2018 BMW X3

Passneger occupancy sensor keeps failing due to a known issue with BMW X3 G01. Seat wiring circuit keeps experiencing electrical problems and failing to detect passenger. This can lead to airbags not deploying in the event of collision. Third time the issue has been repaired and customer was responsible for almost $1200 in costs

The sos antenna in our x3 had a leak around the seal due to a poor design. Over time the tcb got corroded and caused an sos system malfunction. I have researched other cases in which a malfunction had not popped up, but still replicated the same issues as with the warning. Part of the module is the automatic sos help, if one were to get into an accident and rely on this system not realizing it was faulty, it could result in much slower response times if said person were unable to access a phone able to call proper emergency response teams.

While reversing heard a clanking noise (like a heavy wrench falling off from few feet). Came out and checked and found a broken piece of suspension coil spring near the front left wheel. Checked the inner portion of the coil with hand and felt uneven surface on the lower part of the coil similar to the unevenness on the broken part. Remaining coil is still hard to move and seems to be in place. Car is only 6 yrs old and driven for less than 35k miles. Asked around with local shops and they say with this age and miles it should not crack like this and could be a quality issue. No rust is visible and remaining part of coil looks intact. Please check photo as well.

The contact owns a 2018 BMW X3. The contact stated while his wife was driving 65 MPH, a message advising to stop driving was displayed, and the vehicle simultaneously shifted into neutral(N) independently. The vehicle stalled in the middle of the highway and failed to respond while depressing the accelerator pedal. The message advising to drive with caution was displayed after several minutes, and the contact was able to continue driving upon depressing the accelerator pedal. The vehicle was taken to an unknown dealer to be diagnosed. The vehicle was not diagnosed or repaired. The vehicle was then towed to the local dealer, where it was diagnosed that coolant was leaking from a hose. Additionally, the dealer informed the contact that excessive engine temperature could have damaged the cylinder head and the rod bearings. The dealer recommended replacing the engine. The vehicle was not repaired. The contact stated that his son-in-law then towed the vehicle to another facility, where the vehicle was diagnosed by a mechanic; however, no engine failure or coolant leak were found. The contact related the failure to an unknown recall. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 152,942.

2018 BMW X3 M40i - after the car was washed in a car wash, the tailgate started opening and closing on its own. Would open all the way up, wait a few seconds then close all the way down and lock itself. It happened about 20 times until it stopped on its own. This started immediately after the car was parked in the garage. Did not happen while driving. The button on the remote control was not pressed at all. The tailgate would beep and flash the taillights when opening and closing.

Something is wrong with the BMW OEM windshields with HUD. I have had to completely replace 3 in 5 years. In between replacements have had Safeliite try and fill pits in it. My last windshield lasted 21 days before cracking on the side at the very edge. I was driving and the road construction had very uneven lane heights so the car was higher on the passenger side. All of the sudden I heard a crack. The was not rock or debris that hit the windshield. There have been lots of complaints about the BMW windshields with HUD especially the X series SUV’s. People are saying softer glass. All I know is this is dangerous and BMW is up charging for replacement windshields if you don’t have insurance or a warranty. The cost is in the thousands for the replacement. I’ve never had a car that had such issues with the windshield being damaged so easily and or faulty glass. My last windshield replacement was 6/29/23, cracked 7/20/23

I am writing to report a potential safety problem with my 2018 BMW X3, VIN: (provide VIN here if available), that was purchased in May 2018 and has covered 36,000 miles since then. The vehicle has always been garaged and well-maintained. A few weeks ago, I experienced a critical malfunction with the vehicle's moonroof. I opened it normally, but it failed to close afterwards. I should note that this was merely the 4th or 5th time I have ever operated the moonroof since the car was purchased. As of now, the moonroof remains in the open position unable to close it even manually. With summer on the horizon, the interior of the car is exposed to direct sunlight and increasing temperatures. This situation raises significant concerns for my family, particularly the potential health risks to my 7-year-old daughter due to prolonged exposure to excessive heat and sunlight. Upon experiencing this issue, I contacted the service department for troubleshooting. The technicians diagnosed the issue as a problem with the interior sunshade motor, an electrical issue that necessitates a labor-intensive process to fix, including the removal of the vehicle's headliner. Subsequently, I reached out to BMW North America, seeking support and resolution for this significant malfunction. To my disappointment, they declined to acknowledge the problem or offer any assistance towards remediation. This response was unexpected and unsatisfactory, considering the potential health risks and safety concerns the malfunctioning moonroof poses to occupants of the vehicle. I respectfully request your department to investigate this matter and take appropriate action to protect the safety and wellbeing of consumers who may be dealing with similar issues. This may well represent a widespread manufacturing defect that could affect numerous vehicles of the same make and model, thereby posing substantial risks to a large number of people. Thank you for your attention to this matter. The contact stated that the manufacturer initially told them that th