IllustrationFAULTY CLOCK SPRING BMW AIRBAG LIGHT ON HORN DOESN'T WORK BMW STEERING WHEEL BUTTONS DON'T WORK, PADDLE SHIFTER NOT WORKING, FAULT CODE: DRIVER SQUIB CIRCUIT OPEN OR HIGH RESISTANCE, CODE B1049 AND B1054.
2006 BMW X3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 BMW X3 do not stand out strongly from the model-year median of 86.
About this comparison →How this year compares
Owner complaints by model year
Compare all X3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
1525–50K
3550–75K
2975–100K
22100–150K
6150K+
110 reports with mileage · 33 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports16 fire reports17 injury reports
Unknown Or Other complaints
4 reportsELECTRICAL AND HAS BEEN AFFECTED SINCE THE CAR WAS LESS THAN 5 YEARS OLD, RADIO WOULD SUDDENLY GET LOUD IF VOLUME WAS ADJUSTED. AFTER THE ELECTRICAL ISSUES STARTED ABOUT 2 YEARS LATER MY A/C STARTED HAVING ISSUES THOUGHT IT MAY BE A LEAK BUT NOW AFTER SEEING THE RECALL ON ELECTRICAL ISSUES ON SOME MODELS THIS SUV X3 SHOULD HAVE …
Read full complaint
ELECTRICAL AND HAS BEEN AFFECTED SINCE THE CAR WAS LESS THAN 5 YEARS OLD, RADIO WOULD SUDDENLY GET LOUD IF VOLUME WAS ADJUSTED. AFTER THE ELECTRICAL ISSUES STARTED ABOUT 2 YEARS LATER MY A/C STARTED HAVING ISSUES THOUGHT IT MAY BE A LEAK BUT NOW AFTER SEEING THE RECALL ON ELECTRICAL ISSUES ON SOME MODELS THIS SUV X3 SHOULD HAVE BEEN ON THE LIST BUT IT'S NOT, AND SHOULD HAVE REPORTED THIS A LONG TIME AGO THAT THIS IS A LEMON. THE BACK WINDOW ALSO SLIDES DOWN ANOTHER ELECTRICAL ISSUE. CAR WAS DRIVEN FOR PLEASURE EVERY FEW DAYS BUT HAS MORE ISSUES THAN OLDER CARS.
"TAKATA RECALL" I STARTED MY CAR TO WARM UP IN THE MORNING PRIOR TO GOING TO WORK FOR A FEW MINUTES AND THEN MY CAR JUST SHUT OFF-IT WAS BELOW ZERO DURING THE NIGHT SO I CALLED FOR A TOW AND TOOK TO SHOP AND PER OWNER OF SHOP HE HAD TO CALL BMW AS SHOP WAS NOT A BMW SHOP AS HE COULD NOT FIND OUT WHY CAR SHUT OFF-BMW STATED TO…
Read full complaint
"TAKATA RECALL" I STARTED MY CAR TO WARM UP IN THE MORNING PRIOR TO GOING TO WORK FOR A FEW MINUTES AND THEN MY CAR JUST SHUT OFF-IT WAS BELOW ZERO DURING THE NIGHT SO I CALLED FOR A TOW AND TOOK TO SHOP AND PER OWNER OF SHOP HE HAD TO CALL BMW AS SHOP WAS NOT A BMW SHOP AS HE COULD NOT FIND OUT WHY CAR SHUT OFF-BMW STATED TO HIM THAT HE HAS TO ORDER A COLD WEATHER KIT THAT BMW MAKES SO THIS WONT HAPPEN AGIAN OR ELSE ENGINE CAN BLOW UP-PER BMW ALSO THEY HAVE BEEN AWARE OF THIS ISSUE WITH MY MODEL THEREFORE THAT IS WHY THERE IS A KIT. MY GUESTIION TO YOU IS I WOULD THINK THIS WOULD HAVE BEEN A RECALL ISSUE AND I DO NOT SEE ON BMW RECALL WEBISTE WHERE THIS HAS EVE BEEN RE-CALLED SO PER SHOP IS $250.00 FOR KIT FROM BMW AND $500.00 LABOR AS MUCH LABOR INVOLED SO I WANTED TO CHECK WITH YOU HOW I AM RESPONISBLE FOR THIS AND WHY IS NOT BMW NOT-THANK YOU
REPEATED FLOODING IN DRIVER-SIDE BACK AND PASSENGER FRONT. IT HAS BEEN THE VAPOR SEAL ALONG THE DOOR, TOP PART OF DOOR NEAR WINDOW, SEAL ALONG THE WINDSHIELD AND FINALLY FROM THE SUNROOF LEADING TO DRAIN LEADING TO INTERIOR OF CAR. I HAVE BEEN FORTUNATE THAT NO ELECTRICAL ISSUES HAVE INCURRED, BUT DUE TO THE HIGH RISK OF THAT H…
Read full complaint
REPEATED FLOODING IN DRIVER-SIDE BACK AND PASSENGER FRONT. IT HAS BEEN THE VAPOR SEAL ALONG THE DOOR, TOP PART OF DOOR NEAR WINDOW, SEAL ALONG THE WINDSHIELD AND FINALLY FROM THE SUNROOF LEADING TO DRAIN LEADING TO INTERIOR OF CAR. I HAVE BEEN FORTUNATE THAT NO ELECTRICAL ISSUES HAVE INCURRED, BUT DUE TO THE HIGH RISK OF THAT HAPPENING, WANTED TO REPORT THE SITUATION. THIS HAS BEEN ONGOING FOR OVER A YEAR (FIXED VARIOUS ISSUES WITH FLOODING EVERY FEW MONTHS). BMW ACKNOWLEDGES THAT THE X3 HAS WATER ISSUES BUT THAT IT IS NO FAULT OF THEIR'S. I UNDERSTAND A VAPOR SEAL NEEDING TO BE REPLACED ONCE IN A WHILE- BUT THIS IS FAR AND BEYOND HAPPENING WAY TOO FREQUENTLY. JUST DON'T WANT ANY OF THE LARGER POSSIBILITIES TO COME INTO PLAY.
Official recalls
217V605000 · Air Bags:sensor:occupant Classification
Sep 28, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2010 BMW X3 2.5i, X3 3.0i and X3 xDrive30i Sports Activity Vehicles. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. Interim owner notification letters were mailed on November 27, 2017. A second notification letter will be sent when parts are available. Owners may contact BMW customer service at 1-800-525-7417.
08V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).