NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
15 reportsMileage unknown · Sep 1, 2026
Electrical System
On 8/31/2026 this 2020 BMW X4 was serviced at an authorized dealer (BMW of Tyler) to execute the remedy for official NHTSA Safety Recall Campaign 25V-636 (Engine Starter Relay Fire Risk). INCIDENT DESCRIPTION: Within minutes of picking up the vehicle post-repair and entering an active roadway, the vehicle suffered an immediate, …
Read full complaint
On 8/31/2026 this 2020 BMW X4 was serviced at an authorized dealer (BMW of Tyler) to execute the remedy for official NHTSA Safety Recall Campaign 25V-636 (Engine Starter Relay Fire Risk). INCIDENT DESCRIPTION: Within minutes of picking up the vehicle post-repair and entering an active roadway, the vehicle suffered an immediate, un-warned, total loss of all electrical power. The engine stalled, all digital dashboard instrumentation went black, and power steering/braking assistance were compromised. The vehicle came to a complete stop in moving traffic. The total power failure prevented the activation of hazard lights, rendering the blacked-out vehicle invisible to surrounding traffic and nearly causing a high-speed rear-end collision. The vehicle was towed back to the dealer center. TECHNICAL BASIS FOR DEFECT/WORKMANSHIP FAILURE: Campaign 25V-636 requires replacing or manipulating vulnerable electrical relay and starter assembly points tied directly to the main 12V electrical infrastructure and power distribution system. A total, sudden in-motion electrical blackout strongly indicates an open-circuit failure, improper terminal torque specifications, or damage to the adjacent Intelligent Battery Sensor (IBS) network occurring during the recall execution. The dealer is attempting to claim a coincidental "faulty battery" caused the in-motion shutdown to avoid workmanship liability. However, a battery failure does not completely choke out a running engine already under alternator load unless an open circuit or severe grounding fault is actively introduced. This incident represents a catastrophic failure directly following the execution of an official federal safety recall remedy.
NHTSA ODI #11761428
Mileage unknown · Jun 9, 2026
SteeringSuspensionWheels
I am filing a safety complaint for my 2020 BMW X4, VIN [XXX]. The vehicle recently began making a noticeable noise while turning. I reported this to an authorized BMW dealer before/during service and requested review for possible front-end, steering, suspension, axle, swivel bearing, tie rod, thrust rod, or vehicle-control safet…
Read full complaint
I am filing a safety complaint for my 2020 BMW X4, VIN [XXX]. The vehicle recently began making a noticeable noise while turning. I reported this to an authorized BMW dealer before/during service and requested review for possible front-end, steering, suspension, axle, swivel bearing, tie rod, thrust rod, or vehicle-control safety issues. The dealer stated it did not find a swivel bearing issue, but identified worn thrust rod bushings and collapsed motor mounts. I was quoted approx. $1,950 for thrust rods and approx. $3,450 for motor mounts. I am concerned the worn thrust rod bushings involve the same general front suspension/steering/vehicle-handling system as the turning-noise concern I reported. I asked BMW North America and the dealer to review whether this condition may relate to or overlap with known BMW X4 steering/front axle/suspension recalls, including NHTSA Recall Nos. 19V678000, 19V738000, and 20V355000. BMW/dealer representatives stated there are no open recalls for my VIN and that BMW NA will not provide assistance, but I have not received a complete written explanation confirming that the dealer’s actual findings were reviewed against those recalls, campaigns, or safety concerns. On XXX, the service manager emailed that BMW NA Customer Relations allegedly said there are no open cases, the most recent case was closed, no assistance will be provided for suspension concerns, and the vehicle has no open recalls. The same email required return of the loaner by 5:00 PM if repairs are not approved. I am concerned this pressure is occurring before a complete safety/recall review is provided. No crash, injury, or fire occurred. I am requesting NHTSA review potential safety concerns involving the 2020 BMW X4 front suspension, steering, thrust rod bushings, swivel bearings, tie rods, motor mounts, turning-related noise, and whether additional VINs should be reviewed for recall/campaign applicability. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11742911
Mileage unknown · Mar 10, 2026
Structure
-Electrical damage due to leak. Water entered through the roof shark fin antenna, leading to corrosion /severe water damage to the Telematics Communication Box Module. -Failure of BMW Emergency SOS Call System, GPS, and Microphone/ Voice for hands-free access. -Warning notification on dashboard "Emergency SOS Malfunction" -Veh…
Read full complaint
-Electrical damage due to leak. Water entered through the roof shark fin antenna, leading to corrosion /severe water damage to the Telematics Communication Box Module. -Failure of BMW Emergency SOS Call System, GPS, and Microphone/ Voice for hands-free access. -Warning notification on dashboard "Emergency SOS Malfunction" -Vehicle taken to BMW certified service, told that water was coming from the roof antenna, shortening the TCB
NHTSA ODI #11723192
Mileage unknown · Feb 17, 2026
Electrical System
The contact owns a 2020 BMW X4. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The contact had not experienced a failure.
NHTSA ODI #11718434
Mileage unknown · Jan 3, 2026
Suspension
I am filing a complaint regarding what I believe is a manufacturer defect in my BMW vehicle. During a recent visit to an authorized BMW dealership for a routine oil change, I was informed that the front tension joints (tension struts) must be replaced because the rubber bushings/gaskets are cracked and leaking fluid. My vehicle…
Read full complaint
I am filing a complaint regarding what I believe is a manufacturer defect in my BMW vehicle. During a recent visit to an authorized BMW dealership for a routine oil change, I was informed that the front tension joints (tension struts) must be replaced because the rubber bushings/gaskets are cracked and leaking fluid. My vehicle has fewer than 33,000 miles, and I drive infrequently. This was missed during the last oil change which was 6-8k miles ago. This type of failure at such low mileage is unreasonable and inconsistent with normal wear and tear. The dealership quoted approximately $1,800 plus tax, not sure if it includes a required wheel alignment, to repair the issue. BMW has declined responsibility and stated the damage could caused by road conditions. However, after researching this issue, I have found that premature failure of BMW front tension strut bushings is a widely reported and recurring problem affecting many BMW vehicles at low mileage. This indicates a design or manufacturing defect, not misuse. This defect presents a serious safety risk, as failed or leaking tension joints can lead to: Loss of steering control Poor braking stability Increased risk of crash Despite the known nature of this problem, BMW has not issued a recall or provided coverage, placing the financial burden and safety risk on consumers. I am requesting that this issue be formally investigated and that BMW be held accountable for repairing or reimbursing this defect, as it poses a potential vehicle safety hazard and appears to be systemic.
NHTSA ODI #11708524
Mileage unknown · Sep 19, 2025
Air BagsElectrical SystemSeats
I went to the car wash and when I turned my car back on it stated the the Driver's Restraints system malfunction.
NHTSA ODI #11688269
Mileage unknown · Jul 7, 2025
Engine
The Oil filter housing on my BMW X4 failed randomly while parked over night causing my vehicle to be depleted off coolant. If you want to inspect the part you will have to reach out to bmw of Columbus for documentation and I can provide the record for repair once complete.This caused my vehicle to be immobilized. If my vehicle h…
Read full complaint
The Oil filter housing on my BMW X4 failed randomly while parked over night causing my vehicle to be depleted off coolant. If you want to inspect the part you will have to reach out to bmw of Columbus for documentation and I can provide the record for repair once complete.This caused my vehicle to be immobilized. If my vehicle had been on the road like previously I would’ve been stranded. There were no warning lights or leaks prior to the vehicle malfunctioning. I ubered to get coolant and once filling the reservoir the coolant immediately leaked out resulting in me needing a tow to the dealership. This problem has been reproduced with many dealers as there’s numerous of report of this online and I believe the dealer has inspected this part but is refusing to replace or recall this part under any type of program or create any type of solution to make this not happen again. There wasn’t any small leaks or warning lights shown before this issue spawned all at once then after showing the low coolant light.
NHTSA ODI #11671661
Mileage unknown · Nov 20, 2024
Seat Belts
Seatbelt driver restraint malfunctioning light came on .
NHTSA ODI #11626312
42,000 miles · Jun 21, 2024
Air BagsSeat Belts
The contact owns a 2020 BMW X4. The contact stated that while driving at an undisclosed speed, the "Restrain System Fault" message was displayed. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the driver's side seat belt. The vehicle was not repaired. After investigating the…
Read full complaint
The contact owns a 2020 BMW X4. The contact stated that while driving at an undisclosed speed, the "Restrain System Fault" message was displayed. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the driver's side seat belt. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V164000 (Seat Belt, Air Bags) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 42,000.
NHTSA ODI #11595719
Mileage unknown · Feb 14, 2024
SuspensionUnknown Or Other
My bmw x4M competition 2020 has pop off a sign that said chassis possible continue driving . It put me in sport suspension and it off traction mode . It is very dangerous for me to drive because in a snow or rainy day it very slippery and sometime I almost cash because slip indicators turn on . I cannot turn it off to drive safe…
Read full complaint
My bmw x4M competition 2020 has pop off a sign that said chassis possible continue driving . It put me in sport suspension and it off traction mode . It is very dangerous for me to drive because in a snow or rainy day it very slippery and sometime I almost cash because slip indicators turn on . I cannot turn it off to drive safe and vehicle drive very different .
