IllustrationI WAS DRIVING AND NOTICED A BURNING SMELL. I HAD MY SEAT HEATER ON AND NOTICED A VERY, VERY HOT SPOT ON THE BOTTOM PART OF THE SEAT ON THE LEFT SIDE. I HURRIED AND SHUT THE SEAT HEATER OFF, BUT NOTICED BURN MARKS ON THE LEATHER. THE SEAT WOULD HAVE DEFINITELY CAUGHT ON FIRE IF I HADN'T SHUT OFF THE SEAT HEATER. *TR
2006 BMW X3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 BMW X3 do not stand out strongly from the model-year median of 86.
About this comparison →How this year compares
Owner complaints by model year
Compare all X3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
1525–50K
3550–75K
2975–100K
22100–150K
6150K+
110 reports with mileage · 33 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports16 fire reports17 injury reports
Seats complaints
42 reportsTL* THE CONTACT OWNS A 2006 BMW X3. WHILE DRIVING APPROXIMATELY 10 MPH WITH THE FRONT DRIVER SIDE HEATED SEAT ACTIVATED, SMOKE APPEARED FROM THE SEAT. AS A RESULT, A HOLE WAS BURNED THROUGH THE FRONT DRIVER SEAT AND THE CONTACT'S COAT. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW X3. WHILE DRIVING APPROXIMATELY 10 MPH WITH THE FRONT DRIVER SIDE HEATED SEAT ACTIVATED, SMOKE APPEARED FROM THE SEAT. AS A RESULT, A HOLE WAS BURNED THROUGH THE FRONT DRIVER SEAT AND THE CONTACT'S COAT. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 95,000.
I WAS DRIVING WHEN I SMELLED SMOKE AND REALIZED THAT THE DRIVER'S SIDE SEAT HAD CAUGHT FIRE. I STOPPED THE CAR, JUMPED OUT, AND SAW THAT A HOLE HAD BURNED THROUGH THE CAR SEAT AND I COULD SEE FLAMES. I DON'T UNDERSTAND HOW THIS HAS NOT TRIGGERED A RECALL AS IT IS OBVIOUSLY EXTREMELY DANGEROUS TO HAVE YOUR CAR CATCH ON FIRE WHI…
Read full complaint
I WAS DRIVING WHEN I SMELLED SMOKE AND REALIZED THAT THE DRIVER'S SIDE SEAT HAD CAUGHT FIRE. I STOPPED THE CAR, JUMPED OUT, AND SAW THAT A HOLE HAD BURNED THROUGH THE CAR SEAT AND I COULD SEE FLAMES. I DON'T UNDERSTAND HOW THIS HAS NOT TRIGGERED A RECALL AS IT IS OBVIOUSLY EXTREMELY DANGEROUS TO HAVE YOUR CAR CATCH ON FIRE WHILE DRIVING. *TR
DRIVER SIDE HEATED SEAT CAUGHT ON FIRE. *TR
SEAT HEATING SYSTEM ISSUE: WITHOUT ANY EARLIER WARNING SIGNS THE DRIVER SEAT OVERHEATED VERY QUICKLY (WITHIN ONE MINUTE OF TURNING ON THE SEAT HEATERS) TO THE POINT OF BURNING THE DRIVERS SKIN. A BURNING SMELL OCCURRED AT THE SAME TIME. THE DRIVER HAD TO GET UP FROM THE SEAT RAPIDLY TO AVOID ANY SERIOUS BURNS. THIS MADE BRINGING…
Read full complaint
SEAT HEATING SYSTEM ISSUE: WITHOUT ANY EARLIER WARNING SIGNS THE DRIVER SEAT OVERHEATED VERY QUICKLY (WITHIN ONE MINUTE OF TURNING ON THE SEAT HEATERS) TO THE POINT OF BURNING THE DRIVERS SKIN. A BURNING SMELL OCCURRED AT THE SAME TIME. THE DRIVER HAD TO GET UP FROM THE SEAT RAPIDLY TO AVOID ANY SERIOUS BURNS. THIS MADE BRINGING THE VEHICLE TO A CONTROLLED STOP VERY DIFFICULT. THE DRIVER WAS HALFWAY UP FROM THE SEAT WITH THE SEATBELT HOLDING THE DRIVER BACK. THIS COULD HAVE LEAD EASILY TO AN ACCIDENT AS IT IS VERY DIFFICULT TO CONTROL A VEHICLE IN THAT POSITION. FORTUNATELY, THE VEHICLE WAS STILL AT A SLOW SPEED AND OPERATED IN A RESIDENTIAL AREA. HOWEVER, THE RISK OF AN ACCIDENT OR INJURIES AT A HIGHER SPEED AND/OR MORE POPULATED AREA WOULD HAVE BEEN MUCH GREATER. I BELIEVE THIS IS A SERIOUS SAFETY RELATED DEFECT UNDER THE UNITED STATES CODE FOR MOTOR VEHICLE SAFETY (TITLE 49, CHAPTER 301). INTERNET RESEARCH AND MULTIPLE COMPLAINS ON THE NHTSA WEBSITE CONFIRM THAT THIS IS NOT AN ISOLATED INCIDENT. *TR
