NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
15 reportsClear category filter90,000 miles · Mar 22, 2010
Engine And Engine Cooling
TL*THE CONTACT OWNS A 1995 CADILLAC SEVILLE. THE CONTACT STATED THAT THE ENGINE BEGAN TO FREEZE WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE HEAD BOLTS ON THE ENGINE. A WARNING LIGHT ILLUMINATED INDICATING THAT THE COOLANT LEVEL NEEDED TO BE CHECKED. THE DEALER STATED THAT THERE WERE NO RECALLS OR W…
Read full complaint
TL*THE CONTACT OWNS A 1995 CADILLAC SEVILLE. THE CONTACT STATED THAT THE ENGINE BEGAN TO FREEZE WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE HEAD BOLTS ON THE ENGINE. A WARNING LIGHT ILLUMINATED INDICATING THAT THE COOLANT LEVEL NEEDED TO BE CHECKED. THE DEALER STATED THAT THERE WERE NO RECALLS OR WARRANTY; THEREFORE THE CONTACT WOULD BE RESPONSIBLE FOR PAYING $3500 TO HAVE THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT CALLED. THE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #10321361
137,000 miles · May 28, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1995 CADILLAC SEVILLE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED FLAMES UNDER THE HOOD OF THE VEHICLE. SHE STOPPED AND EXITED THE VEHICLE AND CALLED 911. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED AND THE FIRE DEPARTMENT HAS NOT COMPLETED THEIR REPORT. …
Read full complaint
TL*THE CONTACT OWNS A 1995 CADILLAC SEVILLE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED FLAMES UNDER THE HOOD OF THE VEHICLE. SHE STOPPED AND EXITED THE VEHICLE AND CALLED 911. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED AND THE FIRE DEPARTMENT HAS NOT COMPLETED THEIR REPORT. THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS 137,000.
NHTSA ODI #10270172
Mileage unknown · Dec 11, 2007
Engine And Engine Cooling
VEHICLE OVER HEATED, FOR THE FIRST TIME EVER. BLOWN HEAD GASKET DUE TO FAILURE OF THE HEAD GASKET BOLTS. TO CORRECT, THE HOLES NEED TO BE RESLEEVED AND A NEW HEAD GASKET INSTALLED. *TR
NHTSA ODI #10211421
117,184 miles · Aug 30, 2007
Engine And Engine Cooling
AUGUST 23, 2007, ON OR ABOUT 12:00 NOON TODAY I WAS DRIVING MY CAR. 1995 CADILLAC SEVILLE STS NORTHSTAR WITH 117,000 MILES. MY CAR STARTED TO HESITATE AND WASNT RUNNING RIGHT. I PULLED OVER AND PARKED. SMOKE STARTED TO COME OUT OF MY HOOD AND INSIDE THE CAR. THE SMOKE IN THE CAR SMELLED LIKE SOMETHING ON FIRE. I CALLED MY HU…
Read full complaint
AUGUST 23, 2007, ON OR ABOUT 12:00 NOON TODAY I WAS DRIVING MY CAR. 1995 CADILLAC SEVILLE STS NORTHSTAR WITH 117,000 MILES. MY CAR STARTED TO HESITATE AND WASNT RUNNING RIGHT. I PULLED OVER AND PARKED. SMOKE STARTED TO COME OUT OF MY HOOD AND INSIDE THE CAR. THE SMOKE IN THE CAR SMELLED LIKE SOMETHING ON FIRE. I CALLED MY HUSBAND AND MY SON. MY SON CAME ( WE WERE ABOUT MILE FROM HOME) AND TRIED TO GET IT HOME, DIDNT WORK. AS MY SON WAS DRIVING SMOKE ALSO WAS COMING INSIDE THE CAR. SO WE STOPPED AND CALLED A TOW TRUCK. THE DRIVER TOWED US HOME. WHILE HE WAS HERE HE WAS CKING MY CAR AND LOOKED UNDER IT AND SAW A RED AMBER VIBRANT GLOW COMING FROM THE CATALYTIC CONVERTER AND SMOKE WAS GOING INTO MY CAR. HE SHOWED IT TO ME VERY FAST, IT LOOKED LIKE A HOT HEATING ELEMENT IN AN ELECTRIC OVEN. I WAS SCARED TO DEATH AND HE IMMEDIATELY TOLD ME TO SHUT THE CAR OFF AND GET AWAY FROM IT. IT LOOKED LIKE THE CAR WAS READY TO BLOW UP! MY HUSBAND CH'D IT LATER WHEN COOL AND FOUND WITHIN 15 MINUTES OF THE CAR RUNNING THE SAME PROBLEM. IT WAS IN THE GARAGE AND QUICKLY ROLLED IT OUT SO IF IT CAUGHT FIRE IT WOULDNT BE IN THE HOUSE, SHUT OFF THE CAR AND FELT AROUND THE FLOOR ,CENTER CONSOLE ALL HOT TO THE TOUCH. HE TOOK A HOSE TO THE UNDERSIDE OF THE CAR AND SPRAYED THE CATALYTIC CONVERTER TO COOL IT DOWN, OPENED UP THE DOORS TO TRY AND AIR OUT THE CAR AS IT HAD FILLED WITH SMOKE. WE CALLED THE TOW TRUCK BACK TO TAKE THE CAR TO THE DEALER FOR SERVICE. THE SERVICE ADVISOR TOLD MY HUSBAND THAT HE HAD SEEN THIS PROBLEM BEFORE AND THAT WE WOULD NEED A NEW CATALYTIC CONVERTER THAT COSTS AROUND $1,000.00 AND WOULD SEE IF HE COULD GET IT UNDER WARRANTY. THE CAR WAS NO LONGER UNDER ANY WARRANTY. MY CAR GAVE ME ABSOLUTELY NO WARNING OR SIGNAL OF ANY PROBLEM. ON AUGUST 24, 2007 I REPORTED THE PROBLEM TO GM (FILE #71-550478818), THEY TOLD ME THEY WOULD DO NOTHING AND REPORT ME AS DIS-SATISFIED. WE HAD THE CAR REPAIRED AND PICKED IT UP FROM THE DEALER ON AUGUST 29,2007.
NHTSA ODI #10201242
Mileage unknown · Jul 22, 2004
Engine And Engine CoolingFire
WHILE DRIVING, SMOKE BEGAN EMITTING FROM THE VENTS. THE CONSUMER WAS ABLE TO PULL OVER. THE CONSUMER LIFTED UP THE HOOD AND THE VEHICLE WAS ON FIRE. THE CONSUMER WAS ABLE TO EXTINGUISHED THE FIRE. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10083526
Mileage unknown · Sep 16, 2003
Engine And Engine Cooling
WHILE DRIVING ABOUT 60 MPH ON THE HIGHWAY AND WITHOUT WARNING VEHICLE SHUT DOWN. VEHICLE WAS TOWED TO THE DEALERSHIP, AND MECHANIC COULD NOT DUPLICATE THE PROBLEM. THE VEHICLE WAS IN REPAIR SHOP SIX TIMES . *AK
NHTSA ODI #10040112
62,890 miles · Aug 1, 2003
Engine And Engine CoolingExterior LightingFuel System, Gasoline
WHILE DRIVING THE CONSUMER SMELLED FUEL. THE FUEL RAIL DEVELOPED A LEAK, AND FUEL LEAKED ALL OVER THE ENGINE COMPARTMENT. *AK THE FUEL RAIL CROSS OVER PIPE BETWEEN THE FUEL INJECTORS, DEVELOPED A PRESSURE FUEL LEAK, AS A RESULT THE FUEL SPRAYED ONTO THE ENGINE. GM CLAIMED TO HAVE NO RECORD OF THE PROBLEM. WHEN THE CONSUMER…
Read full complaint
WHILE DRIVING THE CONSUMER SMELLED FUEL. THE FUEL RAIL DEVELOPED A LEAK, AND FUEL LEAKED ALL OVER THE ENGINE COMPARTMENT. *AK THE FUEL RAIL CROSS OVER PIPE BETWEEN THE FUEL INJECTORS, DEVELOPED A PRESSURE FUEL LEAK, AS A RESULT THE FUEL SPRAYED ONTO THE ENGINE. GM CLAIMED TO HAVE NO RECORD OF THE PROBLEM. WHEN THE CONSUMER PICKED UP THE VEHICLE FROM THE DEALER, HE NOTICED THE DEALER HADN'T INSTALLED THE IDENTICAL PART. THE DEALER STATED GM CHANGED THE PART DUE TO PROBLEMS WITH THE FUEL RAIL. THERE WAS A NOISE IN THE ENGINE AREA DUE TO A FAILED WATER PUMP. THE TAIL LAMP BULBS FAILED ALSO. *SCC *JB
NHTSA ODI #10026867
Mileage unknown · Jun 12, 2002
Engine And Engine CoolingUnknown Or Other
THE CHECK OIL LEVEL MESSAGE CAME ON WHILE THE CONSUMER WAS DRIVING. THE VEHICLE CONSUMED MORE THAN A QUART OF OIL. *YH
NHTSA ODI #565407
Mileage unknown · Apr 10, 2002
Engine And Engine Cooling
AFTER DRIVING 1,400 MILES, VEHICLE BURNS A GREAT DEAL OF OIL. ENGINE LIGHT CONTINUOUSLY STAYS ON. *AK. *JB
NHTSA ODI #8007292
Mileage unknown · Oct 12, 2001
Engine And Engine Cooling
OIL SMOKING NEAR EXHAUST.
NHTSA ODI #563688
NHTSA investigations
4EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA98004 · Inadvertent Air Bag Deployment
Opened Feb 24, 1998 · Closed Jun 16, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
SQ97017 · Inadvertent Air Bag Deployment
Opened Jul 2, 1997 · Closed Feb 24, 1998
Status: closed (inferred from source dates) · Air Bags
IF A 1995 CADILLAC INTERIOR IS EXPOSED TO SIGNIFICANT WATER INTRUSION, SUCH AS FROM WATER LEAKS, A WINDOW LEFT OPEN IN THE RAIN, OR DRIVING THROUGH HIGH WATER UP TO THE CARPET LEVEL, THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) SYSTEM SENSING AND DIAGNOSTIC MODULE (SDM) CAN BE DAMAGED.IF THIS OCCURS, BOTH THE DRIVER AND PASSENGER AIR BAGS CAN DEPLOY WHEN THE IGNITION SWITCH IS TURNED ON, EVEN IF THERE HAS BEEN NO FRONTAL IMPACT OR CRASH.AS A RESULT OF THESE DEPLOYMENTS, GM CONDUCTED AN ADVISORY LETTER CAMPAIGN, NUMBER 51-01-08 ENTITLED INADVERTENT DEPLOYMENT OF AIR BAGS WHEN INTERIOR EXPOSED TO WET CONDITIONS, IN FEBRUARY 1996.LETTERS TO OWNERS MAILED PURSUANT TO THIS COMPAIGN WARNED OWNERS TO NOT START THEIR ENGINES IF THE VEHICLE INTERIOR HAD BEEN EXPOSED TO SUBSTANTIAL AMOUNTS OF WATER.ODI HAS RECEIVED A TOTAL 8 REPORTS OF INADVERTENT AIR BAG DEPLOYMENT IN 1995 CADILLAC VEHICLES.
Illustration