NHTSA ODI #11571803
Official recalls
10Sep 23, 2025
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
Consequence & remedy
Consequence: A short circuit in the starter relay may increase the risk of a fire.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.
Aug 2, 2021
BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without assist) remains available.
Consequence & remedy
Consequence: Loss of braking assist can increase the risk of a crash.
Remedy: Dealers will update the engine management software, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Feb 19, 2021
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Back Over Prevention:software
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Back Over Prevention: Sensing System: Camera
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Sep 30, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 X3 sDrive 30i, X3 xDrive 30i, X3M 40i, X3 xDrive 30e, X4 xDrive 30i, X4M 40i, 530i, 540i, 540i xDrive, M550i xDrive, M5, 550e, 550e xDrive, and 550e iPerformance vehicles. A small portion of the rearview image may be slightly obscured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: If the driver relies on only the rearview camera image, the reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, program the rearview camera with updated software. The recall began November 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jun 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2019 Z4 sDrive30i, 2019-2020 330i xDrive, M340i and M340i xDrive, 2020 X3M and X4M, and Toyota Supra vehicles. In certain driving conditions, such as high temperatures and rough road surfaces, a steering gear tie rod may become damaged, possibly resulting in a fractured tie rod.
Consequence & remedy
Consequence: A damaged or fractured tie rod may affect vehicle handling and control, increasing the risk of a crash.
Remedy: BMW and Toyota will notify owners, and dealers will replace the steering gear tie rods, free of charge. The recall began August 14, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
Mar 19, 2020
BMW of North America, LLC (BMW) is recalling certain 2020 X3 xDrive30e, X4 xDrive30i, X4 M40i, X4M, 330i, 330i xDrive, M340i, 840i Gran Coupe, 840i xDrive Gran Coupe, M850i xDrive Gran Coupe, M8 Gran Coupe, X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, and 840i xDrive Convertible vehicles. The sensors in the front seat belt buckles may inaccurately detect a belted occupant as unbelted, possibly causing the air bag and seat belt pretensioners to deploy improperly in the event of a crash.
Consequence & remedy
Consequence: If the air bag and/or seat belt pretensioners deploy improperly in the event of a crash, there is an increased risk of injury to the driver and front passenger.
Remedy: BMW will notify owners, and dealers will inspect and replace the front seat belt buckles, as necessary, free of charge. The recall began May 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (4)
Seat Belts:pretensioner
BMW of North America, LLC (BMW) is recalling certain 2020 X3 xDrive30e, X4 xDrive30i, X4 M40i, X4M, 330i, 330i xDrive, M340i, 840i Gran Coupe, 840i xDrive Gran Coupe, M850i xDrive Gran Coupe, M8 Gran Coupe, X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, and 840i xDrive Convertible vehicles. The sensors in the front seat belt buckles may inaccurately detect a belted occupant as unbelted, possibly causing the air bag and seat belt pretensioners to deploy improperly in the event of a crash.
Consequence: If the air bag and/or seat belt pretensioners deploy improperly in the event of a crash, there is an increased risk of injury to the driver and front passenger.
Remedy: BMW will notify owners, and dealers will inspect and replace the front seat belt buckles, as necessary, free of charge. The recall began May 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Seat Belts:front:warning Light/devices
BMW of North America, LLC (BMW) is recalling certain 2020 X3 xDrive30e, X4 xDrive30i, X4 M40i, X4M, 330i, 330i xDrive, M340i, 840i Gran Coupe, 840i xDrive Gran Coupe, M850i xDrive Gran Coupe, M8 Gran Coupe, X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, and 840i xDrive Convertible vehicles. The sensors in the front seat belt buckles may inaccurately detect a belted occupant as unbelted, possibly causing the air bag and seat belt pretensioners to deploy improperly in the event of a crash.
Consequence: If the air bag and/or seat belt pretensioners deploy improperly in the event of a crash, there is an increased risk of injury to the driver and front passenger.
Remedy: BMW will notify owners, and dealers will inspect and replace the front seat belt buckles, as necessary, free of charge. The recall began May 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Seat Belts:front:buckle Assembly
BMW of North America, LLC (BMW) is recalling certain 2020 X3 xDrive30e, X4 xDrive30i, X4 M40i, X4M, 330i, 330i xDrive, M340i, 840i Gran Coupe, 840i xDrive Gran Coupe, M850i xDrive Gran Coupe, M8 Gran Coupe, X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, and 840i xDrive Convertible vehicles. The sensors in the front seat belt buckles may inaccurately detect a belted occupant as unbelted, possibly causing the air bag and seat belt pretensioners to deploy improperly in the event of a crash.
