THERE SEEMS TO BE A COMMON DEFECT IN THE '1995-'01 BMW 740 SERIES GAS TANK. THERE IS A PROBLEM THAT OCCURS THAT CREATES A VACCUM IN THE TANK WHICH THEN MAKES THE TANK IMPLODE. IT JUST CRUSH IN UPON ITSELF UNTIL IT POPS OR A SEAM BREAKS SOMEWHERE. THIS HAPPENED TO ME YESTERDAY WHILE I WAS DRIVING TO WORK AND HAD 17 GALLONS OF G…
Read full complaint
THERE SEEMS TO BE A COMMON DEFECT IN THE '1995-'01 BMW 740 SERIES GAS TANK. THERE IS A PROBLEM THAT OCCURS THAT CREATES A VACCUM IN THE TANK WHICH THEN MAKES THE TANK IMPLODE. IT JUST CRUSH IN UPON ITSELF UNTIL IT POPS OR A SEAM BREAKS SOMEWHERE. THIS HAPPENED TO ME YESTERDAY WHILE I WAS DRIVING TO WORK AND HAD 17 GALLONS OF GAS SPEWING FROM UNDERNEATH THE CAR. I DIDN'T NOTICE IT UNTIL I WAS IN MY PARKING GARAGE WHICH IS IN A 49 STORY BUILDING. THE JERSEY CITY FIRE DEPARTMENT CAME THEN BROUGHT IN THEIR HAZMAT TEAM. THEY RECOVERED/CLEANED UP MAYBE 7 GALLONS WHILE IN THE GARAGE SO ABOUT 10 GALLONS SPILLED WHILE I WAS DRIVING. NEEDLESS TO SAY THIS WAS AN EXTREMELY DANGEROUS SITUATION THAT COULD HAVE BEEN PREVENTED IF BMW HAD RECALLED THE CAR ON THIS ITEM. IT HAS HAPPENED TO AT LEAST 6 OTHER PEOPLE ON THIS MESSAGE BOARD THAT I'M A PART OF: HTTP://BIMMER.ROADFLY.ORG/BMW/FORUMS/E38/ I'M JUST GLAD THAT NO ONE GOT HURT AND THAT MY 3 AND 1 YEAR OLD DAUGHTERS WERE NOT IN THE CAR. BUT IF SOMETHING IS NOT DONE SOON SOMEONE IS GOING TO DIE AS A RESULT OF THIS DEFECT.*AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.
Consequence & remedy
Consequence: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 BMW 740I Problems, Complaints & Recalls | Skip That Year
Illustration