TL* THE CONTACT OWNS A 2006 BMW X3. THE CONTACT STATED THAT THERE WAS FLUID LEAKING FROM THE VEHICLE AND THE COOLANT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE COOLANT RESERVOIR, BUT THE VEHICLE CONTINUED TO LEAK. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING O…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW X3. THE CONTACT STATED THAT THERE WAS FLUID LEAKING FROM THE VEHICLE AND THE COOLANT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE COOLANT RESERVOIR, BUT THE VEHICLE CONTINUED TO LEAK. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #11174232
99,000 miles · Nov 25, 2018
Electronic Stability Control (esc)EngineSeats
PROBLEM WITH THE DRIVER'S SEAT HEATING MAT. PROBLEM WITH DETERMINING THE CAUSE OF ERRORS POSTED ON THE PHOTO
NHTSA ODI #11153582
122,000 miles · Jan 30, 2017
EngineSeatsFireInjury
AS I DROVE HOME FROM A LONG FLIGHT HOME AFTER THE HOLIDAYS, THE ENGINE CAUGHT FIRE DUE TO A FROZEN CRANK CASE VENTILATION SYSTEM WHICH CAUSED OIL TO SPRAY OUT IN THE ENGINE COMPARTMENT. I PULLED OVER WHEN I NOTICED SMOKE IN THE PASSENGER COMPARTMENT AND SMOKE COMING OUT OF THE HOOD. I WAS ABLE TO BLOW OUT THE FIRE. TEMPERATURES…
Read full complaint
AS I DROVE HOME FROM A LONG FLIGHT HOME AFTER THE HOLIDAYS, THE ENGINE CAUGHT FIRE DUE TO A FROZEN CRANK CASE VENTILATION SYSTEM WHICH CAUSED OIL TO SPRAY OUT IN THE ENGINE COMPARTMENT. I PULLED OVER WHEN I NOTICED SMOKE IN THE PASSENGER COMPARTMENT AND SMOKE COMING OUT OF THE HOOD. I WAS ABLE TO BLOW OUT THE FIRE. TEMPERATURES WERE 5 DEGREES F THAT NIGHT. THE DEALER STATED THERE WAS A "MORE ROBUST CRANK CASE VENTILATION SYSTEM" THAT THEY WOULD INSTALL AT MY COST. AFTER THE WEEK LONG REPAIR, THE DEALER BROUGHT MY CAR TO THE FRONT AND TURNED ON THE SEAT HEATERS. I DROVE ABOUT 5 MILES BEFORE NOTING A PINCHING/PAINFUL SENSATION ON MY LEFT UPPER THIGH. I PULLED OVER TO FIND A BURN MARK ON THE LEATHER SEAT AND A BURN ON MY LEFT UPPER THIGH. IT APPEARS TO BE DUE TO A SHORT IN THE SEAT HEATER.
NHTSA ODI #10948378
140,000 miles · Oct 9, 2016
EngineCrashInjury
ON 8/4/2016 AROUND 7:20AM. I PULLED INTO A PARKING SPACE AT WORK. MY FOOT WAS ON THE BRAKE AND WAS A COMPLETE STOP. SHIFTING FROM DRIVE TO PARK. THE CAR EXCELERATED THROWING ME BACK INTO MY SEAT. I KEPT PUSHING THE BRAKE AND THE CAR WOULD NOT STOP. THE CAR WENT AIRBORNE AND EXCELERATED A SECOND TIME. I HIT A FIRE HYDRANT AND LAN…
Read full complaint
ON 8/4/2016 AROUND 7:20AM. I PULLED INTO A PARKING SPACE AT WORK. MY FOOT WAS ON THE BRAKE AND WAS A COMPLETE STOP. SHIFTING FROM DRIVE TO PARK. THE CAR EXCELERATED THROWING ME BACK INTO MY SEAT. I KEPT PUSHING THE BRAKE AND THE CAR WOULD NOT STOP. THE CAR WENT AIRBORNE AND EXCELERATED A SECOND TIME. I HIT A FIRE HYDRANT AND LANDED IN THE STREET. I WAS THEN ABLE TO STOP THE CAR. THE DISTANCE FROM THE PARKING STOP TO THE ROAD WAS ABOUT 20 FEET. THE CAR WAS TOWED TO A BMW DEALER. BMW HAD MY CAR FOR 8 WEEKS. THEY HAD 2 DIFFERENT TECHS COME IN TO LOOK AT THE CAR. THE OUT COME WAS THAT THE BRAKES ARE FINE AND IT DID NOT HAVE ANY CODES. NOTHING IS WRONG WITH THE CAR. I TOLD THEM THAT I DIDN'T WANT THE CAR BACK. SINCE THEY DIDN'T SEE AN ISSUE I TOLD THEM I WOULD TRADE IT IN AND THEY COULD BE LIABLE FOR SOMEONE ELSE GETTING HURT. FUNNY HOW ALL OF THE SUDDEN THEY TOTALED OUT THE CAR. I ENDED UP GETTING A CONCUSSION AND WHIPLASH AND WILL BE DOCTORING FOR A WHILE. THE PERSON AT BMW THAT WAS TAKING CARE OF THIS IS MICHAEL AND HIS PHONE NUMBER IS 201-571-5820. WE WERE TOLD BY AMERICAN FAMILY INSURANCE PERSON THAT GOING AFTER BMW TO GET THE REPORTS FROM THE TECHS WOULD BE VERY DIFFICULT. WE REALLY WOULD LIKE TO KNOW WHAT THE REPORTS SAY. I FEEL LIKE WE WERE GIVEN THE RUN AROUND. I WANT BMW TO ACKNOWLEDGE THAT THEY HAVE ISSUES WITH SUDDEN EXCELERATION. I AM VERY ANGRY ON HOW I WAS TREATED. THEY GAVE US NO INFORMATION AND WE WERE WITHOUT A CAR FOR 7 WEEKS. THE LAST WEEK THEY FINALLY GAVE US A RENTAL. PLEASE LOOK INTO THIS FOR ME.
