IllustrationFUEL SMELL IN THE DRIVER SIDE REAR. THE FUEL PUMP LEAKS FUEL.
2009 BMW 528I
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2009 BMW 528I do not stand out strongly from the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all 528I years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 22 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports1 fire reports0 injury reports
Fuel/propulsion System complaints
4 reportsTHE CAR SMELLS AS FUEL IS LEAKING AND THE HEADLIGHTS BLINK IN AND OUT... MY TRUNK STOP OPENING WITH KEY FOB
I WAS DRIVING THE VEHICLE ON THE HIGHWAY ABOUT 70 MILES PER HOUR - WHEN WITHOUT ANY WARNING THE VEHICLE "CHECK ENGINE LIGHT" AND "HAZARD LIGHTS CAME ON - THE FUEL GAUGE SHOWED OVER 100 MORE GALLOONS IN THE TANK THAN IT HAD PREVIOUSLY - TRIED TO ACCELERATE BUT THE CAR DID NOT RESPOND. THE ENGINE REDUCED POWER AND WAS STALLING AS …
Read full complaint
I WAS DRIVING THE VEHICLE ON THE HIGHWAY ABOUT 70 MILES PER HOUR - WHEN WITHOUT ANY WARNING THE VEHICLE "CHECK ENGINE LIGHT" AND "HAZARD LIGHTS CAME ON - THE FUEL GAUGE SHOWED OVER 100 MORE GALLOONS IN THE TANK THAN IT HAD PREVIOUSLY - TRIED TO ACCELERATE BUT THE CAR DID NOT RESPOND. THE ENGINE REDUCED POWER AND WAS STALLING AS I IMMEDIATELY STARTED TO CROSS THE HIGHWAY FROM THE FURTHEST LEFT LANE IN ORDER TO GET TO SAFETY ON THE RIGHT SIDE OF THE ROAD - I WAS WITH MY PARENTS AND MY HANDICAPPED NEPHEW AND SCARED FOR ALL OF OUR LIVES. THE ENGINE "SPUTTERED AND VIBRATED" BEFORE STOPPING. I DIDN'T NOTICE ANYTHING WRONG OR ANY CHANGE IN THE WAY THE CAR DROVE. THIS WAS A VERY DANGEROUS AND UNSAFE INCIDENT.
THIS CAR DOES HAVE SYSTEMS ISSUES INVOLVING FUEL PRESSURE UNDER HWY SPEEDS AND DURING HARD ACCELERATION. THERE IS A ORANGE WARNING LIGHT THAT COMES ON INTERMITTENTLY WHY THE CAR IS TRYING TO PULL VACUUME AND GET UP TO PROPER SPEEDS. THERE HAVE BEEN SEVERAL RECALLS BUT NOT ALL MODELS ARE INVOLVED. I WOULD SUGGEST REPLACING THE O …
Read full complaint
THIS CAR DOES HAVE SYSTEMS ISSUES INVOLVING FUEL PRESSURE UNDER HWY SPEEDS AND DURING HARD ACCELERATION. THERE IS A ORANGE WARNING LIGHT THAT COMES ON INTERMITTENTLY WHY THE CAR IS TRYING TO PULL VACUUME AND GET UP TO PROPER SPEEDS. THERE HAVE BEEN SEVERAL RECALLS BUT NOT ALL MODELS ARE INVOLVED. I WOULD SUGGEST REPLACING THE O RINGS AND OR INJECTORS AS PREVENTABLE MEASURE AND FOR BETTER FUEL ECONOMY. IF THE DEALER CAN'T HELP YOU THEN REACH OUT TO THE AREA REP IN YOUR SALES CITY.
Official recalls
217V683000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
13V407000 · Exterior Lighting:tail Lights
Sep 11, 2013
BMW is recalling certain model year 2008 through 2010 528i, 535i, 550i, and M5 passenger cars manufactured from March 1, 2007, through December 31, 2009. Over time, increased resistance at the taillight electrical contact points may cause damage to the ground terminal and housing of the connector resulting in an intermittent or permanent loss of functionality of one or more rear lamp functions (tail, brake, turn-signal, reverse).
Consequence & remedy
Consequence: Intermittent light operation reduces the ability to warn other motorists of the driver's intentions, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the rear lamp bulb carriers free of charge. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.