2005 CADILLAS STS - FRAME ROTTING OUT - CAR IS GARAGE KEPT. UPON INSPECTION ON MY LIFT THIS WEEKEND, I FOUND SUBSTANTIAL RUST TO BOTH LOWER FRAME RAILS JUST BEHIND THE MOUNTS FOR ENGINE CRADLE. MANUFACTURER FILLS THE FRAME RAILS OF THIS AREA WITH FOAM WHICH ABSORBS AND HOLDS WATER AND ROTS THE FRAME RAIL FROM THE INSIDE OUT. THI…
Read full complaint
2005 CADILLAS STS - FRAME ROTTING OUT - CAR IS GARAGE KEPT. UPON INSPECTION ON MY LIFT THIS WEEKEND, I FOUND SUBSTANTIAL RUST TO BOTH LOWER FRAME RAILS JUST BEHIND THE MOUNTS FOR ENGINE CRADLE. MANUFACTURER FILLS THE FRAME RAILS OF THIS AREA WITH FOAM WHICH ABSORBS AND HOLDS WATER AND ROTS THE FRAME RAIL FROM THE INSIDE OUT. THIS IS DEFINITELY A MANUFACTURER DEFECT. NOW LOOKING AT THOUSANDS TO REPAIR A VEHICLE IN OTHERWISE VERY GOOD CONDITION.
NHTSA ODI #11089694
55,000 miles · Jun 5, 2017
Structure
MANUFACTURE PRODUCED THIS CAR FILLING THE INSIDE OF THE UNIBODY RAILS WITH AN ABSORBENT FOAM. THESE RAILS ALSO HAVE MANUFACTURED HOLES ALLOWING WATER TO ENTER THE RAILS. THE WATER IS THEN ABSORBED IN THE FOAM AND THROUGH AGE IT HAS CAUSE THE UNIBODY RAILS TO ROT FROM THE INSIDE OUT. THIS IS THE MAIN STRUCTURE OF THE CAR. I ALSO …
Read full complaint
MANUFACTURE PRODUCED THIS CAR FILLING THE INSIDE OF THE UNIBODY RAILS WITH AN ABSORBENT FOAM. THESE RAILS ALSO HAVE MANUFACTURED HOLES ALLOWING WATER TO ENTER THE RAILS. THE WATER IS THEN ABSORBED IN THE FOAM AND THROUGH AGE IT HAS CAUSE THE UNIBODY RAILS TO ROT FROM THE INSIDE OUT. THIS IS THE MAIN STRUCTURE OF THE CAR. I ALSO HAVE A 2007 CADILLAC STS WITH 85K WHERE THIS IS STARTING TO BECOME PRESENT AND AN 2005 CADILLAC SRX 130K WHERE THIS ALREADY HAPPENED AND HAD TO SPEND THOUSANDS IN REPAIRS. I UNDERSTAND WITH AGE COMES RUST HOWEVER THIS IS A MANUFACTURE DEFECT. THERE IS NO REASON FOR THESE CARS MAIN STRUCTURE TO OF BEEN FILLED WITH FOAM CAUSING THE "FRAME" TO ROT SPECIFICALLY WHERE THE ENGINE CRADLE BOLTS TO THE BODY STRUCTURE. HAD THIS ADDRESSED NOW I COULD OF BEEN DRIVING THE CAR AND HAD THE ENGINE SUBFRAME RIP FROM THE UNIBODY.
NHTSA ODI #10993220
55,645 miles · Sep 29, 2011
Structure
I WAS DRIVING NORTH ON I-95 IN VIRGINIA WHEN I HEARD A LOUD POP AND SUDDENLY REALIZED THAT THE GLASS PART OF MY SUNROOF HAD TORN AWAY COMPLETELY. LUCKILY NO ONE WAS BEHIND ME AT THE TIME. THE SEALANT THAT HOLDS THE GLASS IN PLACE HAD FAILED. THE SUNROOF WAS CLOSED AT THE TIME THIS HAPPENED. THIS IS A SERIOUS PROBLEM. *TT
NHTSA ODI #10427962
38,455 miles · Jun 17, 2008
SeatsStructure
I HAVE RUST IN MY CAR AND UNDER THE BOTTOM. CADILLAC STATES THIS IS NORMAL AND THEY CANNOT DO ANYTHING UNTIL THERE IS A HOLE IN THE VEHICLE. THEY RELY ON THE DEALERS FEEDBACK. THE DISTRICT MANAGER IN THE AREA IS OF NO USE. THE DEALER OVER RIDES HIS DECISIONS. WHAT DOES GMC PAID THIS FELLOW FOR? *TR
NHTSA ODI #10231395
Mileage unknown · Sep 26, 2006
Structure
THE AIR DAM SHIELD ON A 2005 CADILLAC STS KEEPS FALLING DOWN AND DRAGGING ON THE PAVEMENT. THE CAR WAS BOUGHT IN JUNE 2005 AND THE FIRST INCIDENT HAPPENED IN JULY 2005. THE DEALER REPLACED THE SHIELD. THE SECOND INCIDENT HAPPENED IN AUGUST 2005 AND THE DEALER REATTACHED THE SHIELD. THE THIRD INCIDENT HAPPENED IN SEPTEMBER 20…
Read full complaint
THE AIR DAM SHIELD ON A 2005 CADILLAC STS KEEPS FALLING DOWN AND DRAGGING ON THE PAVEMENT. THE CAR WAS BOUGHT IN JUNE 2005 AND THE FIRST INCIDENT HAPPENED IN JULY 2005. THE DEALER REPLACED THE SHIELD. THE SECOND INCIDENT HAPPENED IN AUGUST 2005 AND THE DEALER REATTACHED THE SHIELD. THE THIRD INCIDENT HAPPENED IN SEPTEMBER 2006 AND THE DEALER REPLACED THE SHIELD. THE DRAGGING OF THE SHIELD CAUSED SOME COSMETIC DAMAGE UNDER THE CAR AND THE NOISE OF THE DRAGGING WAS QUITE NOTICEABLE. *NM
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
Consequence & remedy
Consequence: A REAR DIFFERENTIAL FAILURE MAY CAUSE LOSS OF MOTIVE POWER AND POSSIBLY LOSS OF CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PINION SEAL FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006 OR HTTP://WWW.CADILLAC.COM; PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM; AND SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM.
CERTAIN VEHICLES HAVE A LEFT OR RIGHT REAR SUSPENSION TOE LINK THAT COULD SEPARATE BECAUSE OF AN INCORRECT WELD.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, THE AFFECTED REAR WHEEL WOULD BE ABLE TO TURN IN OR OUT, AFFECTING VEHICLE CONTROL, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE RIGHT AND LEFT TOE LINK AND REPLACE AS REQUIRED. IF A TOE LINK IS REPLACED, THE DEALER WILL PERFORM A WHEEL ALIGNMENT. THE RECALL BEGAN ON MAY 3, 2006. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.
CERTAIN VEHICLES EQUIPPED WITH V6 ENGINES MAY HAVE A CONDITION WHERE FUEL IS NO LONGER SUPPLIED TO THE ENGINE. THIS CONDITION OCCURS WITHOUT THE ILLUMINATION OF THE FUEL LEVEL LOW INDICATOR LIGHT OR THE WARNING CHIME.
Consequence & remedy
Consequence: IF THE ENGINE STOPS RUNNING, THE OPERATOR WILL NOT BE ABLE TO RESTART THE VEHICLE WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ELECTRONIC CONTROL MODULE (ECM) WITH NEW SOFTWARE FREE OF CHARGE. OWNERS WERE NOTIFIED IN DECEMBER 2005 AND ASKED TO MAINTAIN AT LEAST 1/4 OF A TANK FUEL LEVEL TO AVOID THIS CONDITION UNTIL THE PARTS ARE AVAILABLE. THE PARTS ARE NOW AVAILABLE, OWNER RENOTIFICATION BEGAN ON MARCH 23, 2006. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE07037 · Failure Of The Rear Differential
Opened Jul 17, 2007 · Closed Dec 27, 2007
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.
2005 Cadillac Sts Problems, Complaints & Recalls | Skip That Year
Illustration