Read full complaint
I HAVE A 2001 CHEVROLET BLAZER THAT RECENTLY HAD TO BE REPAIRED. I FEEL THAT A RECALL ITEM SHOULD COVER COST OF THE REPAIR. THE CHEVROLET CUSTOMER REPRESENTATIVE THAT I SPOKE TO SAID THAT IT IS NOT COVERED BY THE RECALL. IN A NUTSHELL, THE SYMPTOMS THAT THE CAR HAD ARE EXACTLY THE SAME AS THOSE MENTIONED IN NHTSA CAMPAIGN ID NUMBER : 01V364000. BOTH REAR, OUTSIDE STOPLIGHTS STOPPED WORKING. THE CENTER STOP AND THE TURN SIGNALS WORKED FINE. I HAD THE CAR REPAIRED AT A COST OF $470.29. ON THE INVOICE THE ITEM REPLACED IS A MULTIFUNCTION SWITCH? *TR
Official recalls
308V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.