Consequence: If the air bag and/or seat belt pretensioners deploy improperly in the event of a crash, there is an increased risk of injury to the driver and front passenger.
Remedy: BMW will notify owners, and dealers will inspect and replace the front seat belt buckles, as necessary, free of charge. The recall began May 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags
BMW of North America, LLC (BMW) is recalling certain 2020 X3 xDrive30e, X4 xDrive30i, X4 M40i, X4M, 330i, 330i xDrive, M340i, 840i Gran Coupe, 840i xDrive Gran Coupe, M850i xDrive Gran Coupe, M8 Gran Coupe, X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, and 840i xDrive Convertible vehicles. The sensors in the front seat belt buckles may inaccurately detect a belted occupant as unbelted, possibly causing the air bag and seat belt pretensioners to deploy improperly in the event of a crash.
Consequence: If the air bag and/or seat belt pretensioners deploy improperly in the event of a crash, there is an increased risk of injury to the driver and front passenger.
Remedy: BMW will notify owners, and dealers will inspect and replace the front seat belt buckles, as necessary, free of charge. The recall began May 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Mar 18, 2020
BMW of North America, LLC (BMW) is recalling certain 2019-2020 X4 xDrive30i and X4 M40i, and 2018-2020 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3M vehicles. The instrument panel casing may not have been tightened properly to the passenger air bag.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, the air bag could damage the instrument panel and cause small pieces of the panel to strike the driver or other occupants, increasing the risk of injury.
Remedy: BMW will notify owners, and dealers will replace the instrument panel casing, free of charge. The recall began May 15, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2019-2020 X4 xDrive30i and X4 M40i, and 2018-2020 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3M vehicles. The instrument panel casing may not have been tightened properly to the passenger air bag.
Consequence: In the event of a crash necessitating air bag deployment, the air bag could damage the instrument panel and cause small pieces of the panel to strike the driver or other occupants, increasing the risk of injury.
Remedy: BMW will notify owners, and dealers will replace the instrument panel casing, free of charge. The recall began May 15, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Electrical System: Instrument Cluster/panel
BMW of North America, LLC (BMW) is recalling certain 2019-2020 X4 xDrive30i and X4 M40i, and 2018-2020 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3M vehicles. The instrument panel casing may not have been tightened properly to the passenger air bag.
Consequence: In the event of a crash necessitating air bag deployment, the air bag could damage the instrument panel and cause small pieces of the panel to strike the driver or other occupants, increasing the risk of injury.
Remedy: BMW will notify owners, and dealers will replace the instrument panel casing, free of charge. The recall began May 15, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Oct 16, 2019
BMW of North America, LLC (BMW) is recalling certain 2020 BMW X3 M40i and X4 M40i vehicles. The steering rack pinion teeth may break under load, resulting in a loss of steering control.
Consequence & remedy
Consequence: A loss of steering control increases risk of a crash.
Remedy: BMW has notified owners, and dealers will replace the steering gear, free of charge. The recall began October 9, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Sep 27, 2019
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: The lack of an image in the back-up camera display increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
Sep 25, 2019
BMW of North America, LLC (BMW) is recalling certain 2020 X3 sDrive30i, X3 xDrive30i, and X3 M40i vehicles, X4 xDrive30i, and X4 M40i vehicles. The front axle swivel bearings may not have been properly heat treated during manufacturing, reducing their strength and possibly causing them to break.
Consequence & remedy
Consequence: Broken swivel bearings can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: BMW has notified owners and instructed them to not drive their vehicles. Dealers will replace the front axle swivel bearings, free of charge. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Suspension:front
BMW of North America, LLC (BMW) is recalling certain 2020 X3 sDrive30i, X3 xDrive30i, and X3 M40i vehicles, X4 xDrive30i, and X4 M40i vehicles. The front axle swivel bearings may not have been properly heat treated during manufacturing, reducing their strength and possibly causing them to break.
Consequence: Broken swivel bearings can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: BMW has notified owners and instructed them to not drive their vehicles. Dealers will replace the front axle swivel bearings, free of charge. Owners may contact BMW customer service at 1-800-525-7417.
Steering
BMW of North America, LLC (BMW) is recalling certain 2020 X3 sDrive30i, X3 xDrive30i, and X3 M40i vehicles, X4 xDrive30i, and X4 M40i vehicles. The front axle swivel bearings may not have been properly heat treated during manufacturing, reducing their strength and possibly causing them to break.
Consequence: Broken swivel bearings can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: BMW has notified owners and instructed them to not drive their vehicles. Dealers will replace the front axle swivel bearings, free of charge. Owners may contact BMW customer service at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration