IllustrationThe daylight lamps fall apart causing poor lighting at night and continuous alarms while driving. Also, impacting the quality of light and lack of lighting at night. The alarms are continuous and block ALL other alerts from the vehicle, including cruise control, temperature, overheating, engine, and other notices.
2008 BMW 528I
Owner reports · Recalls · Investigations
More warning signs than most 528I years
Owner complaints for the 2008 BMW 528I are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all 528I years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
525–50K
2350–75K
2075–100K
27100–150K
9150K+
86 reports with mileage · 32 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports16 fire reports2 injury reports
Exterior Lighting complaints
33 reportsAfter purchasing this vehicle from my aunt and uncle my one headlight when bad after purchasing the headlights I replaced both the right and left one while removing the old headlights the insulation from the wires just crumbles off casuing a short bc the wires are zip tied several times together and causes my lights to flicker o…
Read full complaint
After purchasing this vehicle from my aunt and uncle my one headlight when bad after purchasing the headlights I replaced both the right and left one while removing the old headlights the insulation from the wires just crumbles off casuing a short bc the wires are zip tied several times together and causes my lights to flicker or not work at all while the the car keeps notifying me that there is an issue never couple seconds
My front left and right headlight assembly went out. Went to take a look to realize all the wiring inside the assembly was exposed and sparking. Come to find out this was a common issue in this year make and model. They are charging $2,500 per assembly for a factory issue that could start a fire. Needs taken care of ASAP
DRIVER SIDE HEADLIGHT WENT OUT, SO I AUTOMATICALLY ASSUMED THAT THE BULL WAS BLOWN. WENT AND BOUGHT $100 BULL THAT CONTROLS THE HIGH BEAM AND THE LOW BEAMS, REPLACE THE BULB, AND THE HEADLIGHT STILL DOESN'T WORK. TOOK THE BALL BACK AND GOT ANOTHER BULB, AND THE HEADLIGHT STILL DOESN'T WORK. AS I WAS REPLACING THE BULB I NOTICED …
Read full complaint
DRIVER SIDE HEADLIGHT WENT OUT, SO I AUTOMATICALLY ASSUMED THAT THE BULL WAS BLOWN. WENT AND BOUGHT $100 BULL THAT CONTROLS THE HIGH BEAM AND THE LOW BEAMS, REPLACE THE BULB, AND THE HEADLIGHT STILL DOESN'T WORK. TOOK THE BALL BACK AND GOT ANOTHER BULB, AND THE HEADLIGHT STILL DOESN'T WORK. AS I WAS REPLACING THE BULB I NOTICED BARE WIRES SHOWING, ON MULTIPLE WIRES, AS FAR AS I COULD SEE. THIS IS DEFINITELY A SAFETY ISSUE , AS IT COULD CAUSE MY CAR TO CATCH FIRE.
ALL OF THE INTERNAL HEADLIGHT WIRING INSULATION ON BOTH HEADLIGHTS IS CRUMBLING OFF WHICH IS EXPOSING THE COPPER WIRE, CAUSING SPARKS AND SHORTING OUT. I HAVE PERFORMED MUCH ONLINE RESEARCH AND APPARENTLY THIS IS A KNOWN PROBLEM BY BMW. CURRENTLY IT'S A HUGE SAFETY ISSUE BECAUSE IT'S UNPREDICTABLE WHEN HEADLIGHTS WILL SHORT OUT …
Read full complaint
ALL OF THE INTERNAL HEADLIGHT WIRING INSULATION ON BOTH HEADLIGHTS IS CRUMBLING OFF WHICH IS EXPOSING THE COPPER WIRE, CAUSING SPARKS AND SHORTING OUT. I HAVE PERFORMED MUCH ONLINE RESEARCH AND APPARENTLY THIS IS A KNOWN PROBLEM BY BMW. CURRENTLY IT'S A HUGE SAFETY ISSUE BECAUSE IT'S UNPREDICTABLE WHEN HEADLIGHTS WILL SHORT OUT WHILE DRIVING, LOSING SIGHT OF THE ROAD AND POSSIBLY INCREASING RISK OF ACCIDENT.
WHEN I ATTEMPTED TO INSTALL NEW LOW BEAM, HIGH BEAM, AND ANGEL EYE BULBS I DISCOVERED THAT ALL THE PROTECTIVE COATING ON THE WIRES INSIDE THE HEADLIGHT ASSEMBLY WAS MISSING OR CRUMBLING OFF. THESE EXPOSED WIRES ARE A CERTAIN FIRE HAZARD. ANY ATTEMPT TO REPAIR THE WIRE COATING RESULTED IN MORE COATING CRUMBLING OFF, EXPOSING YE…
Read full complaint
WHEN I ATTEMPTED TO INSTALL NEW LOW BEAM, HIGH BEAM, AND ANGEL EYE BULBS I DISCOVERED THAT ALL THE PROTECTIVE COATING ON THE WIRES INSIDE THE HEADLIGHT ASSEMBLY WAS MISSING OR CRUMBLING OFF. THESE EXPOSED WIRES ARE A CERTAIN FIRE HAZARD. ANY ATTEMPT TO REPAIR THE WIRE COATING RESULTED IN MORE COATING CRUMBLING OFF, EXPOSING YET MORE OF THE WIRE.
TL* THE CONTACT OWNS A 2008 BMW 528I. THE CONTACT STATED THAT THE DRIVER SIDE BRAKE LIGHT AND TURN SIGNAL FAILED TO ILLUMINATE WHEN ENGAGED. A WARNING INDICATOR FOR THE REAR DRIVER SIDE EXTERIOR LIGHTING ILLUMINATED. IN ADDITION, THE TURN SIGNAL INDICATOR FLICKERED RAPIDLY ON THE INSTRUMENT PANEL, BUT FAILED TO ILLUMINATE ON THE…
Read full complaint
TL* THE CONTACT OWNS A 2008 BMW 528I. THE CONTACT STATED THAT THE DRIVER SIDE BRAKE LIGHT AND TURN SIGNAL FAILED TO ILLUMINATE WHEN ENGAGED. A WARNING INDICATOR FOR THE REAR DRIVER SIDE EXTERIOR LIGHTING ILLUMINATED. IN ADDITION, THE TURN SIGNAL INDICATOR FLICKERED RAPIDLY ON THE INSTRUMENT PANEL, BUT FAILED TO ILLUMINATE ON THE EXTERIOR OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIR. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V407000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 170,000.
HEADLIGHT WIRING INSIDE HEADLIGHT ASSEMBLY IS DETERIORATING BADLY. THE PROTECTIVE COATING IS CRACKING AND FLAKING OFF LEAVING THE EXPOSED COPPER CORE WHICH IN TURN SHORTS OUT THE LIGHTS. POSSIBLE FIRE HAZARD AS WELL.
REPLACED HEADLIGHT BULB, PASSENGER SIDE, FOR THE SECOND TIME, WITHIN THE PAST YEAR, AND ABOUT THE FIFTH TIME (DRIVER SIDE AND PASSENGER SIDE; HEADLIGHT BULB AND ANGEL EYE BULB) SINCE WE HAVE OWNED THE VEHICLE (PURCHASED CERTIFIED PRE-OWNED FROM A BMW DEALERSHIP, HOUSTON, TX). AND THE CAUSE OF THE PROBLEM IS INFERIOR WIRING INSU…
Read full complaint
REPLACED HEADLIGHT BULB, PASSENGER SIDE, FOR THE SECOND TIME, WITHIN THE PAST YEAR, AND ABOUT THE FIFTH TIME (DRIVER SIDE AND PASSENGER SIDE; HEADLIGHT BULB AND ANGEL EYE BULB) SINCE WE HAVE OWNED THE VEHICLE (PURCHASED CERTIFIED PRE-OWNED FROM A BMW DEALERSHIP, HOUSTON, TX). AND THE CAUSE OF THE PROBLEM IS INFERIOR WIRING INSULATION. THE WIRING INSULATION IS DETERIORATING CAUSING THE BULBS TO PREMATURELY BURN OUT AND A POSSIBLE FIRE HAZARD. THE REPLACEMENT BULBS ARE PURCHASED FROM A LOCAL BMW STORE. THEY ARE NOT NON-OEM BULBS AND THEY ARE NOT CHEAP. BMW NEEDS TO REPLACE THE ENTIRE HEADLIGHT UNIT.
HEADLIGHTS.... ANGEL EYES BOTH SIDES BURNED OFF PROBLEM WITH ELECTRIC SOCKETS I WOULD THINK!!! THIS IS HAPPENING TOO A LOT OF BMW AS RESERCH! *BF *TR
Official recalls
217V683000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
13V407000 · Exterior Lighting:tail Lights
Sep 11, 2013
BMW is recalling certain model year 2008 through 2010 528i, 535i, 550i, and M5 passenger cars manufactured from March 1, 2007, through December 31, 2009. Over time, increased resistance at the taillight electrical contact points may cause damage to the ground terminal and housing of the connector resulting in an intermittent or permanent loss of functionality of one or more rear lamp functions (tail, brake, turn-signal, reverse).
Consequence & remedy
Consequence: Intermittent light operation reduces the ability to warn other motorists of the driver's intentions, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the rear lamp bulb carriers free of charge. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.