I HAD A PROBLEM WITH THE DRIVER'S SIDE SEAT WARMER IN MY 2006 BMW X3 STARTING ON ABOUT OCTOBER 21, 2013. WHILE I WAS DRIVING ON A COUPLE DIFFERENT OCCASIONS, I FELT A "SHOCK" IN MY LEFT THIGH. I DIDN'T THINK ANYTHING ABOUT IT UNTIL THE SEAT WARMER STOPPED WORKING ALL TOGETHER. I BROUGHT IT TO THE DEALER TO FIX AND FOUND THAT THE…
Read full complaint
I HAD A PROBLEM WITH THE DRIVER'S SIDE SEAT WARMER IN MY 2006 BMW X3 STARTING ON ABOUT OCTOBER 21, 2013. WHILE I WAS DRIVING ON A COUPLE DIFFERENT OCCASIONS, I FELT A "SHOCK" IN MY LEFT THIGH. I DIDN'T THINK ANYTHING ABOUT IT UNTIL THE SEAT WARMER STOPPED WORKING ALL TOGETHER. I BROUGHT IT TO THE DEALER TO FIX AND FOUND THAT THE ENTIRE HEATING ELEMENT WOULD HAVE TO BE REPLACED, AT A COST OF OVER $1500. AS I AM LOOKING INTO THE PROBLEM, I FOUND THAT THIS HAS HAPPENED TO NUMEROUS OTHERS. I AM FORTUNATE THAT THERE WAS NOT A MORE SERIOUS INJURY, AND THAT MY SEAT WAS NOT DAMAGED TO THE EXTENT THAT OTHERS HAVE ENCOUNTERED. HOWEVER, THIS IS AN UNACCEPTABLE PROBLEM AND BMW SHOULD BE TAKING CARE OF IT. *TR
WHEN TESTING THE HEATED SEATS IN THIS VEHICLE, AFTER 5-10 SECS, I FELT A STRONG HEAT SENSATION ON MY LEFT THIGH. THE THERE WAS A BURN HOLE IN THE DRIVER'S SEAT ON THE LEFT SIDE. SWITCHED OFF HEAT WARMER RIGHT AWAY. *TR
I FELT A BURNING SENSATION UNDER MY LEFT LEG AND PULLED THE CAR OVER. NOTICED THAT THE SEAT HAD CRACKED AND THERE WAS A DISCOLORATION INDICATING A BURN. I SWITCHED OFF THE HEATED SEAT AND CONTINUED. I HAVE FELT THIS BURNING SENSATION A FEW OTHER TIMES AND WOULD TURN DOWN THE HEAT OR SWITCH IT OFF ALTOGETHER. THE DEALER SUGGESTED…
Read full complaint
I FELT A BURNING SENSATION UNDER MY LEFT LEG AND PULLED THE CAR OVER. NOTICED THAT THE SEAT HAD CRACKED AND THERE WAS A DISCOLORATION INDICATING A BURN. I SWITCHED OFF THE HEATED SEAT AND CONTINUED. I HAVE FELT THIS BURNING SENSATION A FEW OTHER TIMES AND WOULD TURN DOWN THE HEAT OR SWITCH IT OFF ALTOGETHER. THE DEALER SUGGESTED A CHANGE OF THE SEAT COVER WHICH COSTS UPWARDS OF 1000 $S *TR
TURNING INTO A DRIVEWAY WITH A BOULDER ON THE EDGE/CORNER. WITH THE DRIVERS SIDE SEAT HEATER ON, THE SEAT BURNED A HOLE THRU THE LEATHER AND MADE ME TURN ABRUPTLY AND BUMPED THE BOULDER. DAMAGE TO THE FR. BUMPER, INNER FENDER AND WHEEL. LEFT SIDE (DRIVERS) SEAT BOLSTER HAS A BURN-THROUGH HOLE. *TR
STARTED THE CAR IN MY DRIVEWAY THIS MORNING AND LET THE ENGINE IDLE FOR A MINUTE OR TWO BEFORE DRIVING OFF, I ENERGIZED THE DRIVERS SIDE HEATED SEAT TO THE LOWEST SETTING, AFTER 10 SEC OR SO I STARTED TO SMELL A BURNING ODOR AND FELT A SHARP PAIN UNDER MY LEFT THIGH. I TURNED OFF THE HEATED SEAT IMMEDIATELY, SHUT THE CAR OFF, AN…
Read full complaint
STARTED THE CAR IN MY DRIVEWAY THIS MORNING AND LET THE ENGINE IDLE FOR A MINUTE OR TWO BEFORE DRIVING OFF, I ENERGIZED THE DRIVERS SIDE HEATED SEAT TO THE LOWEST SETTING, AFTER 10 SEC OR SO I STARTED TO SMELL A BURNING ODOR AND FELT A SHARP PAIN UNDER MY LEFT THIGH. I TURNED OFF THE HEATED SEAT IMMEDIATELY, SHUT THE CAR OFF, AND GOT OUT OFF THE CAR TO SEE WHAT THE PROBLEM WAS. I NOTICED A SMALL BLACK BURN MARK ON THE SEAT THAT WAS VERY WARM TO THE TOUCH. I CALLED BMW NORTH AMERICA TO FILE A COMPLAINT, THE LADY ON THE PHONE TOOK MY INFORMATION AND STATEMENT AS TO WHAT HAD HAPPENED AND SUGGESTED THAT I TAKE THE VEHICLE TO AN AUTHORIZED BMW DEALER FOR INSPECTION. I HAD THE VEHICLE INSPECTED LATER THIS AFTERNOON BY CONCORD BMW AND WAS TOLD BY THE SERVICE MANAGER THAT SINCE THE CAR WAS OUT OF WARRANTY THAT THE DEALER WOULD NOT COVER ANY REPAIR COST OF THE DAMAGED SEAT. I ASKED IF THEY WOULD CONTACT BMW NORTH AMERICA ON MY BEHALF AND ASK THEM TO AUTHORIZE AND PAY FOR THE REPAIR DUE TO THE SEVERITY OF THE EVENT, HEATED SEATS ARE NOT SUPPOSE TO CATCH FIRE AND MYSELF OR SOMEONE ELSE DRIVING THE VEHICLE COULD HAVE BEEN BURNED. I WAS TOLD NO, THAT I WOULD HAVE TO TAKE IT UP WITH BMW NORTH AMERICA ON MY OWN. *TR
Official recalls
217V605000 · Air Bags:sensor:occupant Classification
Sep 28, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2010 BMW X3 2.5i, X3 3.0i and X3 xDrive30i Sports Activity Vehicles. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners, and dealers will replace the front passenger seat occupant detection mat, free of charge. Interim owner notification letters were mailed on November 27, 2017. A second notification letter will be sent when parts are available. Owners may contact BMW customer service at 1-800-525-7417.
08V384000 · Air Bags:frontal
Aug 5, 2008
BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Consequence & remedy
Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
PE07045 · BMW Airbag Light Illumination
Opened Sep 4, 2007 · Closed Jan 4, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Additional source detail variants (3)
Air Bags
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).
Air Bags:frontal:sensor/control MODULE-INACTIVE
IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE PASSENGER AIRBAG STATUS LAMP.ILLUMINATION OF THESE LIGHTS WARN THAT AN OPEN ELECTRICAL CIRCUIT MAY BE PRESENT WITHIN THE PASSENGER SEAT MAT SENSOR.WHEN BOTH OF THE LIGHTS ARE ILLUMINATED, THE PASSENGER FRONTAL AIR BAG WILL NOT DEPLOY IN A FRONTAL CRASH.CERTAIN BMW VEHICLES IN ADDITION TO THE SUBJECT VEHICLES CONTAIN THE SAME SEAT MAT SENSOR.THESE ARE THE MY 2004 5-SERIES, 7-SERIES AND X3, THE MY 2004 THROUGH 2006Z-4 SERIES AND MY 2006 3-SERIES, 6-SERIES AND X5 VEHICLES.AN IMPROVED SEAT MAT SENSOR WAS INTRODUCED IN DECEMBER 2005 FOR THE MID-MY 2006 PRODUCTION.IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER, BMW PROVIDED 1,172 OWNER REPORTS AND 28,238 WARRANTY CLAIMS.INITIAL REVIEW OF THE DATA INDICATE THAT 280 NON-DUPLICATING OWNER REPORTS AND 13,051 NON-DUPLICATING WARRANTY CLAIMS MAY BE RELATED THE SUBJECT DEFECT ISSUE ON THE SUBJECT VEHICLESTHIS PRELIMINARY EVALUATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA08-001).