NHTSA ODI #10914959
92,000 miles · Aug 8, 2016
Engine
MY BMW X3 HAS HAD ITS ENGINE MOUNT BOLTS SHEARED OFF. THERE ARE NO INDICATIONS OF THE BOTTOM OF THE VEHICLE HAVING BEEN HIT BY ANY OBJECTS. THE VEHICLE'S MILEAGE IS IN THE LOW 90,000 MILE RANGE. AN INTERNET SEARCH REVEALS THAT THIS IS A COMMON PROBLEM HAPPENING TO MANY BMW X3'S, AT LOW MILEAGE. THEY ALSO CLAIM THAT THE BROK…
Read full complaint
MY BMW X3 HAS HAD ITS ENGINE MOUNT BOLTS SHEARED OFF. THERE ARE NO INDICATIONS OF THE BOTTOM OF THE VEHICLE HAVING BEEN HIT BY ANY OBJECTS. THE VEHICLE'S MILEAGE IS IN THE LOW 90,000 MILE RANGE. AN INTERNET SEARCH REVEALS THAT THIS IS A COMMON PROBLEM HAPPENING TO MANY BMW X3'S, AT LOW MILEAGE. THEY ALSO CLAIM THAT THE BROKEN MOTOR MOUNT BOLTS, COULD RESULT IN A SERIOUS ACCIDENT. THE BMW SERVICE MANAGER, I TALKED TO, INDICATED THAT HE HAS SEEN THIS SIMILAR ISSUES, BUT WAS NOT AWARE HOW WIDE SPREAD THE PROBLEM IS. HIS GUESS OF WHY THIS MAY BE HAPPENING IS DUE TO DIFFERENT THERMAL EXPANSION AND CONTRACTION OF THE 3 DIFFERENT METALS INVOLVED IN THE MOUNTING SYSTEM. THE WAY I DISCOVERED THE PROBLEM WAS THAT THE ENGINE OIL DRAIN PLUG WAS MISALIGNED WITH A PROTECTIVE SHROUD. I HAVE BEEN OCCASIONALLY NOTICING A THUMP COMING FROM THE ENGINE COMPARTMENT. I HAD MY BALL JOINTS AND FRONT-END CHECKED OUT ABOUT A YEAR AGO AND EVERYTHING CHECKED OUT FINE. I SUSPECT NOW, THAT THE THUMP SOUND IS DUE TO THE SHEARED ENGINE MOUNT BOLTS. IF THAT'S INDEED THE CASE, I WOULD HAVE BEEN DRIVING THE VECHILE WITH THE ENGINE MOUNT BOLTS SHEARED OFF FOR ABOUT 1-1/2 YEARS, UNAWARE OF THE ISSUE. THE ENGINE MOUNTS ARE NOT EASILY INSPECTABLE, WHICH IS PROBABLY WHY THE MECHANIC THAT CHECKED OUT MY FRONT END SUSPENSION DIDN'T CHECK THE ENGINE MOUNTS AT THAT TIME.
NHTSA ODI #10894166
97,000 miles · Feb 13, 2015
Engine
TL* THE CONTACT OWNS A 2006 BMW X3. WHILE DRIVING 40 MPH, THE VEHICLE STARTED TO OVERHEAT AND STALLED CAUSING THE ENGINE WARNING LIGHT TO ILLUMINATE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE THERMOSTAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. T…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW X3. WHILE DRIVING 40 MPH, THE VEHICLE STARTED TO OVERHEAT AND STALLED CAUSING THE ENGINE WARNING LIGHT TO ILLUMINATE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE THERMOSTAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 97,000.
BMW of North America, LLC (BMW) is recalling certain 2006-2010 BMW X3 2.5i, X3 3.0i and X3 xDrive30i Sports Activity Vehicles. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. Interim owner notification letters were mailed on November 27, 2017. A second notification letter will be sent when parts are available. Owners may contact BMW customer service at 1-800-525-7417.
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
2006 BMW X3 Problems, Complaints & Recalls | Skip That Year
Illustration