IllustrationI turned on my heated seat and within about a minute and a half I smelled a burning smell. Pulled over as I started to feel a burn on my leg because the seat heater has burnt through the leather in my car. This is a known problem at BMW and they have not issued a recall for this.
2006 BMW X3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 BMW X3 do not stand out strongly from the model-year median of 86.
About this comparison →How this year compares
Owner complaints by model year
Compare all X3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
1525–50K
3550–75K
2975–100K
22100–150K
6150K+
110 reports with mileage · 33 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports16 fire reports17 injury reports
Seats complaints
42 reportsDRIVER SEAT HEATER COIL BURNED UP WHILE I WAS SITTING IN THE GARAGE PREPARING TO LEAVE CAUSING HOLE IN THE SEAT AND MY PANTS.. I SEARCHED ON YOUTUBE AND IT SHOWED THAT THERE WERE SEVERAL INCIDENTS OF THIS HAPPENING. SHOULDN'T THERE BE A RECALL FOR THIS PROBLEM
WHILE DRIVING, WITH DRIVER'S HEATED SEAT SET ON HIGH (3 LIGHTS FOR HEATED SEAT CONTROL), DRIVER NOTED A BURNING SMELL. DRIVER TURNED OFF CABIN HEAT, HEATED SEAT AND PULLED OFF THE ROAD TO IDENTIFY THE SOURCE OF THE STRONG BURNING SMELL. HEATED SEAT HAD BURNED THROUGH THE LEATHER SEAT AND THE EXTERNAL LAYER OF THE DRIVER'S DOW…
Read full complaint
WHILE DRIVING, WITH DRIVER'S HEATED SEAT SET ON HIGH (3 LIGHTS FOR HEATED SEAT CONTROL), DRIVER NOTED A BURNING SMELL. DRIVER TURNED OFF CABIN HEAT, HEATED SEAT AND PULLED OFF THE ROAD TO IDENTIFY THE SOURCE OF THE STRONG BURNING SMELL. HEATED SEAT HAD BURNED THROUGH THE LEATHER SEAT AND THE EXTERNAL LAYER OF THE DRIVER'S DOWN FILLED WOOL COAT. VEHICLE WAS IN MOTION ON A RESIDENTIAL STREET, MANUAL TRANSMISSION IN 3RD GEAR, STRAIGHT ROAD. OCCURRED ON 12/16/19. INCLUDED 2 PICTURES OF THE BURNT LEATHER SEAT AND 1 PICTURE OF THE DRIVER'S BURNT COAT. SEAT AND COAT WERE BURNED, NO LIVE FLAME.
HEATED SEAT GETTING TOO HOT TOO FAST. BURNING SMELL.
WITHIN TWO MINUTES OF DRIVING, ON A CITY STREET, THE CAR WITH THE HEATED SEATS ON, I SMELLED A BURNING SMELL AND THOUGHT IT WAS COMING FROM ANOTHER CAR. BUT THE SMELL GOT STRONGER AND IT DIDN'T SMELL LIKE A CAR-RELATED SMELL. EVENTUALLY, THE SMELL GOT SO STRONG AND PUNGENT AND I SUDDENLY HAD A SHARP PAIN ON MY LEFT HIP AND I REA…
Read full complaint
WITHIN TWO MINUTES OF DRIVING, ON A CITY STREET, THE CAR WITH THE HEATED SEATS ON, I SMELLED A BURNING SMELL AND THOUGHT IT WAS COMING FROM ANOTHER CAR. BUT THE SMELL GOT STRONGER AND IT DIDN'T SMELL LIKE A CAR-RELATED SMELL. EVENTUALLY, THE SMELL GOT SO STRONG AND PUNGENT AND I SUDDENLY HAD A SHARP PAIN ON MY LEFT HIP AND I REALIZED IT THE HEATED SEAT WAS BURNING ME. THE PAIN WAS SO ACUTE I HAD TO LIFT MYSELF OFF OF THE SEAT, WHICH WAS DANGEROUS AND COULD'VE RESULTED IN AN ACCIDENT, AND I IMMEDIATELY PULLED OVER AND TURNED OFF THE HEATED SEATS. ONCE I TURNED THE HEATED SEAT OFF THE PAIN AND SMELL DISSIPATED. I GOT OUT OF THE CAR AND THERE WAS A CLEAR BURN HOLE BOTH ON THE SEAT AND ON MY PANTS. THE SMELL OF BURNT FABRIC LASTED IN THE CAR FOR SEVERAL DAYS AND FOR THE REST OF THE DAY I EXPERIENCED SHARP PAINS ON MY LEFT HIP AS IF IT WAS GETTING BURNED AGAIN.
WHILE USING DRIVER SIDE SEAT HEATER, ELEMENTS OVERHEATED BURNING THROUGH THE LEATHER SEAT AND BURNING THE LEFT SIDE/HIP OF THE DRIVER. CAR WAS IN MOTION AND ALMOST CAUSED AN ACCIDENT. PULLED OVER AND TURNED OFF THE HEATER IMMEDIATELY AND HAVEN'T USED IT SINCE.
HEATED SEATS GETS TOO HOT AND BURNT ME ON THE LEFT BUTT CHEEK. DEFINITELY A FIRE HAZARD AS I COULD ALSO SMELL SOMETHING BURNING IN THE CAR.
HEATED SEAT MALFUNCTIONS CAUSING "HOT SPOT" THAT BURNS SKIN ON REAR UPPER LEG.
PROBLEM WITH THE DRIVER'S SEAT HEATING MAT. PROBLEM WITH DETERMINING THE CAUSE OF ERRORS POSTED ON THE PHOTO
DRIVER'S SIDE SEAT HEATER WIRE BURNED THROUGH THE SEAT, MELTED A SPOT ON MY VINYL RAINCOAT AND SUBSEQUENTLY BURNED MY BUTTOCK. VEHICLE WAS IN MOTION ON A CITY STREET AT THE TIME.
Official recalls
217V605000 · Air Bags:sensor:occupant Classification
Sep 28, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2010 BMW X3 2.5i, X3 3.0i and X3 xDrive30i Sports Activity Vehicles. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. Interim owner notification letters were mailed on November 27, 2017. A second notification letter will be sent when parts are available. Owners may contact BMW customer service at 1-800-525-7417.
08V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).