Steering. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports1 fire reports3 injury reports

Engine complaints

1 reports

Clear category filter

Mileage unknown · Jan 23, 2023

Electrical SystemEngine

Read full complaint

While driving on the freeway, the vehicle's electric motor suddenly died. Because this is an electric vehicle, the car came to a sudden and abrupt stop, with all the wheels locking up. The car would not shift into drive or neutral or reverse. It effectively died, with the only power coming from the 12-volt battery to power the dashboard and interior lights. It was effectively inoperable. The vehicle displayed the following error message: "DRIVETRAIN: only electric drive possible, limited driving range, continued driving possible, consult nearest service center." We brought the car to our local BMW service center, and they ran a diagnostic (attached as PDF file). The issue is a faulty EME, which could be as much as an $11K repair. Several model years prior to 2017 i3 have been recalled by BMW for this exact issue. We cannot afford an $11K repair, so hoping BMW will recall 2017 and beyond, as this is a major safety hazard. Thankfully we were stuck in gridlock traffic and were not moving very fast (under 5 miles per hour) when the car stopped. But at a high rate of speed, this could have cause a catastrophic accident. We have two small children and will not be driving with them in this car until the issue is resolved.

NHTSA ODI #11503225

Official recalls

17V720000 · Air Bags:frontal

Nov 16, 2017

BMW of North America, LLC (BMW) is recalling certain 2014-2018 BMW i3 electric and hybrid electric vehicles. Unbelted, small adult, drivers may be at a higher risk of neck injury in the event of a frontal crash. These vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: During a frontal impact, unbelted, small adult, drivers could be at a higher risk of neck injury.

Remedy: BMW will notify owners, and dealers will update the Driver air bag control unit software, free of charge. The recall is expected to begin January 8, 2018. Owners may contact BMW customer service at the dedicated i3 recall number 1-855-269-3361.

17V088000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Feb 9, 2017

BMW of North America, LLC (BMW) is recalling certain 2014-2017 i3 REx hybrid electric vehicles. The fuel tank vent line may rub against the ribbed wire protection sleeve of the battery positive (B+) cable, creating a hole in the vent line and causing a fuel vapor leak.

Consequence & remedy

Consequence: A fuel vapor leak in the presence of an ignition source can increase the risk of a fire.

Remedy: BMW will notify owners, and dealers will inspect the fuel vent line, replacing it as necessary, and install a clip to prevent it from chafing, free of charge. The recall beganApril 3, 2017. Owners may contact BMW customer service at 1-800-525-7417.

16V914000 · Air Bags

Dec 20, 2016

BMW of North America, LLC (BMW) is recalling certain model year 2017 BMW 640i, 640i xDrive, 650i, 650i xDrive, M6, 535i, 535i xDrive, 430i, 430i xDrive, 440i, 440i xDrive, M4, X1 sDrive28i, X1 xDrive28i, i3, i8, Rolls-Royce Dawn, Mini Clubman Cooper, Clubman Cooper S, Cooper All4, Cooper S All4, Mini 4-Door Cooper, Cooper S, Mini 2-Door Cooper, Cooper S, John Cooper Works and 2016 BMW 528i, 528i xDrive, 535i, 535i xDrive, 550i, 550i xDrive, M5 and 535d vehicles. The affected vehicles have seat- mounted side air bag inflator initiators that may fail to ignite during a crash.

Consequence & remedy

Consequence: If the air bag inflator initiator fails to ignite, the seat-mounted air bag will not deploy, increasing the risk of injury.

Remedy: BMW will notify owners, and dealers will replace the air bag modules, free of charge. The recall began February 6, 2017. Owners may contact BMW customer service at 1-800-525-7417.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.