NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
132 reports86,000 miles · Aug 17, 2017
Steering
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. WHILE DRIVING 5 MPH, THE STEERING WHEEL FAILED TO TURN LEFT OR RIGHT. THE CONTACT TURNED OFF AND RESTARTED THE ENGINE, AND THE VEHICLE RETURNED TO NORMAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT DEALER (JIMMY'S GARAGE INC, LOCATED AT 3124 ELMIRA RD, NEWFIELD, NY 14867; (607) 594-3030), …
Read full complaint
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. WHILE DRIVING 5 MPH, THE STEERING WHEEL FAILED TO TURN LEFT OR RIGHT. THE CONTACT TURNED OFF AND RESTARTED THE ENGINE, AND THE VEHICLE RETURNED TO NORMAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT DEALER (JIMMY'S GARAGE INC, LOCATED AT 3124 ELMIRA RD, NEWFIELD, NY 14867; (607) 594-3030), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.
NHTSA ODI #11015887
Mileage unknown · Jul 13, 2017
Unknown Or Other
AIR CONDITION DIRVER SIDE COOL PASSENGER AND BACK WARM. TOOK CAR TO INTEGRITY AUTOMOTIVE GROUP THEY SAID A/C CONDENSER LEAKING FOUND LEAK FROM REAR AUX. CONDENSER.FOLLOWED PIP16_NA-046. REMOVED AND REPLACED REAR A/C CONDENSER AND BLOWER MOTOR ASSEMBLY. CLEANED CASE AS NEEDED,EVAC & RECHARGED SYSTEM & ADDED DIE AND 134-A AS NEEDE…
Read full complaint
AIR CONDITION DIRVER SIDE COOL PASSENGER AND BACK WARM. TOOK CAR TO INTEGRITY AUTOMOTIVE GROUP THEY SAID A/C CONDENSER LEAKING FOUND LEAK FROM REAR AUX. CONDENSER.FOLLOWED PIP16_NA-046. REMOVED AND REPLACED REAR A/C CONDENSER AND BLOWER MOTOR ASSEMBLY. CLEANED CASE AS NEEDED,EVAC & RECHARGED SYSTEM & ADDED DIE AND 134-A AS NEEDED COST $567 9996 STANDARD 67 CPC
NHTSA ODI #11005147
45,000 miles · Jun 30, 2017
EngineSteeringSuspension
FRONT SUSPENSION HAD TO BE REPLACED. AIR CONDITIONER, EVAPORATOR COMPONENT HAD TO BE REPLACED THREE DIFFERENT OCASIONS..REAR GATE RECALL ,REPLACED LIFT GATES SHOCKS.. MODE VALVE ACTUATOR REPLACEMENT.
NHTSA ODI #11002453
72,000 miles · Jun 12, 2017
Visibility
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. WHILE LOADING SOME ITEMS IN THE BACK OF THE VEHICLE, THE SUN ROOF SHATTERED INTO PIECES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS BEING REPAIRED AT THE DEALER (WALTER JACKSON IN RINGGOLD, GEORGIA), BUT WAS NOT COVERED UNDER WARRANTY. THE VIN WAS UNKNOWN. THE APPROXI…
Read full complaint
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. WHILE LOADING SOME ITEMS IN THE BACK OF THE VEHICLE, THE SUN ROOF SHATTERED INTO PIECES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS BEING REPAIRED AT THE DEALER (WALTER JACKSON IN RINGGOLD, GEORGIA), BUT WAS NOT COVERED UNDER WARRANTY. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.
NHTSA ODI #10994492
96,000 miles · May 10, 2017
StructureInjury
THE POWER BACK DOOR"HATCH" SLAMS SHUT AFTER OPENING. BE THE POWER ON OR OFF. SOMETIMES IT WILL STAY OPEN OTHER TIMES IT SLAMS SHUT. IT DOESN'T MATTER EVEN IF YOU ARE STANDING THERE. IT HAS SLAMMED SEVERAL TIMES ON MY CHILDRENS' HEADS. I EMAILED BUICK BUT THEY STATED MY CAR WAS NOT INVOLVED IN THE RECALL BUT THIS IS OBVIOUSLY THE…
Read full complaint
THE POWER BACK DOOR"HATCH" SLAMS SHUT AFTER OPENING. BE THE POWER ON OR OFF. SOMETIMES IT WILL STAY OPEN OTHER TIMES IT SLAMS SHUT. IT DOESN'T MATTER EVEN IF YOU ARE STANDING THERE. IT HAS SLAMMED SEVERAL TIMES ON MY CHILDRENS' HEADS. I EMAILED BUICK BUT THEY STATED MY CAR WAS NOT INVOLVED IN THE RECALL BUT THIS IS OBVIOUSLY THE SAME PROBLEM THE OTHER 2012 BUICK ENCLAVES WERE HAVING.
NHTSA ODI #10984654
62,000 miles · Dec 2, 2016
Structure
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT THE LIFTGATE INDEPENDENTLY CLOSED ON THE BACK OF AN OCCUPANT. THERE WERE NO INJURIES. THE FAILURE OCCURRED WITHOUT WARNING. PRIOR TO THE FAILURE, THE VEHICLE WAS REMEDIED PER NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE). THE CONTACT WAS INFORMED THAT THE LIFTGATE…
Read full complaint
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT THE LIFTGATE INDEPENDENTLY CLOSED ON THE BACK OF AN OCCUPANT. THERE WERE NO INJURIES. THE FAILURE OCCURRED WITHOUT WARNING. PRIOR TO THE FAILURE, THE VEHICLE WAS REMEDIED PER NHTSA CAMPAIGN NUMBER: 15V415000 (STRUCTURE). THE CONTACT WAS INFORMED THAT THE LIFTGATE STRUTS WERE REPOSITIONED INSTEAD OF HAVING THE SOFTWARE UPDATED AS THE RECALL REMEDY STATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000.
NHTSA ODI #10929570
61,000 miles · Nov 22, 2016
Air Bags
LAST NIGHT (11/21/2016) MY 2012 BUICK ENCLAVE'S PASSENGER AIRBAG LIGHT CAME ON. VEHICLE HAS ONLY 61,000 MILES. I TOOK IT IN AND FOUND OUT THAT THE PASSENGER PRESENCE MODULE NEEDS TO BE REPLACE AT A COST TO ME OF $1100. I WAS ALSO TOLD THAT AIR BAGS WILL NOT DEPLOY IN THE EVENT OF A CRASH. I'VE NOTICED THAT THIS IS AN ONGOING PRO…
Read full complaint
LAST NIGHT (11/21/2016) MY 2012 BUICK ENCLAVE'S PASSENGER AIRBAG LIGHT CAME ON. VEHICLE HAS ONLY 61,000 MILES. I TOOK IT IN AND FOUND OUT THAT THE PASSENGER PRESENCE MODULE NEEDS TO BE REPLACE AT A COST TO ME OF $1100. I WAS ALSO TOLD THAT AIR BAGS WILL NOT DEPLOY IN THE EVENT OF A CRASH. I'VE NOTICED THAT THIS IS AN ONGOING PROBLEM MANY PEOPLE HAVE WITH THIS CAR. HOW IS THIS NOT A RECALL?
NHTSA ODI #10927535
65,925 miles · Nov 22, 2016
Unknown Or Other
POWER LIFT GATE STRUTS FAILED. THIS WAS A RECALL ON OTHER 2012 MODELS. I HAD TO PAY $1113.21 FOR THIS REPAIR. THIS CREATED A SAFETY HAZARD. THIS LIFTGATE FELL ON MY DAUGHTER. WE CAUGHT IT BUT SHE COULD HAVE BEEN HURT.
NHTSA ODI #10927478
63,200 miles · Oct 13, 2016
Unknown Or Other
GM HAD RECALL ON POWER LIFT GATE WERE STRUTS WERE FAILING AND FALLING DOWN ON PEOPLE DECEMBER 2015 THEY DIDN'T REPLACE STRUTS(SAID THEY WERE GOOD)AND JUST REPOSITIONED THEM(BAND AID FIX)MY WIFE WAS HIT WITH LIFT GATE IN THE BACK(LIFTGATE CAME CRASHING DOWN).I TOOK IT TO DEALER FOR THEM TO FIX.I WAS TOLD THAT SINCE THE FIXED THEY…
Read full complaint
GM HAD RECALL ON POWER LIFT GATE WERE STRUTS WERE FAILING AND FALLING DOWN ON PEOPLE DECEMBER 2015 THEY DIDN'T REPLACE STRUTS(SAID THEY WERE GOOD)AND JUST REPOSITIONED THEM(BAND AID FIX)MY WIFE WAS HIT WITH LIFT GATE IN THE BACK(LIFTGATE CAME CRASHING DOWN).I TOOK IT TO DEALER FOR THEM TO FIX.I WAS TOLD THAT SINCE THE FIXED THEY DID IN DEC 2015 LASTED MORE THAN 90 DAYS THEY WEREN'T LIABLE TO REPAIR IT.GM DOESN'T CARE ABOUTR THE HEALTH AND SAFETY OF THEIR CUSTOMERS.THEY SHOULD BE MADE LIABLE TO FIX AND REPLACE THE GAS STRUTS ON THESE POWER LIFT GATES BEFORE SOMEONE BECOMES SERIOUS HURT.$40,000 DOLLAR CAR AND THEY JUST DON'T CARE.IT'S A 2012 BUCIK ENCLAVE.I WAS NEVER TOLD THAT RECALL FIXES ONLY LASTED 90 DAYS?
NHTSA ODI #10915699
42,000 miles · Aug 19, 2016
Air BagsCrashInjury
WAS INVOLVED IN AN ACCIDENT WHERE ANOTHER DRIVER SEEMINGLY PROCEEDED THRU A STOP SIGN WITHOUT AN ACTUAL STOP, MY CAR WAS HIT ON THE LEFT SIDE OF THE CAR...FROM SIDE DRIVER'S DOOR TO FRONT PORTION OF VEHICLE, INCLUDING GRILL...LEFT SIDE TIRE WAS BUCKLED INTO VEHICLE WITH PROBABLE AXLE DAMAGE, ETC. NONE OF THE AIR BAGS WERE DEPL…
Read full complaint
WAS INVOLVED IN AN ACCIDENT WHERE ANOTHER DRIVER SEEMINGLY PROCEEDED THRU A STOP SIGN WITHOUT AN ACTUAL STOP, MY CAR WAS HIT ON THE LEFT SIDE OF THE CAR...FROM SIDE DRIVER'S DOOR TO FRONT PORTION OF VEHICLE, INCLUDING GRILL...LEFT SIDE TIRE WAS BUCKLED INTO VEHICLE WITH PROBABLE AXLE DAMAGE, ETC. NONE OF THE AIR BAGS WERE DEPLOYED, AND I HIT MY HEAD ON THE DRIVER'S WINDOW, BREAKING THE WINDOW, RESULTING IN SERIOUS HEAD INJURIES, ETC. MY VEHICLE WAS ON A CITY STREET, 4 WAY STOP, AND HAD JUST STARTED AUTO MOTION TO TURN LEFT AT INTERSECTION. I WILL BE ABLE TO PROVIDE PHOTOS AND ADDITIONAL DOCUMENTATION AS REQUESTED.
NHTSA ODI #10897159
Official recalls
6Oct 7, 2021
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration