2013 CAN-AM Spyder Rt

THIS IS MY 2ND REPORT, I RODE THE SPYDER AGAIN YESTERDAY AND I BURNED MY INNER THIGHS AND MY RIGHT CALF FROM THE EXTREME HEAT COMING FROM UNDER THE SEAT AND A VENT ON THE RIGHT SIDE. THE ENGINE TEMPERATURE IS NOT SHOWING IT RUNNING HOT. THERE IS A DESIGN FLAW THE BODY PLASTICS NOT ALLOWING PROPER VENTING FOR THE HEAT. THIS IS MY SECOND SPYDER, MY FIRST WAS A 2008 MODEL AND NEVER HAD PROBLEMS WITH THE ENGINE HEAT, I HAD 25,000 MILES ON IT BEFORE I SOLD IT AND BOUGHT THIS PILE OF JUNK, I HAVE LEFT MANY E-MAILS ON BRP'S WEBSITE AND HAVE NEVER GOTTEN A REPLY, *TR

HEAT BUILD UP UNDER BODY PANELS AND SEAT AT LOW AND HIGH SPEED, CAUSING BODILY DISCOMFORT, RYDER AND PASSENGER, TO THE POINT OF NEEDING MEDICATION TO THE AFFECTED AREAS COMING IN CONTACT WITH PANELS AND SEAT. GAS CAP HOT-TO-TOUCH, BUILDING UP PRESSURE IN TANK AND CAUSING GAS TO BLOW OUT OF FILLER WHEN REMOVING CAP. ERRATIC GAS FUMES AT ANY TIME. *TR

I HAVE HAD THE 2013 SPYDER RTS SINCE 6-24-2014. EVER SINCE GETTING IT THERE HAS BEEN EXCESSIVE HEAT COMING FROM THE BIKE, ESPECIALLY ON THE RIGHT SIDE WHERE THE RADIATOR EXHAUST IS VENTED. THE BIKE GETS EXTREMELY HOT WHETHER SITTING STILL OR MOVING. I HAVE DONE MODIFICATION IN AN EFFORT TO REDUCE THE HEAT, AS SUGGESTED ON SPYDERLOVERS.COM BY OTHER SPYDER OWNERS. THE MEASURES HAVEN'T REALLY HELPED AND THE BIKE IS STILL WAY TO HOT! *TR

AFTER RIDING THIS MOTORCYCLE FOR AS LITTLE AS 15 MINUTES IN WEATHER ABOVE 70 DEGREES F. (IN WARMER WEATHER THE CONDITION OCCURS MORE QUICKLY AND MORE SEVERELY) THE LOCATION ON THE RIGHT SIDE OF THE BIKE WHERE YOUR LEG IS POSITIONED BECOMES UNBEARABLY HOT. IN WARMER WEATHER 80 DEGREES F. OR MORE IT ACTUALLY BECOMES PAINFUL TO BARE SKIN. IT BECOMES SO HOT YOU MUST MOVE YOUR LEG AWAY AND INTO THE WIND TO PROVIDE SOME RELIEF. THIS FORCES YOU TO TAKE YOUR FOOT OFF OF THE FOOTREST AND AWAY FROM THE BRAKE PEDAL. ALSO, AFTER RIDING THE BIKE AS STATED ABOVE AND STOPPING FOR TRAFFIC OR TO STOP AND GET OFF YOU CAN CLEARLY SMELL GASOLINE VAPORS. WITH THE PANELS REMOVED I OBSERVED THAT THE CATALYTIC CONVERTER IS LOCATED DIRECTLY UNDER THE FUEL TANK. THE HEAT FROM THIS COMPONENT APPEARS TO BE HEATING UP THE FUEL TANK AND CREATING THE FUEL VAPORS YOU SMELL NEAR THE BIKE. TO REFUEL THE BIKE YOU MUST LIFT THE SEAT TO ACCESS THE FUEL CAP, AFTER RIDING IN THE CONDITIONS STATED ABOVE THIS FUEL CAP ALSO BECOMES VERY, VERY HOT TO THE TOUCH. AGAIN, ALL OF THESE CONDITIONS ARE MORE PRONOUNCED THE WARMER THE WEATHER. I BELIEVE BOTH THESE CONDITIONS DESCRIBED ABOVE ARE A DANGER TO THE CONSUMER. THE FIRST CONDITION COULD CAUSE SKIN IRRITATION OR POSSIBLY EVEN A SLIGHT BURN TO THE SKIN. IT COULD ALSO CAUSE A DELAY IN REACHING THE BRAKE PEDAL WITH HEAT CAUSING YOU TO MOVE YOUR LEG FROM THE VICINITY OF THE BRAKE. THE SECOND CONDITION HAS THE POTENTIAL TO CAUSE A FIRE. BOTH THESE CONDITIONS SEEM TO RELATE TO ONE ROOT CAUSE, TOO MUCH HEAT UNDER THE BODY PANELS AND NO PLACE FOR IT TO GO. THE PROXIMITY OF THE CATALYTIC CONVERTER TO THE FUEL TANK IS ALSO A MAJOR CONTRIBUTOR TO THESE CONDITIONS. BOTH OF THESE CONDITIONS HAVE THE POTENTIAL TO CAUSE BODILY HARM AND PROPERTY DAMAGE. *TR

THE AREA AROUND THE FRONT OF THE SEAT AND BODYWORK GETS EXTREMELY HOT, HOT ENOUGH THAT LEGS/THIGHS BECOME VERY UNCOMFORTABLE AND HAVE TO RAISE OFF OF SEAT WHENEVER STOPPED TO GET SOME RELIEF FROM THE HEAT. THIS IS ESPECIALLY APPARENT WHEN RIDING IN WARMER WEATHER AND SITTING AT STOPLIGHTS AND STOP AND GO TRAFFIC. THE HOT AIR COMING OUT OF THE LOWER RIGHT SIDE DIRECTLY ONTO RIGHT LEG AND BOOT IS ALSO BECOMES VERY UNCOMFORTABLE. THE STORAGE BOX IN FRONT OF THE SEAT IS BASICALLY UNUSABLE DUE TO THE HEAT AND THE BODYWORK ALSO BECOMES EXTREMELY HOT AT TIMES. *TR

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT MOTORCYCLE. THE CONTACT COULD SMELL FUEL WHEN THE VEHICLE WAS HOT. THE CONTACT STATED THAT THE STORAGE COMPARTMENT AND THE SEAT WOULD BECOME VERY HOT. THE DEALER STATED THAT THE VEHICLE WAS WITHIN SPECIFICATIONS. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 13V386000 (SERVICE BRAKES, HYDRAULIC), BUT DID NOT CONFIRM IF THE VEHICLE WAS INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 800.

THERE IS EXCESSIVE HEAT ON THE RIGHT FOOT AND LOWER LEG AT ALL SPEEDS TO THE EXTENT THAT ONE HAS TO PUT THEIR FOOT ON THE PASSENGER FOOTBOARD TO KEEP THE DISCOMFORT AT A TOLERABLE LEVEL. THERE IS ALSO EXCESSIVE HEAT COMING FROM THE FRONT AND SIDES OF THE SEAT ALSO TO THE POINT OF DISCOMFORT. AFTER RIDING FOR A SHORT TIME (WELL LESS THAN 30 MINUTES) IF THE SEAT IS RAISED, ONE CANNOT TOUCH ANY SURFACE UNDER THE SEAT FOR FEAR OF BEING BURNED. *TR

THIS IS A NEW BIKE WITH EXTREMELY HEAT ISSUES FROM THE ENGINE. AT FIRST DEALER APPOINTMENT IT MEASURED 140 DEGREES AFTER I PARKED 10 MINUTES. WHILE RIDING EXTREMELY HOT AIR BLOWS AT YOUR BOTTOM RIGHT LEG AND TRAVELS UP THE SEAT. THE WHOLE RIGHT SIDE PANEL THE FRONT OF THE SEAT AND TANK MAKES IT TO HOT TO THE TOUCH. PIPES WERE WRAPPED FROM DEALER WHICH DID NOT TAKE CARE OF PROBLEM. I WAS TOLD BRP WILL DO NO FURTHER SOLUTIONS REGARDING THE HEAT ISSUES. I AM CONCERNED ABOUT THE TANK GETTING TO HOT TO THE TOUCH. *TR

VEHICLE IS A FIRE HAZARD AND PRODUCES HOT AIR FROM THE ENGINE ONTO THE RIGHT LEG THAT IS INTENSE ENOUGH TO CAUSE BURNS. ALSO HEAT FROM UNDER THE SEAT WHERE THE GAS TANK IS LOCATED IS UNBEARABLE. GAS FUMES ARE EMITTED FROM THE BIKE WHILE RIDING AND WHEN THE CYCLE IS TURNED OFF THE GAS FUMES ARE SO INTENSE THAT IT SEEMS UNSAFE TO PARK IN A GARAGE FOR FEAR OF FIRE.THIS IS A TRAGEDY WAITING TO HAPPEN.CAN AM NEEDS TO BE REQUIRED TO FIND A SOLUTION TO THESE PROBLEMS FOR THE SAFETY OF THE RIDERS AND THE GENERAL PUBLIC. *TR