NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
122 reports100,000 miles · Dec 16, 2022
EngineFire
The contact owned a 1996 Cadillac Seville. The contact stated while parked, the contact noticed smoke coming from the vents. The contact was able to exit the vehicle, and once the contact exited the vehicle, the vehicle burst into flames. The fire department was able to extinguish the fire. The contact was unsure if a police rep…
Read full complaint
The contact owned a 1996 Cadillac Seville. The contact stated while parked, the contact noticed smoke coming from the vents. The contact was able to exit the vehicle, and once the contact exited the vehicle, the vehicle burst into flames. The fire department was able to extinguish the fire. The contact was unsure if a police report was filed. No one was injured. The vehicle was towed and deemed a total loss. The manufacturer was not notified of the failure. The failure mileage was 100,000. The VIN was not available.
NHTSA ODI #11497745
183,000 miles · Jan 6, 2017
Air BagsElectrical System
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. WHILE DRIVING 30 MPH, THE FRONT DRIVER AND PASSENGER SIDE AIR BAGS SUDDENLY DEPLOYED WITHOUT IMPACT OR WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN NOTICED WATER LEAKING FROM THE AIR CONDITIONING UNIT INTO THE AIR BAG COMPUTER SYSTEM, WHIC…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. WHILE DRIVING 30 MPH, THE FRONT DRIVER AND PASSENGER SIDE AIR BAGS SUDDENLY DEPLOYED WITHOUT IMPACT OR WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN NOTICED WATER LEAKING FROM THE AIR CONDITIONING UNIT INTO THE AIR BAG COMPUTER SYSTEM, WHICH CAUSED THE AIR BAGS TO FAIL. AS A RESULT, THE CONTACT WAS INFORMED THAT THE AIR BAGS AND OTHER UNKNOWN PARTS RELATED TO THE COMPUTER SYSTEM AND AIR CONDITIONING UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 183,000.
NHTSA ODI #10940061
117,000 miles · Oct 31, 2016
Electrical SystemFuel/propulsion System
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT THERE WAS A FUEL LEAK. ALSO, WHEN THE VEHICLE WAS STARTED, THE PASS KEY LOCK WARNING INDICATOR FLASHED. THE KEY WOULD NOT TURN OVER TO START THE VEHICLE ON SEVERAL OCCASIONS. THE VEHICLE WAS UNABLE TO BE DRIVEN EACH TIME THE FAILURE OCCURRED. THE VIN WAS NOT I…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT THERE WAS A FUEL LEAK. ALSO, WHEN THE VEHICLE WAS STARTED, THE PASS KEY LOCK WARNING INDICATOR FLASHED. THE KEY WOULD NOT TURN OVER TO START THE VEHICLE ON SEVERAL OCCASIONS. THE VEHICLE WAS UNABLE TO BE DRIVEN EACH TIME THE FAILURE OCCURRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 95V224000 (EQUIPMENT) AND 04V110000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND RECOMMENDED THAT THE VEHICLE BE TAKEN TO A DEALER FOR FURTHER DIAGNOSTIC TESTING. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 117,000.
NHTSA ODI #10920198
156,000 miles · Jun 6, 2016
Air BagsInjury
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. WHILE APPROACHING A STOP, THE FRONT DRIVER AND PASSENGER AIR BAGS DEPLOYED INDEPENDENTLY AND WITHOUT IMPACT. THE CONTACT SUSTAINED ABRASIONS TO THE RIGHT ARM, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A BODY SHOP. THE VEHICLE WAS NOT DIAGNO…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. WHILE APPROACHING A STOP, THE FRONT DRIVER AND PASSENGER AIR BAGS DEPLOYED INDEPENDENTLY AND WITHOUT IMPACT. THE CONTACT SUSTAINED ABRASIONS TO THE RIGHT ARM, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A BODY SHOP. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 156,000.
NHTSA ODI #10872819
80,000 miles · Mar 21, 2014
Air BagsElectrical SystemEngine
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY STALL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THE CRANK SHAFT SENSORS, SPARKS PLUGS AND IDLE AIR CONTROL VALVE NEEDED TO BE REPLACED THE VEHICLE WAS NOT REPAIRED. . THE CONTACT TOOK THE VEHICLE TO AN I…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY STALL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THE CRANK SHAFT SENSORS, SPARKS PLUGS AND IDLE AIR CONTROL VALVE NEEDED TO BE REPLACED THE VEHICLE WAS NOT REPAIRED. . THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC. THE MECHANIC REPLACED THE CRANK SHAFT POSITION SENSORS,WIRING, SPARKS PLUGS AND IDLE AIR CONTROL VALVE. HOWEVER THE FAILURE PERSISTED. THE CONTACT STATED NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS , ELECTRICAL SYSTEM) IS THE SAME FAILURE HE EXPERIENCED. HOWEVER, THE RECALL DID NOT INCLUDE THE CONTACT'S YEAR MAKE OR MODEL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 80,000. UPDATED 07-23-14 *BF UPDATED 7/31/14*CN
NHTSA ODI #10573986
Mileage unknown · Dec 3, 2012
Electrical System
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE ENTIRE INSTRUMENT PANEL WENT BLACK WITH THE EXCEPTION OF THE RADIO COMPONENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT TH…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE ENTIRE INSTRUMENT PANEL WENT BLACK WITH THE EXCEPTION OF THE RADIO COMPONENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 95V224000 (EQUIPMENT:ELECTRICAL). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.
NHTSA ODI #10487207
Mileage unknown · Jul 19, 2012
Electrical System
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE SLS. THE CONTACT WAS TRAVELING 30 MPH WHEN AN ERROR MESSAGE APPEARED INDICATING THAT THE VEHICLE WOULD NOT START. THE VEHICLE THEN STALLED. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC. THE MECHANIC STATED THAT A GROUNDED FUSE CAUSED A FAILURE TO THE WIRING HARNESS IN THE INSTRUMENT PA…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE SLS. THE CONTACT WAS TRAVELING 30 MPH WHEN AN ERROR MESSAGE APPEARED INDICATING THAT THE VEHICLE WOULD NOT START. THE VEHICLE THEN STALLED. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC. THE MECHANIC STATED THAT A GROUNDED FUSE CAUSED A FAILURE TO THE WIRING HARNESS IN THE INSTRUMENT PANEL. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.
NHTSA ODI #10466621
150,000 miles · Feb 27, 2012
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS) FOR A FUEL LEAK BUT THE FAILURE RECURRED. THE VEHICLE WAS LEAKING GASOLINE ONTO THE GROUND FROM THE ENGINE COMPARTMENT, WHIC…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS) FOR A FUEL LEAK BUT THE FAILURE RECURRED. THE VEHICLE WAS LEAKING GASOLINE ONTO THE GROUND FROM THE ENGINE COMPARTMENT, WHICH THE CONTACT WAS CONCERNED COULD POSSIBLY CAUSE A FIRE. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 150,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10449459
138,000 miles · Dec 5, 2011
Engine And Engine CoolingFire
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE STS. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH AND SMELLED A STRONG BURNING ODOR OF FUMES INSIDE OF THE VEHICLE. THE ENGINE BEGAN TO OVERHEAT, CAUSING THE TEMPERATURE GAUGE TO INCREASE RAPIDLY TO HOT. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD TO INSPECT THE VEHICLE AND NOTICED…
Read full complaint
TL* THE CONTACT OWNS A 1996 CADILLAC SEVILLE STS. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH AND SMELLED A STRONG BURNING ODOR OF FUMES INSIDE OF THE VEHICLE. THE ENGINE BEGAN TO OVERHEAT, CAUSING THE TEMPERATURE GAUGE TO INCREASE RAPIDLY TO HOT. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD TO INSPECT THE VEHICLE AND NOTICED A SUBSTANTIAL AMOUNT OF COOLANT LEAKAGE UNDERNEATH THE DASHBOARD AND THE FRONT PASSENGER FLOOR AREA. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 138,000.
NHTSA ODI #10438577
40,000 miles · Mar 11, 2011
Engine And Engine Cooling
GM HAS A KNOWN PROBLEM WITH THE CADALLIC NORTHSTAR 4.6L HEAD GASKETS. THEY BROKE DOWN BETWEEN 70,000 AND 140,000 MILES GM WILL NOT ASSIST IN THE REPAIR OF THE HEAD GASKETS. OUR CADILLAC IS A 1996 WITH 72,000 MILES AND HAS HAD THE LEAKING SINCE 40,000 MILES. THE DEALER WAS AND IS WILLING TO REPAIR FOR APPROX. $3500.00. WE HAVE N…
Read full complaint
GM HAS A KNOWN PROBLEM WITH THE CADALLIC NORTHSTAR 4.6L HEAD GASKETS. THEY BROKE DOWN BETWEEN 70,000 AND 140,000 MILES GM WILL NOT ASSIST IN THE REPAIR OF THE HEAD GASKETS. OUR CADILLAC IS A 1996 WITH 72,000 MILES AND HAS HAD THE LEAKING SINCE 40,000 MILES. THE DEALER WAS AND IS WILLING TO REPAIR FOR APPROX. $3500.00. WE HAVE NEVER BEEN TOLD ABOUT THE LAWSUIT THAT WAS FILES AND THE DEALER HAS KNOWN ABOUT THE DEX COOLANT PROBLEM. THE DEALER WILL NOT GUARANTEE THE HEAD GASKET THEY SAID WAS NEEDED . I DID NOT KNOW THAT THERE WERE SERVICE BULLITTINS ON PUTTING INSERTS IN THE BLOCK FOR THE HEAD BOLTS. I THINK OVER 50% OF THESE ENGINES HAVE HAD THE GASKET REPLACED. THIS WAS A PROBLEM, BUT I KNOW THAT THEY LIKE THE MONEY THAT IT BRINGS IN TO THEM.
NHTSA ODI #10391428
NHTSA investigations
4EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA98004 · Inadvertent Air Bag Deployment
Opened Feb 24, 1998 · Closed Jun 16, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
Illustration