NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
40 reportsClear category filterMileage unknown · May 27, 2023
Electrical SystemService BrakesSuspension
Chevy Blazer has low milage. However, it still has several electrical issues radio at engine start goes to loudest point and car seats move backwards at awkward times which can cause an accident. Suspension very off guard, truck drifts to the sides while driving and makes an awkward sound when turning steering wheel. The complet…
Read full complaint
Chevy Blazer has low milage. However, it still has several electrical issues radio at engine start goes to loudest point and car seats move backwards at awkward times which can cause an accident. Suspension very off guard, truck drifts to the sides while driving and makes an awkward sound when turning steering wheel. The complete break / steering system is off and may cause an accident if not properly take care right away. I have no money to do this big job. Please remediate.
NHTSA ODI #11524128
59,892 miles · May 15, 2007
Power TrainSuspension
FRONT WHEEL BEARINGS HAD TO BE REPLACED FOR A SECOND TIME. THE CAR HAS ONLY 60,000 MILES ON IT! THE SECOND TIME, THE BEARINGS WERE NO LONGER COVERED UNDER WARRANTY AND I INCURRED OVER $1000 IN REPAIR COSTS. *AK
NHTSA ODI #10190771
74,000 miles · Apr 13, 2007
Suspension
TL*- THE CONTACT OWNS A 2001 CHEVROLET BLAZER. WHILE DRIVING THE UPPER BALL JOINT SNAPPED AND THE WHEEL COLLAPSED SIDEWAYS, LEANING TOWARDS THE INSIDE OF THE VEHICLE, BUT THE VEHICLE CONTINUED TO TRAVEL AT 70 MPH. THE CONTACT HAD THE VEHICLE TOWED, AND REPLACED THE BALL JOINT AS WELL AS ANYTHING THAT MIGHT HAVE BEEN DAMAGED HI…
Read full complaint
TL*- THE CONTACT OWNS A 2001 CHEVROLET BLAZER. WHILE DRIVING THE UPPER BALL JOINT SNAPPED AND THE WHEEL COLLAPSED SIDEWAYS, LEANING TOWARDS THE INSIDE OF THE VEHICLE, BUT THE VEHICLE CONTINUED TO TRAVEL AT 70 MPH. THE CONTACT HAD THE VEHICLE TOWED, AND REPLACED THE BALL JOINT AS WELL AS ANYTHING THAT MIGHT HAVE BEEN DAMAGED HIMSELF. THE CURRENT MILEAGE WAS 76,000 AND THE FAILURE MILEAGE WAS 74,000.*AK
NHTSA ODI #10187784
68,470 miles · Dec 29, 2006
Suspension
HAD A TERRIBLY LOUD NOISE IN THE FRONT END OF OUR 2001 CHEVY BLAZER AND FOUND OUT IT WAS A FRONT WHEEL HUB AND BEARING ASSEMBLY, COST $439.81. NOW ONE YEAR LATER THE OTHER SIDE HAS GONE AND HAD TO BE REPLACED, WE HAVE ALMOST $900. INTO THIS REPAIR THAT I NOW SEE APPEARS TO BE A FREQUENT PROBLEM WITH THIS VEHICLE. GENERAL MOTORS …
Read full complaint
HAD A TERRIBLY LOUD NOISE IN THE FRONT END OF OUR 2001 CHEVY BLAZER AND FOUND OUT IT WAS A FRONT WHEEL HUB AND BEARING ASSEMBLY, COST $439.81. NOW ONE YEAR LATER THE OTHER SIDE HAS GONE AND HAD TO BE REPLACED, WE HAVE ALMOST $900. INTO THIS REPAIR THAT I NOW SEE APPEARS TO BE A FREQUENT PROBLEM WITH THIS VEHICLE. GENERAL MOTORS NEEDS TO BE ACCOUNTABLE FOR THERE PRODUCTS, EITHER ON THERE OWN OR FORCED TO DO SOME TYPE OF RECALL. WE ALSO HAD TO HAVE THE BRAKE LIGHT RECALL TAKEN CARE OF
