NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
95 reports135,000 miles · Nov 11, 2003
Fuel System, Gasoline
I HAVE A 1997 CADILLAC SEVILLE STS AND THE FUEL RAIL SPRUNG A LEAK RESULTING IN GAS SPREAD ON THE ENGINE AND FUMES IN THE PASSENGER COMPARTMENT. THIS IS EXTREMELY DANGEROUS AND HAD I NOT STOPPED QUICKLY, A FIRE WOULD HAVE RESULTED. FROM MY CAR REPAIRMAN AND LOOKING ON THE WEB, THIS IS NOT AN ISOLATED INCIDENT. NOTE COMPLAINT 1…
Read full complaint
I HAVE A 1997 CADILLAC SEVILLE STS AND THE FUEL RAIL SPRUNG A LEAK RESULTING IN GAS SPREAD ON THE ENGINE AND FUMES IN THE PASSENGER COMPARTMENT. THIS IS EXTREMELY DANGEROUS AND HAD I NOT STOPPED QUICKLY, A FIRE WOULD HAVE RESULTED. FROM MY CAR REPAIRMAN AND LOOKING ON THE WEB, THIS IS NOT AN ISOLATED INCIDENT. NOTE COMPLAINT 10045758.*AK
NHTSA ODI #10045965
107,871 miles · Nov 8, 2003
Fuel System, Gasoline
IN REFERENCE TO OPEN INVESTIGATION PE03050. I HAVE CADILLAC SEVILLE, STS, 1997. HAD EXACTLY THE SAME PROBLEM AS DESCRIBED -- STRONG FUEL SMELL IN THE CAR -- WHEN CHECKED BY THE DEALERSHIP -- THERE WAS A PIN HOLE IN THE FUEL RAIL -- I HAVE SEEN IT MYSELF AND IT WAS SCARY. LOGGED THE COMPLAINT WITH CADILLAC: [XXX] ON 09/30/2003, …
Read full complaint
IN REFERENCE TO OPEN INVESTIGATION PE03050. I HAVE CADILLAC SEVILLE, STS, 1997. HAD EXACTLY THE SAME PROBLEM AS DESCRIBED -- STRONG FUEL SMELL IN THE CAR -- WHEN CHECKED BY THE DEALERSHIP -- THERE WAS A PIN HOLE IN THE FUEL RAIL -- I HAVE SEEN IT MYSELF AND IT WAS SCARY. LOGGED THE COMPLAINT WITH CADILLAC: [XXX] ON 09/30/2003, BUT THEY WERE NOT WILLING TO INVESTIGATE ANY FURTHER AT THAT TIME. CADILLAC SHOULD RECALL ALL THESE VEHICLE AS SOON AS POSSIBLE BECAUSE THIS IS A SIGNIFICANT FIRE HAZARD. PLEASE FEEL FREE TO CONTACT ME AT [XXX](WORK) IF YOU HAVE ANY QUESTIONS. REGARDS, [XXX]. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10045758
75,300 miles · Nov 5, 2003
Engine And Engine CoolingFuel System, Gasoline
ENGINE EXHIBITED EXTENDED CRANKS AFTER SITTING FOR SEVERAL HOURS. DEALER REPLACED FUEL PRESSURE REGULATOR($$$). ENGINE CONTINUED TO EXHIBIT EXTENDED CRANKS ONLY MORE SEVERE. DEALER REPLACED FUEL PUMP ($$$$). ENGINE CONTINUED TO EXHIBIT EXTENDED CRANKS. DEALER REPLACED FUEL FILTER ($$) AND FUEL PUMP AGAIN. CRANK PROBLEM NOW REPLA…
Read full complaint
ENGINE EXHIBITED EXTENDED CRANKS AFTER SITTING FOR SEVERAL HOURS. DEALER REPLACED FUEL PRESSURE REGULATOR($$$). ENGINE CONTINUED TO EXHIBIT EXTENDED CRANKS ONLY MORE SEVERE. DEALER REPLACED FUEL PUMP ($$$$). ENGINE CONTINUED TO EXHIBIT EXTENDED CRANKS. DEALER REPLACED FUEL FILTER ($$) AND FUEL PUMP AGAIN. CRANK PROBLEM NOW REPLACED BY STALLING AFTER DECELERATING TO NEAR STOP THEN DOING A GENTLE TIP IN ON ACCELERATOR AS IN MAKING A TURN OR ENTERING A TRAFFIC CIRCLE.*AK
NHTSA ODI #10045551
Mileage unknown · Nov 3, 2003
Service Brakes, Air
WHILE MAKING A TURN AT 15 MPH THE ANTI-LOCK BRAKING SYSTEM ENGAGED, CAUSING THE VEHICLE TO SKID. WHEN IT RELEASED CONSUMER WAS ABLE TO DRIVE THE VEHICLE UNTIL THE NEXT TIME WHEN CONSUMER TURNED IT OFF. *AK
NHTSA ODI #10046202
Mileage unknown · Oct 29, 2003
Fuel System, Gasoline
CONSUMER STATED THAT THE FUEL INJECTION RAIL WAS MADE OF PLASTIC. THE MANUFACTURER WAS CONTACTED, AND STATED, THAT THEY ONLY WILL REPLACE METAL NOT PLASTIC. *AK
