NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
143 reports100,000 miles · Jan 19, 2018
SeatsFire
MY HEATED DRIVER SIDE SEAT SHORTED OUT AND BURNED A HOLE IN THE LEATHER SEAT, AND LUCKILY BEING IN THE AUTO INDUSTRY AND HAVING A KNOWLEDGE OF SEAT CONSTRUCTION I IMMEDIATELY TURNED THE SEAT OFF. THERE ARE NUMEROUS REPORTS OF THIS ISSUE ON VARIOUS BMW FORUMS., INCLUDING FIRES! I THINK THIS IS A SERIOUS SAFETY DEFECT THAT BMW S…
Read full complaint
MY HEATED DRIVER SIDE SEAT SHORTED OUT AND BURNED A HOLE IN THE LEATHER SEAT, AND LUCKILY BEING IN THE AUTO INDUSTRY AND HAVING A KNOWLEDGE OF SEAT CONSTRUCTION I IMMEDIATELY TURNED THE SEAT OFF. THERE ARE NUMEROUS REPORTS OF THIS ISSUE ON VARIOUS BMW FORUMS., INCLUDING FIRES! I THINK THIS IS A SERIOUS SAFETY DEFECT THAT BMW SHOULD BE HELD ACCOUNTABLE TO FIX AND REPAIR.
NHTSA ODI #11063767
Mileage unknown · Jan 17, 2018
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2006 BMW X3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V605000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (FERMAN BMW, 31400 US HWY 19 N,…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2006 BMW X3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V605000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (FERMAN BMW, 31400 US HWY 19 N, PALM HARBOR, FL 34684) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11063338
Mileage unknown · Jan 9, 2018
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2006 BMW X3. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V605000 (AIR BAGS), BUT DID NOT RECEIVE A NOTIFICATION. THE DEALER (BMW OF THE WOODLANDS, 17830 N FWY SERVICE RD, THE WOODLANDS, TX 77384, (936) 776-4610) WAS …
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2006 BMW X3. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V605000 (AIR BAGS), BUT DID NOT RECEIVE A NOTIFICATION. THE DEALER (BMW OF THE WOODLANDS, 17830 N FWY SERVICE RD, THE WOODLANDS, TX 77384, (936) 776-4610) WAS UNABLE TO DETERMINE WHEN THE REMEDY AND PARTS WOULD BE SUPPLIED FROM THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11061517
105,000 miles · Jan 8, 2018
Air BagsSeats
HEAD PROTECTION SYSTEM WAS DEACTIVATED THE AIR BAG WARNING LAMP ILLUMINATED AND THE AIR BAG "ON-OFF" LAMP ILLUMINATED AS WELL. AFTER PURCHASE THERE WAS NO ILLUMINATION OF THESE LIGHTS AND THEN ABOUT 2 YEARS LATER WHILE DRIVING IN THE CITY AT ABOUT 45 MPH, BOTH LAMPS ILLUMINATED WHEN MY SON AND I WERE HEADING TO THE STORE. I CAL…
Read full complaint
HEAD PROTECTION SYSTEM WAS DEACTIVATED THE AIR BAG WARNING LAMP ILLUMINATED AND THE AIR BAG "ON-OFF" LAMP ILLUMINATED AS WELL. AFTER PURCHASE THERE WAS NO ILLUMINATION OF THESE LIGHTS AND THEN ABOUT 2 YEARS LATER WHILE DRIVING IN THE CITY AT ABOUT 45 MPH, BOTH LAMPS ILLUMINATED WHEN MY SON AND I WERE HEADING TO THE STORE. I CALLED BMW AND THEY TOLD ME THEN THAT IT WAS PROBABLY DUE TO A CRACKED SEAT MAT SENSOR AND A RECALL ON THOSE SENSORS WAS BEING EXTENDED FOR 2006 X3 MODELS. I CALLED OUR LOCAL BMW TODAY TO SCHEDULE A REPAIR OF THE SEAT AND HAVE THE CAR PARKED IN THE GARAGE SINCE AUGUST 2017 DUE TO A POSSIBLE VEHICLE SAFETY ISSUE WITH A SYSTEM FAILURE OF AIRBAG DEPLOYMENT. MY SON HAS BEEN UNABLE TO USE THE CAR FOR COLLEGE WHICH IS 4 HOURS AWAY. NOW I WOULD LIKE TO UNDERSTAND WHY THIS VEHICLE IS NOT CONSIDERED UNDER THE EXTENDED WARRANTY NOTICES OF 08V384000 OR 17V605000.
NHTSA ODI #11061218
Mileage unknown · Dec 30, 2017
Air Bags
PERTAINING TO BMW RECALL CAMPAIGN 17V-605. THIS RECALL HAS BEEN GOING ON FOR MORE THAN TWO YEARS AND THE MANUFACTURER DOES NOT HAVE ANY IDEA WHEN PARTS WILL BE AVAILABLE. THE PART IN QUESTION IS AVAILABLE FOR PURCHASE FROM DEALERS. I DON'T FEEL THAT BMW IS HANDLING THIS RECALL PROPERLY, ESPECIALLY AS IT CONCERNS PASSENGER SAFETY…
Read full complaint
PERTAINING TO BMW RECALL CAMPAIGN 17V-605. THIS RECALL HAS BEEN GOING ON FOR MORE THAN TWO YEARS AND THE MANUFACTURER DOES NOT HAVE ANY IDEA WHEN PARTS WILL BE AVAILABLE. THE PART IN QUESTION IS AVAILABLE FOR PURCHASE FROM DEALERS. I DON'T FEEL THAT BMW IS HANDLING THIS RECALL PROPERLY, ESPECIALLY AS IT CONCERNS PASSENGER SAFETY. THE AFFECTED PART IS THE PASSENGER SEAT AIRBAG SENSOR MAT.
NHTSA ODI #11057503
125,000 miles · Dec 12, 2017
Electrical SystemExterior Lighting
INTERNAL HEADLIGHT WIRING IS EXTREMELY FLAKING OFF ITS INSULATION, REVEALING BARE WIRES THROUGHOUT BOTH HEADLIGHTS. BOTH SECTIONS OF THE LIGHT ARE AFFECTED, XENON AND HALOGEN. DISCOVERED DURING ROUTINE BULB REPLACEMENT. MERELY TOUCHING THE WIRES CAUSED EXTRA FLAKING. SEEMS TO BE A POTENTIAL ELECTROCUTION/FIRE HAZARD.
NHTSA ODI #11054295
75,000 miles · Dec 4, 2017
Air BagsCrash
TL* THE CONTACT OWNED A 2006 BMW X3. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT'S SHOE BECAME ENTANGLED WITH THE ACCELERATOR PEDAL. AS A RESULT, THE VEHICLE CRASHED INTO A TREE. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REP…
Read full complaint
TL* THE CONTACT OWNED A 2006 BMW X3. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT'S SHOE BECAME ENTANGLED WITH THE ACCELERATOR PEDAL. AS A RESULT, THE VEHICLE CRASHED INTO A TREE. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000.
NHTSA ODI #11052375
135,000 miles · Dec 2, 2017
Seat Belts
MY DRIVERS SEAT BELT RANDOMLY UNLATCHES WHILE I AM DRIVING. THIS HAS HAPPENED MORE THAN 10 TIMES , BOTH ON SIDE STREETS AND THE FREEWAY. A WEEK AGO I WAS COMING HOME AND ABOUT A BLOCK FROM MY HOUSE THE SEAT BELT LIGHT LIT UP ON MY DASH AND STARTED DINGING. MY SEAT BELT WAS LATCHED. IT CONTINUED TO DING UNTIL I GOT HOME AND TURN…
Read full complaint
MY DRIVERS SEAT BELT RANDOMLY UNLATCHES WHILE I AM DRIVING. THIS HAS HAPPENED MORE THAN 10 TIMES , BOTH ON SIDE STREETS AND THE FREEWAY. A WEEK AGO I WAS COMING HOME AND ABOUT A BLOCK FROM MY HOUSE THE SEAT BELT LIGHT LIT UP ON MY DASH AND STARTED DINGING. MY SEAT BELT WAS LATCHED. IT CONTINUED TO DING UNTIL I GOT HOME AND TURNED OFF THE VEHICLE.
NHTSA ODI #11052016
150,000 miles · May 26, 2017
Exterior Lighting
HEADLIGHT WENT OUT, UPON INSPECTION BY A LOCAL INDEPENDENT BMW SPECIALIST IT WAS BROUGHT TO MY ATTENTION THAT THE RUBBER INSULATION ON ALL OF THE WIRING INSIDE MY XENON HID IS FLAKING OFF. I WAS TOLD THOSE A COMMON ISSUE ON MOST MID 2000S BMWS. I WAS QUOTED 4000 FOR REPLACEMENT OF BOTH HEADLIGHTS AND THEY WOULD EVENTUALLY BEGIN …
Read full complaint
HEADLIGHT WENT OUT, UPON INSPECTION BY A LOCAL INDEPENDENT BMW SPECIALIST IT WAS BROUGHT TO MY ATTENTION THAT THE RUBBER INSULATION ON ALL OF THE WIRING INSIDE MY XENON HID IS FLAKING OFF. I WAS TOLD THOSE A COMMON ISSUE ON MOST MID 2000S BMWS. I WAS QUOTED 4000 FOR REPLACEMENT OF BOTH HEADLIGHTS AND THEY WOULD EVENTUALLY BEGIN TO FLAKE AGAIN. WITH THE RECENT ONSET OF BMWS CATCHING ON FIRE I WOULD THINK THIS IS A POSSIBLE RECALL ISSUE.
NHTSA ODI #10991785
Mileage unknown · May 18, 2017
Air Bags
TAKATA RECALL.
NHTSA ODI #10990462
Official recalls
2Sep 28, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2010 BMW X3 2.5i, X3 3.0i and X3 xDrive30i Sports Activity Vehicles. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. Interim owner notification letters were mailed on November 27, 2017. A second notification letter will be sent when parts are available. Owners may contact BMW customer service at 1-800-525-7417.
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Illustration