NHTSA ODI #10177364
159,097 miles · Dec 28, 2006
Fuel System, GasolinePower TrainService Brakes, Hydraulic
SINCE I BOUGHT MY 2001 CHEVY BLAZER, I'VE HAD TO REPLACE BALL JOINTS EVERYTIME I HAVE A FRONT END ALIGNMENT. THIS YEAR I'VE REPLACED 3 WHEEL BEARINGS, FUEL PUMP, AND I JUST LOST MY TRANSMISSION. I'VE HAD THE LIGHT RECALL FIXED. MY SERVICE ENGINE LIGHT STAYS ON, BUT YOU CANNOT PUT A COMPUTER TO IT BECAUSE IT DOESN'T WORK. MY ABS…
Read full complaint
SINCE I BOUGHT MY 2001 CHEVY BLAZER, I'VE HAD TO REPLACE BALL JOINTS EVERYTIME I HAVE A FRONT END ALIGNMENT. THIS YEAR I'VE REPLACED 3 WHEEL BEARINGS, FUEL PUMP, AND I JUST LOST MY TRANSMISSION. I'VE HAD THE LIGHT RECALL FIXED. MY SERVICE ENGINE LIGHT STAYS ON, BUT YOU CANNOT PUT A COMPUTER TO IT BECAUSE IT DOESN'T WORK. MY ABS LIGHT COMES AND GOES. WHATS NEXT? *NM
NHTSA ODI #10177263
63,000 miles · Feb 24, 2006
Service Brakes, HydraulicSteeringSuspension
FRONT END, BOTH WHEEL BEARINGS AT 60,000 MILES, IDLER ARM, REPLACE TIRES, ABS LIGHT. *JB
NHTSA ODI #10151154
35,000 miles · Oct 18, 2005
Parking BrakeService Brakes, HydraulicSuspension
1) ABS AND E-BRAKE LIGHT CONTINUALLY COME ON; UNSURE IF ABS SYSTEM IS FUNCTIONAL; I HAVE HAD THE COMPUTER TESTED AND IT RETURNED NO FAULTS 2) SIDE WINDOWS WORK INTERMITTENTLY; NO EXPLANATION; WINDOWS WILL NOT ROLL DOWN FOR DAYS AT A TIME AND THEN THEY WORK FINE FOR DAYS AT A TIME 3) SUNROOF NO LONGER FUNCTIONAL; CHEVY DEALE…
Read full complaint
1) ABS AND E-BRAKE LIGHT CONTINUALLY COME ON; UNSURE IF ABS SYSTEM IS FUNCTIONAL; I HAVE HAD THE COMPUTER TESTED AND IT RETURNED NO FAULTS 2) SIDE WINDOWS WORK INTERMITTENTLY; NO EXPLANATION; WINDOWS WILL NOT ROLL DOWN FOR DAYS AT A TIME AND THEN THEY WORK FINE FOR DAYS AT A TIME 3) SUNROOF NO LONGER FUNCTIONAL; CHEVY DEALER SAID THE "HEAT" WARPED THE INTERNAL PARTS AND THEY BROKE AS I ROLLED IT BACK; WEATHER WAS MILD AND THE BREAKAGE HAPPENED AT 0500 IN THE AM; I DON'T BELIEVE IT WAS HEAT RELATED 4) REAR OF VEHICLE IS HAS DRASTICALLY FALLEN BELOW THE FRONT; I HAVE NO EXPLANATION AS TO WHY; IT LOOKS AS IF THE VEHICLE FRONT SUSPENSION WAS RAISED AND THE REAR WAS LOWERED; DRIVES FINE, BUT FEELS UNSAFE ALL OF THE ABOVE HAPPENED SHORTLY AFTER THE WARRANTY EXPIRED, BETWEEN 40000-50000 MILES. *NM
NHTSA ODI #10140181
40,000 miles · Sep 10, 2005
Fuel System, OtherService Brakes, HydraulicSuspension
NOT ONLY HAVE I HAD PROBLEMS EARLY WITH HUB AND BEARING-- AND ALSO REPLACED BALL BEARING-- NOW THE ABS-- MANUFACTURERS HAS DONE POOR JOB ON BRAKE. WHEEL PARTS- VERY CHEAP PARTS-- MANY TALK ABOUT IT AND KNOW THAT THE BLAZER HAS HAD PROBLEMS WITH THESE PARTS. MY FAMILY HAS PURCHASED CHEVY'S FOR YEARS-- I AM NOW NEVER ABOUT TO PURC…
Read full complaint
NOT ONLY HAVE I HAD PROBLEMS EARLY WITH HUB AND BEARING-- AND ALSO REPLACED BALL BEARING-- NOW THE ABS-- MANUFACTURERS HAS DONE POOR JOB ON BRAKE. WHEEL PARTS- VERY CHEAP PARTS-- MANY TALK ABOUT IT AND KNOW THAT THE BLAZER HAS HAD PROBLEMS WITH THESE PARTS. MY FAMILY HAS PURCHASED CHEVY'S FOR YEARS-- I AM NOW NEVER ABOUT TO PURCHASE A CHEVY AGAIN. WHILE I PAY MY CAR PAYMENT, I ALWAYS PURCHASE NEW. I AM ALWAYS ALSO PAYING FOR WORK DONE ON THIS VEHICLE, AND I AM TALKING- OVER 2,000 SO FAR AND AGAIN HAVE TO GO IN TODAY-- I MAY EVEN TRADE IT IN I AM SO PISSED. WE ALSO HAD PROBLEMS WITH MY HUSBANDS TRUCK..I DON'T KNOW WHAT THEY DID, OR WHO THEY PURCHASED THEIR PARTS FROM, BUT SURELY WENT TO CHEAP PARTS, THEY( CHEVY) PUT MANY CONSUMERS IN A BAD SPOT. AND I HAVE WRITTEN A COMPLAINT BEFORE- WHEN I HAD THE CHEVY BLAZER 2001 FOR A YEAR HALF. THEY SEEM TO WANT TO ONLY HEAR IF I DIED CAUSE OF THE FAILURES THAT IT WOULD BE LOOKED INTO. *JB
NHTSA ODI #10136071
56,218 miles · Jul 11, 2005
Suspension
MY 2001 CHEVY BLAZER HAD UNEVEN TIRE WEAR INDICATING THE NEED FOR A FRONT END ALIGNMENT. DURING THE INSPECTION I WAS INFORMED THAT THE LOWER BALL JOINTS HAD TO BE REPLACED AS WELL AS THE IDLER ARM AND SHOULD DO THE UPPER JOINTS AS WELL. I HAD NEVER HEARD OF A VEHICLE WITH 56,000 MILES NEEDING TO HAVE THIS DONE. OF COURSE, NOW…
Read full complaint
MY 2001 CHEVY BLAZER HAD UNEVEN TIRE WEAR INDICATING THE NEED FOR A FRONT END ALIGNMENT. DURING THE INSPECTION I WAS INFORMED THAT THE LOWER BALL JOINTS HAD TO BE REPLACED AS WELL AS THE IDLER ARM AND SHOULD DO THE UPPER JOINTS AS WELL. I HAD NEVER HEARD OF A VEHICLE WITH 56,000 MILES NEEDING TO HAVE THIS DONE. OF COURSE, NOW I HEAR OF MANY OWNERS HAVING THE SAME PROBLEM. THE UNEXPECTED $900 BILL WAS NOT PLEASANT! THE MECHANIC SAID IT WAS A COMMON PROBLEM THAT HE SAW WITH CHEVY PRODUCTS. DO I HAVE ANY CHANCE OF BEING COMPENSATED FOR THE LESS THAN QUALITY PARTS INSTALLED ON MY VEHICLE?
NHTSA ODI #10128382
60,000 miles · Jan 6, 2005
SteeringSuspension
I OWN A 2001 CHEVROLET 2DR 2WHEEL DRIVE BLAZER. THE WHEEL BEARINGS AND SPINDLE / PARTS HAVE ALREADY NEEDED TO BE REPLACED ON BOTH SIDES/FRONT. I FOUND THIS PROBLEM BECAUSE THE WHEEL OF MY FRONT PASSENGER SIDE CAME OFF WHILE I WAS DRIVING. THANKFULLY I HEARD THE GRINDING AND SLOWED MY SPEED TO 5-6 MPH AND HAD TURNED MY HAZARD LIG…
Read full complaint
I OWN A 2001 CHEVROLET 2DR 2WHEEL DRIVE BLAZER. THE WHEEL BEARINGS AND SPINDLE / PARTS HAVE ALREADY NEEDED TO BE REPLACED ON BOTH SIDES/FRONT. I FOUND THIS PROBLEM BECAUSE THE WHEEL OF MY FRONT PASSENGER SIDE CAME OFF WHILE I WAS DRIVING. THANKFULLY I HEARD THE GRINDING AND SLOWED MY SPEED TO 5-6 MPH AND HAD TURNED MY HAZARD LIGHTS ON. FROM WHAT I AM LEARNING THIS IS A PROBLEM THAT IS SOME WHAT COMMON WITH MY MAKE/MODEL VEHICLE. I HAVE ALSO SEEM COMPLAINTS OF THIS NATURE ON CANADIAN AUTO CLUB SITES. *AK
NHTSA ODI #10105877
Official recalls
3May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration