PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION, WWW.NHTSA.DOT.GOV SENT: SUNDAY, JUNE 17, 2007 10:54 PM TIRES MANUFACTURED BY VOGUE TIRE /RUBBER CO, MT PROSPECT, ILLINOIS ,60056 (800) 323 - 1466/EX. 405. FOUR VOGUE/GOODYEAR TIRES WITH 9/32NDS TREAD WEAR/MANUFACTURED SOMETIMES AFTER 1998 PROBLEM EXISTS WITH …
Read full complaint
PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION, WWW.NHTSA.DOT.GOV SENT: SUNDAY, JUNE 17, 2007 10:54 PM TIRES MANUFACTURED BY VOGUE TIRE /RUBBER CO, MT PROSPECT, ILLINOIS ,60056 (800) 323 - 1466/EX. 405. FOUR VOGUE/GOODYEAR TIRES WITH 9/32NDS TREAD WEAR/MANUFACTURED SOMETIMES AFTER 1998 PROBLEM EXISTS WITH TREAD WEAR/DRY ROT, TIRE TREAD SPLITTING. JIM HORDAN REGIONAL VICE PRESIDENT & KEN GOYAK, EXECUTIVE VICE PRESIDENT ADVISED VOGUE TIRES ONLY HAD A FIVE YEAR LIFE EXPECTANCY, AND AFTER FIVE YEARS TIRES MANUFACTURED BY VOGUE HAVE NO PRODUCT DEFECT WARRANTY. I DISAGREE WITH VOGUE'S CLAIM THEY WERE OBLIGATED TO HONOR A FULL REPLACEMENT WARRANTY OBLIGATION AT ANY TIME IF A MANUFACTURING FLAW DISCOVERED IN A TIRE PRODUCTION EXPOSED THE CONSUMER POPULATION TO LOSS OF LIFE OR INJURY. SINCE VOGUE HAS REFUSED TO HONOR THEIR WARRANTY OBLIGATION I WILL BE REPLACING THE VOGUE TIRES I OWN WITH ANOTHER BRAND TIRE, ND I WOULD LIKE TO ARRANGE FOR THE DELIVERY OF THE TIRES I NOW OWN TO A NHSTB LOCAL OFFICE IN THE BOYNTON BEACH AREA SO THEY COULD BE EXAMINED , AND HAVE A TREAD RUN OUT TEST BE PERFORMED TO CONFIRM THE OPINION OF TWO GOODYEAR TIRE DEALERSHIPS THAT THE VOGUE TIRES I WANT TO DELIVER WERE DUE TO MANUFACTURING PROBLEM. FURTHER, IF AS THE VOGUE TIRE EXECUTIVES REFERENCED IN THIS E-MAIL HAVE STATED, THE E TIRE SHOULD NOT HAVE REMAINED IN SERVICE AFTER A FIVE YEAR TERM, MUST NOT THIS CONDITION BE BROADCAST FOR ALL TIRES THAT BEAR THE SAME SERIAL NUMBER BE SO ADVISED OF THE POSSIBILITY OF TIRES LIKE MINE HAVING A POSSIBLE MANUFACTURING PROBLEM? WAIT TO HEAR FROM YOU AS TO THE APPROPRIATE COURSE OF ACTION I MUST FOLLOW IN HAVNG YOUR AGENCY INVESTIGATE MY COMPLAINED. THEREAFTER, TAKE APPROPRIATE ACTION WHICH WOULD APPEAR TO BE A TIRE RECALL PROGRAM AS YOUR AGENCY DEEMS APPROPRIATE. *AK
NHTSA ODI #10193616
Mileage unknown · Jun 5, 2006
Tires
1995 SEVILLE TIRE BLEWOUT. *TS THE PASSENGER SIDE FRONT TIRE BLEWOUT WHILE THE VEHICLE WAS TRAVELING AT 73 MPH. THE RIGHT FRONT FENDER SUSTAINED DAMAGE AS A RESULT. *NM
NHTSA ODI #10159484
Mileage unknown · Apr 14, 2001
Tires
ON 6/25/98 I PLACED 4 NEW GOODYEAR TIRES AT 30948MILES. ON 6/22/00 BLOWOUT AT 55MPH LEFT REAR AT 43958 MILES. REPLACED BLOWOUT W/ GOODYEAR TIRE. ON 3/24/01 BLOWOUT LEFT FRONT GOODYEAR . ON 4/13/01 BLOWOUT AT 60MPH LEFT REAR [THE GOODYEAR PLACED ON 8/1/00] AT 48344 MILES. TOO MANY BLOWOUTS...NO INJURIES, BUT LUCKY. DID NOT …
Read full complaint
ON 6/25/98 I PLACED 4 NEW GOODYEAR TIRES AT 30948MILES. ON 6/22/00 BLOWOUT AT 55MPH LEFT REAR AT 43958 MILES. REPLACED BLOWOUT W/ GOODYEAR TIRE. ON 3/24/01 BLOWOUT LEFT FRONT GOODYEAR . ON 4/13/01 BLOWOUT AT 60MPH LEFT REAR [THE GOODYEAR PLACED ON 8/1/00] AT 48344 MILES. TOO MANY BLOWOUTS...NO INJURIES, BUT LUCKY. DID NOT HIT ROAD HAZARDS. (TIRESIZE: P225/60R16)( DOT NUMBER: TIRE SIZE: P225/60R16 )
NHTSA ODI #744069
Mileage unknown · Mar 22, 1996
Tires
CAR WAS PARKED IN DRIVEWAY THE PASSENGER SIDE REAR TIRE AIR CAME OUT, DEALER SAID NAIL WAS IN TIRE AND ROTATED TIRE, BUT STILL HAVING THE SAME PROBLEM . *AK
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INADVERTENT DEPLOYMENT OF THE AIR BAGS CAN OCCUR DUE TO WATER INTRUSION.
Consequence & remedy
Consequence: DEPLOYMENT OF THE AIR BAG WITHOUT WARNING COULD CAUSE A DRIVER TO LOSE VEHICLE CONTROL INCREASING THE RISK OF A VEHICLE CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL CLEAN THE EXTERIOR CASE OF THE SENSING AND DIAGNOSTIC MODULE (SDM) AND APPPLY A POTTING COMPOUND TO THE SDM CASE AND ELECTRICAL CONNECTOR BODY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA98004 · Inadvertent Air Bag Deployment
Opened Feb 24, 1998 · Closed Jun 16, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
SQ97017 · Inadvertent Air Bag Deployment
Opened Jul 2, 1997 · Closed Feb 24, 1998
Status: closed (inferred from source dates) · Air Bags
IF A 1995 CADILLAC INTERIOR IS EXPOSED TO SIGNIFICANT WATER INTRUSION, SUCH AS FROM WATER LEAKS, A WINDOW LEFT OPEN IN THE RAIN, OR DRIVING THROUGH HIGH WATER UP TO THE CARPET LEVEL, THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) SYSTEM SENSING AND DIAGNOSTIC MODULE (SDM) CAN BE DAMAGED.IF THIS OCCURS, BOTH THE DRIVER AND PASSENGER AIR BAGS CAN DEPLOY WHEN THE IGNITION SWITCH IS TURNED ON, EVEN IF THERE HAS BEEN NO FRONTAL IMPACT OR CRASH.AS A RESULT OF THESE DEPLOYMENTS, GM CONDUCTED AN ADVISORY LETTER CAMPAIGN, NUMBER 51-01-08 ENTITLED INADVERTENT DEPLOYMENT OF AIR BAGS WHEN INTERIOR EXPOSED TO WET CONDITIONS, IN FEBRUARY 1996.LETTERS TO OWNERS MAILED PURSUANT TO THIS COMPAIGN WARNED OWNERS TO NOT START THEIR ENGINES IF THE VEHICLE INTERIOR HAD BEEN EXPOSED TO SUBSTANTIAL AMOUNTS OF WATER.ODI HAS RECEIVED A TOTAL 8 REPORTS OF INADVERTENT AIR BAG DEPLOYMENT IN 1995 CADILLAC VEHICLES.
1995 Cadillac Seville Problems, Complaints & Recalls | Skip That Year
Illustration