TL* THE CONTACT OWNS A 1992 BMW 525I. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, ANOTHER VEHICLE CRASHED INTO THE VEHICLE. THE CONTACT STATED THAT THE AIR BAG DEPLOYED CAUSING SEVERE BURNS. THE CONTACT REQUIRED MEDICAL ATTENTION FOR THE THIRD DEGREE BURNS TO HER FACE AND NECK. A POLICE REPORT WAS FILED. THE MANUF…
Read full complaint
TL* THE CONTACT OWNS A 1992 BMW 525I. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, ANOTHER VEHICLE CRASHED INTO THE VEHICLE. THE CONTACT STATED THAT THE AIR BAG DEPLOYED CAUSING SEVERE BURNS. THE CONTACT REQUIRED MEDICAL ATTENTION FOR THE THIRD DEGREE BURNS TO HER FACE AND NECK. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE WAS 99,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10653182
90,000 miles · Feb 14, 2006
Air Bags
THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY BROKE WITHOUT WARNING. IT WAS NOTICEABLE, A CLICK OR GRAB TYPE FEEL, WHEREVER THE STEERING WHEEL WAS TURNED AND I IMMEDIATELY TOOK THE CAR TO MY BMW SHOP TO CORRECT. I AM NOT SURE WHAT WAS ACCOMPLISHED BUT THE CLICK WAS REMOVED. ON RECALLS FOR BMWS TH…
Read full complaint
THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY BROKE WITHOUT WARNING. IT WAS NOTICEABLE, A CLICK OR GRAB TYPE FEEL, WHEREVER THE STEERING WHEEL WAS TURNED AND I IMMEDIATELY TOOK THE CAR TO MY BMW SHOP TO CORRECT. I AM NOT SURE WHAT WAS ACCOMPLISHED BUT THE CLICK WAS REMOVED. ON RECALLS FOR BMWS THIS FAULT WAS LIMITED TO THE 3 SERIES AND NOT A 5 SERIES WHICH I OWN. I HAD REPORTED THIS EARLIER BUT DIDN'T RECEIVE ANY RESPONSE FROM THE NTSB SO THEREFORE I AM RESUBMITTING. *NM
NHTSA ODI #10150229
96,000 miles · Jun 30, 2005
Air BagsCrashInjury
DT: VEHICLE WAS INVOLVED IN AN FRONTAL IMPACT THE AIR BAGS DEPLOYED, HOWEVER THE CONSUMER SUSTAINED 3RD DEGREE BURNS TO THE CHIN AREA, AND HAD TO HAVE ROOT CANAL WORK ON A TOOTH. THE VEHICLE WAS TOTALED. NO REPAIRS WERE MADE. THERE WAS A SMALL DEPLOYMENT AND IT WAS LIKE IT WAS FIRE, RED FLAMING AREA ON THE AIR BAG THAT ACTU…
Read full complaint
DT: VEHICLE WAS INVOLVED IN AN FRONTAL IMPACT THE AIR BAGS DEPLOYED, HOWEVER THE CONSUMER SUSTAINED 3RD DEGREE BURNS TO THE CHIN AREA, AND HAD TO HAVE ROOT CANAL WORK ON A TOOTH. THE VEHICLE WAS TOTALED. NO REPAIRS WERE MADE. THERE WAS A SMALL DEPLOYMENT AND IT WAS LIKE IT WAS FIRE, RED FLAMING AREA ON THE AIR BAG THAT ACTUALLY IGNITED. *AK
NHTSA ODI #10127190
Mileage unknown · Apr 27, 2005
Air Bags
I AM WONDERING HOW THE MANUFACTURE DETERMINES WHICH VEHICLES ARE AFFECTED BY A PARTICULIAR RECALL. A COUPLE OF EXAMPLES, I HAVE A 1992 BMW 525I AND HAVE EXPERIENCED TWO FAILURES RELATED TO RECALLS ONE CONCERNED THE RING IN THE STEERING COLUMN RELATED TO THE AIRBAG BROKE AND HAD TO BE REPLACED AND THE OTHER HAD TO DO WITH THE CO…
Read full complaint
I AM WONDERING HOW THE MANUFACTURE DETERMINES WHICH VEHICLES ARE AFFECTED BY A PARTICULIAR RECALL. A COUPLE OF EXAMPLES, I HAVE A 1992 BMW 525I AND HAVE EXPERIENCED TWO FAILURES RELATED TO RECALLS ONE CONCERNED THE RING IN THE STEERING COLUMN RELATED TO THE AIRBAG BROKE AND HAD TO BE REPLACED AND THE OTHER HAD TO DO WITH THE COOLING SYSTEM WHERE THE TERMOSTAT STUCK AND THE PRESSURE CRACKED THE RADIATOR. THESE FAILURE OCCURRED A FEW YEARS BACK AND I WOULD NED TO CHECK MY MAINTENANCE RECORDS TO GET THE EXACT DATES.
NHTSA ODI #10118557
103,000 miles · Apr 22, 2004
Air BagsCrashInjury
WHILE DRIVING CONSUMER'S VEHICLE WAS HIT ON THE DRIVER SIDE FRONT QUARTER PANEL. THE AIR BAGS DEPLOYED. DRIVER WAS BURNED IN THE FACE AND CHEST. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.
Remedy: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1992 BMW 525I Problems, Complaints & Recalls | Skip That Year
Illustration