NHTSA ODI #10045020
100,300 miles · Oct 23, 2003
Steering
1997 SEVILLE STS WHILE STARTING TURN FROM A STOP THE TRACTION CONTROL APPLIES THE BRAKES SKIDS THE TIRES, TAKES AWAY THE ABILITY TO STEER AND DECELERATES THE ENGINE, THIS ALSO OCCURS WHEN DOING THE POSTED SPEED LIMIT (70) MPH. THE BOOK REQUIRES DRIVERS TO PULL OVER AND TURN CAR OFF THEN RESTART, DOING THIS ON THE FREEWAY PERMI…
Read full complaint
1997 SEVILLE STS WHILE STARTING TURN FROM A STOP THE TRACTION CONTROL APPLIES THE BRAKES SKIDS THE TIRES, TAKES AWAY THE ABILITY TO STEER AND DECELERATES THE ENGINE, THIS ALSO OCCURS WHEN DOING THE POSTED SPEED LIMIT (70) MPH. THE BOOK REQUIRES DRIVERS TO PULL OVER AND TURN CAR OFF THEN RESTART, DOING THIS ON THE FREEWAY PERMITS THIS TO OCCUR AT HIGH WAY SPEEDS. WENT TO DEALER, THEY SAY TO REPLACE THE STEERING SENSOR, CALLED MANUFACTURER THEY SAY TOO BAD CONSUMER. *LA
NHTSA ODI #10043457
106,817 miles · Oct 1, 2003
Fuel System, Gasoline
FUEL RAIL LEAKED. DEALER STATED RAIL WAS INSTALLED BACKWARDS. THE FUEL RAIL DEVELOPED A LEAK IN THE HEAT SHRINK TUBING WHICH CAUSED FUMES TO ENTER THE CABIN OF THE VEHICLE. *AK *NLM
NHTSA ODI #10034111
Mileage unknown · Sep 12, 2003
Suspension
WHILE DRIVING, THE VEHICLE FISH-TAILS WHEN HITTING BUMPS. THE DEALER HAS ATTEMPTED TO REPAIR THIS VEHICLE EIGHT TIMES AND SAYS THAT THIS VEHICLE CAN NOT BE FIXED. PLEASE PROVIDE FURTHER DETAILS. *PH
NHTSA ODI #10039917
83,000 miles · Jul 21, 2003
Fuel System, Gasoline
CONSUMER CALLED COMPLAINING ABOUT FUEL INJECTION SYSTEM, INJECTORS. INJECTORS WERE MADE OUT OF PLASTIC, GAS WAS LEAKING THROUGH THEM, AND WAS FALLING RIGHT ON TOP OF THE ENGINE. MANUFACTURER WAS CONTACTED, AND STATED THAT CONSUMER SHOULD PURCHASE THE EXTRA WARRANTY ON THE VEHICLE. BUT THE WARRANTY WILL ONLY COVER THE INJECTOR…
Read full complaint
CONSUMER CALLED COMPLAINING ABOUT FUEL INJECTION SYSTEM, INJECTORS. INJECTORS WERE MADE OUT OF PLASTIC, GAS WAS LEAKING THROUGH THEM, AND WAS FALLING RIGHT ON TOP OF THE ENGINE. MANUFACTURER WAS CONTACTED, AND STATED THAT CONSUMER SHOULD PURCHASE THE EXTRA WARRANTY ON THE VEHICLE. BUT THE WARRANTY WILL ONLY COVER THE INJECTORS MADE OUT OF METAL AND NOT PLASTIC.*AK
NHTSA ODI #10029763
86,447 miles · May 9, 2003
Electrical SystemEngine And Engine Cooling
I BOUGHT A USED 1997 CADILLAC SLS IN 1999 WHICH WAS STILL UNDER WARRANTY. THE CAR HAS HAD ELECTRICAL AND MECHANICAL PROBLEMS OFF AND ON. I HAVE RELIGIOUSLY HAD MY CAR SERVICED AT THE RECOMMENDED SCHEDULE. I WAS TOLD AND LED TO BELIEVE THAT THE ENGINE WAS VIRTUALLY MAINTENANCE FREE UP TO 100,000 MILES. MY CAR HAS 82,000 MILE…
Read full complaint
I BOUGHT A USED 1997 CADILLAC SLS IN 1999 WHICH WAS STILL UNDER WARRANTY. THE CAR HAS HAD ELECTRICAL AND MECHANICAL PROBLEMS OFF AND ON. I HAVE RELIGIOUSLY HAD MY CAR SERVICED AT THE RECOMMENDED SCHEDULE. I WAS TOLD AND LED TO BELIEVE THAT THE ENGINE WAS VIRTUALLY MAINTENANCE FREE UP TO 100,000 MILES. MY CAR HAS 82,000 MILES AND NOW THEY TELL ME THAT I NEED A NEW HEAD GASKET AT NICE COST OF $2800.00. I'M TIRED OF BEING CHARGED FOR "SOME LITTLE PROBLEM" EVERY TIME I BRING IT IN! *JB
NHTSA ODI #10018480
NHTSA investigations
3EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Illustration