AS I WAS DRIVING FROM THE GAS STATION I TOOK A LEFT AND AS I ACCELERATED, THE ENGINE STARTED TO VIBRATE. I I HAD NEVER NOTICED THIS BEFORE THAT DAY. SO PROCEED TO TAKE MY TIME CAREFULLY BACK TO WORK. I EXAMINED THE UNDERCARRIAGE OF MY 99 LESABRE CUSTOM AND THAT'S WHERE I NOTICED THAT THE DRIVERS SIDE SUBFRAME BUSHINGS HAVE ALL B…
Read full complaint
AS I WAS DRIVING FROM THE GAS STATION I TOOK A LEFT AND AS I ACCELERATED, THE ENGINE STARTED TO VIBRATE. I I HAD NEVER NOTICED THIS BEFORE THAT DAY. SO PROCEED TO TAKE MY TIME CAREFULLY BACK TO WORK. I EXAMINED THE UNDERCARRIAGE OF MY 99 LESABRE CUSTOM AND THAT'S WHERE I NOTICED THAT THE DRIVERS SIDE SUBFRAME BUSHINGS HAVE ALL BUT FELL OUT DUE TO SEVERE RUST. THANKFULLY THE PASSENGER SIDE IS STILL FIRMLY ATTACHED. UPON FURTHER RESEARCH, THIS IS A COMMON PROBLEM WITH GM CARS OF THIS ERA AND THE DORMAN REPLACEMENT PARTS ARE READILY AVAILABLE. HAD THIS COMPONENT FAILED ON BOTH SIDES THE ENGINE AND TRANSMISSION WOULD HAVE FALLEN OUT AND CAUSED AN ACCIDENT OR WORSE. I AM STILL TRYING TO FIGURE OUT IF THIS IS A RECALL ISSUE OR JUST A BAD CHOICE OF VEHICLE DESIGN BY GM AND THEIR LACK OF CONCERN FOR THE PUBLICS WELL BEING. THESE SUBFRAME BUSHINGS SHOULD HAVE BEEN OR SHOULD BE A VIABLE RECALL CONCERN TODAY. THANK YOU FOR YOUR CONSIDERATION IN THIS MATTER.
NHTSA ODI #11196784
124,156 miles · Aug 16, 2011
StructureSuspension
TL* THE CONTACT OWNS A 1999 BUICK LESABRE. THE CONTACT STATED THAT WHILE DRIVING OVER A POTHOLE AT A LOW SPEED, THE STRUT HOUSING ON THE FRONT PASSENGER SIDE FAILED AND THE HOOD POPPED OPEN. THE VEHICLE WAS TAKEN TO A LOCAL GARAGE AND THE CONTACT WAS INFORMED THAT THE WHEEL WELDING WAS DEFECTIVE AND CAUSED THE FAILURE. THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 1999 BUICK LESABRE. THE CONTACT STATED THAT WHILE DRIVING OVER A POTHOLE AT A LOW SPEED, THE STRUT HOUSING ON THE FRONT PASSENGER SIDE FAILED AND THE HOOD POPPED OPEN. THE VEHICLE WAS TAKEN TO A LOCAL GARAGE AND THE CONTACT WAS INFORMED THAT THE WHEEL WELDING WAS DEFECTIVE AND CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 124,156.
NHTSA ODI #10419643
66,000 miles · Sep 26, 2007
Suspension
TL*THE CONTACT OWNS A 1999 BUICK LESABRE. WHILE DRIVING APPROXIMATELY 5 MPH, THE CONTACT HEARD A CLUNKING NOISE COMING FROM THE ENGINE COMPARTMENT. HE TOOK THE VEHICLE TO THE REPAIR SHOP AND WAS INFORMED THAT THE STABILIZER BAR SPLIT IN HALF. THE DEALER CURRENTLY DOES NOT HAVE THE PARTS TO REPAIR THE VEHICLE, HOWEVER, THE CON…
Read full complaint
TL*THE CONTACT OWNS A 1999 BUICK LESABRE. WHILE DRIVING APPROXIMATELY 5 MPH, THE CONTACT HEARD A CLUNKING NOISE COMING FROM THE ENGINE COMPARTMENT. HE TOOK THE VEHICLE TO THE REPAIR SHOP AND WAS INFORMED THAT THE STABILIZER BAR SPLIT IN HALF. THE DEALER CURRENTLY DOES NOT HAVE THE PARTS TO REPAIR THE VEHICLE, HOWEVER, THE CONTACT WILL HAVE IT REPAIRED ONCE THE PARTS ARRIVE. THE CURRENT AND FAILURE MILEAGES WERE 66,000. UPDATED 11/14/07
NHTSA ODI #10204137
Mileage unknown · Jan 24, 2005
Suspension
WHILE BACKING UP, THE CONSUMER HEARD A LOUD POPPING NOISE. WHEN THE CONUMER PLACED THE GEAR IN DRIVE, SHE HEARD THE SAME NOISE. THE CAR WAS THEN TOWED TO A DEALER. WHILE BEING INSPECTED, IT WAS DETERMINED THAT THE COIL SPRING HAD FAILED. *JB
NHTSA ODI #10108768
Mileage unknown · Apr 1, 2003
SuspensionCrashInjury
THE VEHICLE WAS INVOLVED IN A ROLL OVER ACCIDENT DUE TO FAULTY REAR SPRINGS, WHICH RESULTED IN ONE FATALITY AND ONE INJURY. *AK. CONSUMER STATED THE REAR SPRING WERE REPLACED, HOWEVER CONSUMER BELIEVED THE FAULTY REAR SUSPENSION WAS THE CAUSE OF HER HUSBAND NOT BEING ABLE TO REGAIN CONTROL OF THE VEHICLE. *JB
NHTSA ODI #10011277
Mileage unknown · Aug 16, 2002
Suspension
SUSPENSION IS NOT WORKING PROPERLY. VEHICLE BECOMES UNSTABLE/ BOUNCING, AND MOVING FROM SIDE TO SIDE TO THE POINT WHERE CONSUMER IS GETTING SICK. CONTACTED DEALER, AND THE DEALER IS NOT WILLING TO DO ANYTHING.*AK
NHTSA ODI #8016528
Mileage unknown · Jul 10, 2001
Electrical SystemEngine And Engine CoolingEquipment
WHEN DRIVING SUSPENSION IS ROUGH. WHEN APPLING PRESSURE VEHICLE SHAKES. DEALERSHIP IS AWARE OF PROBLEM.*AK DEALER REFUSES TO REPLACE THE SHOCKS. AIR CONDITIONER LEAK, DEALER REPLACED COMPRESSOR SHAFT SEAL. PRESSURE OCNTROL SOLENOID REPLACED, CONSUMER STATED WHEN SHIFTING INTO REVERSE OR DRIVE, THERE IS A SHUDDER FELT AT …
Read full complaint
WHEN DRIVING SUSPENSION IS ROUGH. WHEN APPLING PRESSURE VEHICLE SHAKES. DEALERSHIP IS AWARE OF PROBLEM.*AK DEALER REFUSES TO REPLACE THE SHOCKS. AIR CONDITIONER LEAK, DEALER REPLACED COMPRESSOR SHAFT SEAL. PRESSURE OCNTROL SOLENOID REPLACED, CONSUMER STATED WHEN SHIFTING INTO REVERSE OR DRIVE, THERE IS A SHUDDER FELT AT TIMES, DEALER REPLACED THE TURBINE SHAFT SEAL BECAUSE IT WAS WORN AND AGAIN THE VEHICLE JUMPS WHEN PUTTING INTO GEAR AS IF GEAR IS NOT ENGAGING, DEALER CAN NOT REMEDY THIS PROBLEM. ENGINE LIGHT HAS ILLUMINATED. FRONT ROTORS WARPED CAUSING VIBRATION. TURN SIGNALS INOPERABLE, DEALER FOUND WIRE OUT OF TERMINAL. *SLC
NHTSA ODI #892383
Mileage unknown · Mar 6, 2001
Suspension
WHEN VEHICLE RIDES RIDES OVER A BUMP OR A SERIES OF BUMPS NOT READILY VISIBLE, THE BOUNCES ARE ABOVE NORMAL AND IN A SERIES OF BUMPS DIRECTIONAL CONTROL BECOMES SERIOUS.
NHTSA ODI #9002008
Mileage unknown · Mar 6, 2001
Suspension
CONTROL ARM BUSHINGS WERE CAUSING AN UNUSUAL NOISE, DEALER COULD NOT GET PARTS FOR 2 WEEKS. *SLC
NHTSA ODI #882171
Mileage unknown · Sep 29, 2000
Suspension
VEHICLE EXPERIENCING SEVERE PROBLEM WITH REAR OF VEHICLE BOUNCING AND SCRAPING THE ROAD WHENEVER THERE ARE FOUR OR MORE PASSENGERS IN VEHICLE. DEALER NOTIFIED AND INFORMED CONSUMER THAT NOTHING COULD BE FOUND. BUT ONLY TESTED VEHICLE WITH HIMSELF ONLY. FEEL FREE TO PROVIDE ANY FURTHER DETAILS. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 4T65E AUTOMATIC TRANSMISSIONS. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE." A RETAINING CLIP, WHICH SECURES THE MANUAL VALVE TO THE LINKAGE OF THE TRANSMISSION DETENT LEVER, CAN BECOME LOOSE UNDER A COMBINATION OF POSSIBLE DRIVER SHIFTING MANEUVERS AND ALLOW THE LINK TO BECOME DISCONNECTED FROM THE MANUAL VALVE.
Consequence & remedy
Consequence: IF THE LINK DISCONNECTS, THE DRIVER'S INDICATED PRNDL STATE MAY DIFFER FROM THE HYDRAULIC STATE OF THE TRANSMISSION. IF THE DRIVER SELECTS 'DRIVE' AND THE TRANSMISSION IS ACTUALLY IN 'REVERSE', A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE MANUAL VALVE/LINK ASSEMBLY WITH A REPLACEMENT MANUAL VALVE/LINK KIT, FEATURING A SPRING-TYPE FASTENER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
RQ99007 · Transmission Shift Lever Sequence
Opened May 26, 1999 · Closed Feb 8, 2002
Status: closed (inferred from source dates) · Power Train
No summary supplied.
1999 Buick Lesabre Problems, Complaints & Recalls | Skip That Year
Illustration