IllustrationMY SEAT WAS SMOKING AND SOON TO CATCH FIRE IF I HADN'T CAUGHT THIS. WHAT SHOULD I DO TO RESOLVE THIS ISSUE?
2008 BMW 528I
Owner reports · Recalls · Investigations
More warning signs than most 528I years
Owner complaints for the 2008 BMW 528I are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all 528I years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
525–50K
2350–75K
2075–100K
27100–150K
9150K+
86 reports with mileage · 32 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports16 fire reports2 injury reports
Seats complaints
5 reportsAIR BAG SENSOR FOR FRONT PASSENGER SEAT NOT WORKING. REPLACED ONCE WHILE VEHICLE UNDER WARRANTY. SAME SENSOR MALFUNCTION AGAIN. BMW WILL NOT REPLACE UNLESS I PAY, COST OF REPLACING SENSOR OVER 4,000.00. I BELIEVE IT SHOULD BE COVERED BY BMW SINCE SAME PART IS AGAIN NOT WORKING.
I WAS DRIVING MY CAR AND SUDDENLY THE RESTRAINT SYSTEM MALFUNCTION LIGHT TURNED ON AND THE SEATBELT LIGHT TURNED ON. I DID NOT HIT A BUMP OR ANYTHING. THERE WAS NO PASSENGER CURRENTLY SITTING ON THE PASSENGER SEAT WHEN THE LIGHT CAME ON. I HAVE TRIED SITTING DOWN ON THE PASSENGER SEAT AND PUT ON MY SEAT BELT TO SEE IF IT WILL GO…
Read full complaint
I WAS DRIVING MY CAR AND SUDDENLY THE RESTRAINT SYSTEM MALFUNCTION LIGHT TURNED ON AND THE SEATBELT LIGHT TURNED ON. I DID NOT HIT A BUMP OR ANYTHING. THERE WAS NO PASSENGER CURRENTLY SITTING ON THE PASSENGER SEAT WHEN THE LIGHT CAME ON. I HAVE TRIED SITTING DOWN ON THE PASSENGER SEAT AND PUT ON MY SEAT BELT TO SEE IF IT WILL GO AWAY BUT NO LUCK. ALSO, THE SEAT BELT LIGHT WILL NOT GO AWAY EVEN IF I BUCKLE THE DRIVERS SEAT AND PASSENGER SEAT BELT. *TR
TL* THE CONTACT OWNS A 2008 BMW 528I. WHILE ATTEMPTING TO UTILIZE THE SEAT HEATING SYSTEM, THE CONTACT SMELLED AN ABNORMAL BURNING ODOR. UPON FURTHER INSPECTION, IT WAS NOTED THAT THE BACKREST OF THE DRIVER SIDE SEAT HAD A SMALL BURN HOLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMB…
Read full complaint
TL* THE CONTACT OWNS A 2008 BMW 528I. WHILE ATTEMPTING TO UTILIZE THE SEAT HEATING SYSTEM, THE CONTACT SMELLED AN ABNORMAL BURNING ODOR. UPON FURTHER INSPECTION, IT WAS NOTED THAT THE BACKREST OF THE DRIVER SIDE SEAT HAD A SMALL BURN HOLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V575000 (SEATS). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000. ....UPDATED 01/13/16 *BF; UPDATED 05/10/18*JB *CN
UPON TURNING THE SEAT HEATER ON I NOTICED A BURNING SMELL AND SMOKE INSIDE THE CAR. THE SEAT WAS UNUSUALLY HOT. I FELT A BURNING SENSATION AND PULLED OVER TO FIND THAT THE SEAT HEATING ELEMENT HAD BURNED THROUGH THE LEATHER AND TWO LAYERS OF A HEAVY DUTY WINTER COAT. WHEN I TURNED IT OFF THE SMOKE STOPPED. WE TOOK THE CAR TO TH…
Read full complaint
UPON TURNING THE SEAT HEATER ON I NOTICED A BURNING SMELL AND SMOKE INSIDE THE CAR. THE SEAT WAS UNUSUALLY HOT. I FELT A BURNING SENSATION AND PULLED OVER TO FIND THAT THE SEAT HEATING ELEMENT HAD BURNED THROUGH THE LEATHER AND TWO LAYERS OF A HEAVY DUTY WINTER COAT. WHEN I TURNED IT OFF THE SMOKE STOPPED. WE TOOK THE CAR TO THE BMW DEALERSHIP AND WAS TOLD IT IS NOT PART OF A SAFETY RECALL OR UNDER WARRANTY. REFUSED ANY MONETARY CONSIDERATION AND WANTED $1400 TO REPAIR. CONSIDERING THE CAR COULD CATCH ON FIRE THE REPAIR SHOULD BE CONSIDERED A SAFETY ISSUE AND REPAIRED FOR FREE. *TR
Official recalls
217V683000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
13V407000 · Exterior Lighting:tail Lights
Sep 11, 2013
BMW is recalling certain model year 2008 through 2010 528i, 535i, 550i, and M5 passenger cars manufactured from March 1, 2007, through December 31, 2009. Over time, increased resistance at the taillight electrical contact points may cause damage to the ground terminal and housing of the connector resulting in an intermittent or permanent loss of functionality of one or more rear lamp functions (tail, brake, turn-signal, reverse).
Consequence & remedy
Consequence: Intermittent light operation reduces the ability to warn other motorists of the driver's intentions, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the rear lamp bulb carriers free of charge. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.