Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

What owners actually said

3 reports

55,000 miles · Mar 5, 2004

Engine And Engine Cooling

CONSUMER COMPLAINED ABOUT A COOLING SYSTEM PROBLEM. THE HOSE THAT WAS CONNECTED TO THE RADIATOR MELTED FROM THE HEAT THAT CAME FROM THE ENGINE.*AK

NHTSA ODI #10061544

79,375 miles · Oct 28, 2003

Fuel System, Gasoline

Read full complaint

THERE SEEMS TO BE A COMMON DEFECT IN THE '1995-'01 BMW 740 SERIES GAS TANK. THERE IS A PROBLEM THAT OCCURS THAT CREATES A VACCUM IN THE TANK WHICH THEN MAKES THE TANK IMPLODE. IT JUST CRUSH IN UPON ITSELF UNTIL IT POPS OR A SEAM BREAKS SOMEWHERE. THIS HAPPENED TO ME YESTERDAY WHILE I WAS DRIVING TO WORK AND HAD 17 GALLONS OF GAS SPEWING FROM UNDERNEATH THE CAR. I DIDN'T NOTICE IT UNTIL I WAS IN MY PARKING GARAGE WHICH IS IN A 49 STORY BUILDING. THE JERSEY CITY FIRE DEPARTMENT CAME THEN BROUGHT IN THEIR HAZMAT TEAM. THEY RECOVERED/CLEANED UP MAYBE 7 GALLONS WHILE IN THE GARAGE SO ABOUT 10 GALLONS SPILLED WHILE I WAS DRIVING. NEEDLESS TO SAY THIS WAS AN EXTREMELY DANGEROUS SITUATION THAT COULD HAVE BEEN PREVENTED IF BMW HAD RECALLED THE CAR ON THIS ITEM. IT HAS HAPPENED TO AT LEAST 6 OTHER PEOPLE ON THIS MESSAGE BOARD THAT I'M A PART OF: HTTP://BIMMER.ROADFLY.ORG/BMW/FORUMS/E38/ I'M JUST GLAD THAT NO ONE GOT HURT AND THAT MY 3 AND 1 YEAR OLD DAUGHTERS WERE NOT IN THE CAR. BUT IF SOMETHING IS NOT DONE SOON SOMEONE IS GOING TO DIE AS A RESULT OF THIS DEFECT.*AK

NHTSA ODI #10043746

Mileage unknown · May 30, 2003

Engine And Engine Cooling

UPPER NIPPLE WITH HOSE CONNECTOR ON RADIATOR IS MADE OF PLASTIC AND BREAKS OFF WITH FRAGMENTS LEFT IN THE HOSE. THIS REALLY SHOULD NOT BE MADE OF PLASTIC AS INTENSELY HOT WATER PASSES THROUGH IT ALL THE TIME. THIS AMOUNTS TO AN EXPENSIVE REPAIR.*AK

NHTSA ODI #10020749

Official recalls

97V140000 · Suspension:front:springs:coil Springs

Aug 22, 1997

VEHICLE DESCRIPTION: PASSENGER VEHICLES. ROAD GRIT AND GRAVEL ASSOCIATED WITH WINTER ROAD CONDITIONS CAN PENETRATE THE RUBBER OF THE LOWER FRONT SPRING MOUNTS AND ACCUMULATE IN THE MOUNTS CAUSING NOTCHES OR PITS TO DEVELOP. THESE NOTCHES CAN DEVELOP CRACKS RESULTING IN BREAKAGE OF A BOTTOM COIL OF THE SPRING.

Consequence & remedy

Consequence: THE VEHICLE'S RIDE HEIGHT COULD BE AFFECTED CAUSING NOISE WHILE THE VEHICLE IS DRIVEN. THE VEHICLE'S DYNAMIC STABILITY CAN BE AFFECTED REDUCING THE DRIVER'S ABILITY TO MAINTAIN CONTROL OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE BOTH FRONT SPRINGS AND LOWER SPRING MOUNTS.

97V131000 · Vehicle Speed Control

Aug 19, 1997

THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.

Consequence & remedy

Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.