NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
132 reports78,000 miles · May 20, 2018
Unknown Or Other
WHEN WE PRESS THE LIFGATE BUTTON TO CLOSE IT, IT WILL GODOWN AND YOU THINK IT'S CLOSING AND IT MAKES NOISES AND RAISES AGAIN. DOES THIS SEVERAL TIMES THEN YOU HAVE TO PRESS HARD AND IT WILL FINALLY LATCH. I JUST BOUGHT THIS AND DID NOT THINK TO CHECK THE LIFT GATE ON THE CAR LOT AND WAS AT A STORE OPENING IT FOR THE FIRST TIME …
Read full complaint
WHEN WE PRESS THE LIFGATE BUTTON TO CLOSE IT, IT WILL GODOWN AND YOU THINK IT'S CLOSING AND IT MAKES NOISES AND RAISES AGAIN. DOES THIS SEVERAL TIMES THEN YOU HAVE TO PRESS HARD AND IT WILL FINALLY LATCH. I JUST BOUGHT THIS AND DID NOT THINK TO CHECK THE LIFT GATE ON THE CAR LOT AND WAS AT A STORE OPENING IT FOR THE FIRST TIME AND IT DID THIS SCARED ME I WAS GOING TO BE ABLE TO CLOSE IT TO GO HOME.
NHTSA ODI #11096895
115,000 miles · May 8, 2018
Engine
THE TIMING CHAIN FAILED ON MY BUICK ENCLAVE. THIS IS A KNOWN DEFECT THAT SHOULD BE COVERED BY GM UNDER A RECALL. IT IS HAPPENING FREQUENTLY TO OTHER OWNERS AS WELL. IT IS A SAFETY ISSUE BECAUSE IF IT FAILS WHILE DRIVING IT CAN RESULT IN ACCIDENTS OR INJURY. THE ISSUE OCCURRED WHILE MOVING AND IMPACTED PERFORMANCE, BUT DID NO…
Read full complaint
THE TIMING CHAIN FAILED ON MY BUICK ENCLAVE. THIS IS A KNOWN DEFECT THAT SHOULD BE COVERED BY GM UNDER A RECALL. IT IS HAPPENING FREQUENTLY TO OTHER OWNERS AS WELL. IT IS A SAFETY ISSUE BECAUSE IF IT FAILS WHILE DRIVING IT CAN RESULT IN ACCIDENTS OR INJURY. THE ISSUE OCCURRED WHILE MOVING AND IMPACTED PERFORMANCE, BUT DID NOT RESULT IN AN ACCIDENT FOR ME. I HAD THE ISSUE REPAIRED BY A MECHANIC.
NHTSA ODI #11092571
Mileage unknown · Apr 23, 2018
Seats
BOTH DRIVER AND FRONT PASSENGER SEAT 'TRIM' IS CRACKING AND FALLING APART. WE PURCHASED EXTENDED WARRANTY BUT IT WILL NOT COVER THE FRONT SEAT TRIM BECAUSE ITHEY WON'T. THEY AGREE THAT IT'S NOT A WEAR ITEM LIKE OIL, GAS, BRAKES, OR WIPERS BUT STILL WON'T REPLACE THEM. THE ODD PART IS THAT THE PASSENGER SIDE IS WORSE THAN THE DR…
Read full complaint
BOTH DRIVER AND FRONT PASSENGER SEAT 'TRIM' IS CRACKING AND FALLING APART. WE PURCHASED EXTENDED WARRANTY BUT IT WILL NOT COVER THE FRONT SEAT TRIM BECAUSE ITHEY WON'T. THEY AGREE THAT IT'S NOT A WEAR ITEM LIKE OIL, GAS, BRAKES, OR WIPERS BUT STILL WON'T REPLACE THEM. THE ODD PART IS THAT THE PASSENGER SIDE IS WORSE THAN THE DRIVER'S SIDE BUT IT IS USUALLY EMPTY MONDAY-FRIDAY. IF BOTH OF OUR SEAT TRIM ARE DEMOLISHED AND WE GIVE IT NORMAL WEAR, WE CAN'T THE ONLY ONES OUT THERE WITH THIS RIDICULOUS PROBLEM. THEY JUST STARTED FALLING APART ABOUT A YEAR AGO. I PUT A DATE BECAUSE IT WAS REQUIRED FOR SUBMITTING THIS FORM BUT IT WAS MORE OF A PROGRESSIVE BREAKING APART.
NHTSA ODI #11089762
106,000 miles · Mar 14, 2018
Air Bags
I WAS DRIVING MY CAR AND THE AIRBAG LIGHT CAME ON. I PULLED OUT MY MANUAL AND IT SAYS THAT THE AIRBAGS WILL NOT WORK PROPERLY IF IN A CRASH WITH THIS LIGHT STAYING ON. IT HAS NEVER WENT OFF AND IS A SAFETY HAZARD TO MYSELF AND MY OTHER PASSENGERS SUCH AS MY CHILDREN AND PETS.
NHTSA ODI #11079193
70,000 miles · Mar 12, 2018
Structure
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE VEHICLE WAS TAKEN TO COURTESY OF KINGSPORT (1220 E STONE DR, KINGSPORT, TN 37660, (423) 246-4101) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE). SHORTLY AFTER THE REPAIR, THE LIFTGATE CONTINUED TO COME DOWN AND HAD TO MANUALLY BE CLOSED BY THE CONTACT. THE MANUFACT…
Read full complaint
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE VEHICLE WAS TAKEN TO COURTESY OF KINGSPORT (1220 E STONE DR, KINGSPORT, TN 37660, (423) 246-4101) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE). SHORTLY AFTER THE REPAIR, THE LIFTGATE CONTINUED TO COME DOWN AND HAD TO MANUALLY BE CLOSED BY THE CONTACT. THE MANUFACTURER WAS NOTIFIED AND SUGGESTED HAVING A DEALER REPAIR THE VEHICLE AGAIN. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
NHTSA ODI #11078767
Mileage unknown · Mar 5, 2018
Air Bags
THE SERVICE AIR BAGS LIGHT IS ON. I CALLED DEALER TO FIND OUT HOW MUCH IT WOULD BE AND THEY SAID ANY WHERE FROM 2-3 HUNDRED TO 2-3 THOUSAND. THE AIR BAG WILL NOT DEPLOY UNTIL IT IS FIXED. IT JUST CAME ON OUT OF THE BLUE AFTER STARTING VEHICLE YESTERDAY. I CHECKED FOR RECALLS AND DID NOT FIND ANY.
NHTSA ODI #11076334
74,000 miles · Jan 22, 2018
StructureSuspension
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. WHILE THE POWER LIFTGATE WAS REACHING ITS FULL POSITION, IT INDEPENDENTLY SLAMMED SHUT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO RK CHEVROLET (502 N DELSEA DR, VINELAND, NJ 08360, (856) 696-8400) WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC STRUTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. WHILE THE POWER LIFTGATE WAS REACHING ITS FULL POSITION, IT INDEPENDENTLY SLAMMED SHUT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO RK CHEVROLET (502 N DELSEA DR, VINELAND, NJ 08360, (856) 696-8400) WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC STRUTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT ASSOCIATED WITH THE RECALL. THE CONTACT WAS PROVIDED A CASE NUMBER. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.
NHTSA ODI #11064264
Mileage unknown · Jan 9, 2018
Steering
FRONT RACK AND PINION MAY DEVELOP LEAKS AND NEED COSTLY REPLACEMENT. SYMPTOMS INCLUDE FRONT END NOISE WHEN TURNING RIGHT OR LEFT AT LOW SPEEDS AND FLUID LEAKAGE. NOISE IS SIMILAR TO A BAD STRUT OR POWER STEERING ISSUE. BUICK CUSTOMER SERVICE STATES THERE ARE NO CURRENT RECALLS OR SERVICE BULLETINS FOR RACK AND PINION ON ENCL…
Read full complaint
FRONT RACK AND PINION MAY DEVELOP LEAKS AND NEED COSTLY REPLACEMENT. SYMPTOMS INCLUDE FRONT END NOISE WHEN TURNING RIGHT OR LEFT AT LOW SPEEDS AND FLUID LEAKAGE. NOISE IS SIMILAR TO A BAD STRUT OR POWER STEERING ISSUE. BUICK CUSTOMER SERVICE STATES THERE ARE NO CURRENT RECALLS OR SERVICE BULLETINS FOR RACK AND PINION ON ENCLAVES.
NHTSA ODI #11061431
60,000 miles · Nov 16, 2017
Air Bags
FREQUENT MESSAGE APPEARING IN THE MESSAGE CENTER WHICH INDICATES "SERVICE AIR BAGS'. THE AIRBAG SYMBOL IS ALSO LIT AT THE SAME TIME. THE MESSAGE APPEARS AT DIFFERENT TIMES AND WILL REMAIN LIT FOR ABOUT 8 SECONDS. IT HAPPENS WHILE THE VEHICLE IS IN MOTION OR WHEN STOPPED, HOWEVER NOT AT ANY SPECIFIC TIME. THIS VEHICLE WAS PUR…
Read full complaint
FREQUENT MESSAGE APPEARING IN THE MESSAGE CENTER WHICH INDICATES "SERVICE AIR BAGS'. THE AIRBAG SYMBOL IS ALSO LIT AT THE SAME TIME. THE MESSAGE APPEARS AT DIFFERENT TIMES AND WILL REMAIN LIT FOR ABOUT 8 SECONDS. IT HAPPENS WHILE THE VEHICLE IS IN MOTION OR WHEN STOPPED, HOWEVER NOT AT ANY SPECIFIC TIME. THIS VEHICLE WAS PURCHASED NEW FROM THE BUICK DEALER IN EL PASO, TEXAS AND HAS NEVER BEEN IN ANY TYPE OF COLLISION. AN INTERNET CHECK ON THIS TYPE OF COMPLAINT SHOWS THAT MY VEHICLE YEAR IS PART OF ONGOING PROBLEMS WITH THAT SAME MESSAGE BEING DISPLAYED, HOWEVER MY DEALER INDICATES THAT MY VIN IS NOT PART OF THE RECALL TO HAVE THAT REPAIRED BY BUICK. IN MY OPINION, THIS IS A SAFETY ISSUE AND SHOULD BE COVERED BY BUICK. MY VEHICLE HAS 78,000 MILES ON THE ODOMETER AND HAS BEEN MAINTAINED BY THE DEALER SINCE IT WENT INTO SERVICE. THIS COMPLAINT IS A MANUFACTURER DEFECT WHICH SHOULD BE CORRECTED BY BUICK. THIS COMPLAINT WAS FIRST NOTICED AROUND 11-2016 HOWEVER IT WAS DIFFICULT TO CATCH IT WHEN THE MESSAGE WOULD BE DISPLAYED. IT TOOK MONTHS TO NOTICE IT AS IT IS SHOWN IN THE INCLUDED IMAGE SINCE THE VEHICLE WOULD BE IN MOTION AT THE TIME. I FINALLY WAS ABLE TO GET MY WIFE TO SNAP A PHOTO OF THE MESSAGE BEFORE IT DISAPPEARED FROM THE DASH BOARD.
NHTSA ODI #11046529
104,000 miles · Oct 23, 2017
Structure
TOOK MY VEHICLE IN TO HAVE NHTSA CAMPAIGN 15V415000 COMPLETED (LIFTGATE STRUT FAILURE). TOOK THE VEHICLE HOME FROM THE DEALERSHIP AND THE FIRST TIME I LIFTED THE TAILGATE IT FELL ON ME. CALLED THEM UP AND THEY SAY "OH YES I GUESS THE GAS STRUTS NEED REPLACING -- THE PROGRAM CHANGE DIDN'T DO IT" . APPALLING RECALL SERVICE AT PHI…
Read full complaint
TOOK MY VEHICLE IN TO HAVE NHTSA CAMPAIGN 15V415000 COMPLETED (LIFTGATE STRUT FAILURE). TOOK THE VEHICLE HOME FROM THE DEALERSHIP AND THE FIRST TIME I LIFTED THE TAILGATE IT FELL ON ME. CALLED THEM UP AND THEY SAY "OH YES I GUESS THE GAS STRUTS NEED REPLACING -- THE PROGRAM CHANGE DIDN'T DO IT" . APPALLING RECALL SERVICE AT PHILLIPS BUICK/GMC IN LEESBURG, FLORIDA IF YOU ASK ME.
NHTSA ODI #11035821
Official recalls
6Oct 7, 2021
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration