(1) MY 1990 BMW 525I STARTED TO OVER HEAT ON AUGUST 01,2006. THE TEMP GAUGE GOES UP 50% MARK. THE COOLANT LEVEL WENT DOWN EVERY DAY AND I FILLED IT UP WITH DISTILLED WATER TO CONTROL THE TEMPERATURE, HOPING THAT IT WOULD CORRECT ITSELF SOME TIME. (2) I COULD NOT DRIVE THE CAR ON REGULAR BASIS ANYMORE. WITHIN FEW DAYS, I SAW COO…
Read full complaint
(1) MY 1990 BMW 525I STARTED TO OVER HEAT ON AUGUST 01,2006. THE TEMP GAUGE GOES UP 50% MARK. THE COOLANT LEVEL WENT DOWN EVERY DAY AND I FILLED IT UP WITH DISTILLED WATER TO CONTROL THE TEMPERATURE, HOPING THAT IT WOULD CORRECT ITSELF SOME TIME. (2) I COULD NOT DRIVE THE CAR ON REGULAR BASIS ANYMORE. WITHIN FEW DAYS, I SAW COOLANT OVERFLOWING AND SPRAY-OUT. FOLLOWING THIS, I NOTICED SLIGHT ROUGH IDLE AND VIBRATION. (3) REALIZING THAT DRIVING THE CAR WAS NO MORE SAFE, I CALLED WESTCHESTER BMW, WHITE PLAINS, NY. ON EMERGENCY BASIS, THE DEALER ACCEPTED THE CAR THE FOLLOWING WEEK FOR DIAGNOSIS. ON AUGUST 14 2006, THE DEALER CONCLUDED IT IS COOLANT LEAKING IN THE ENGINE AND OUTSIDE THE ENGINE. NO PARTS WERE REPAIRED AND REPLACED BECAUSE THE ENGINE WORK SPECIFIED BY THE DEALER WAS EXPENSIVE. I TOOK THE CAR BACK HOME. CAN NOT DRIVE IT ANYMORE. *JB
NHTSA ODI #10165963
Mileage unknown · May 1, 2002
Engine And Engine Cooling
WHILE DRIVING, COOLANT LEVEL WARNING LIGHT ILLUMINATED AND CONSUMER NOTICED WHITE SMOKE COMING FROM THE REAR OF THE VEHICLE, CONSUMER FOUND THAT WATER WAS IN THE OIL DUE TO A CRACKED HEAD, CONSUMER LATER RECEIVED RECALL 98V178. *SLC
NHTSA ODI #565570
Mileage unknown · Jun 8, 1999
Engine And Engine Cooling
RADIATOR CAP FAILED, CAUSING COMPLETE FAILURE TO RADIATOR. HOWEVER RADIATOR IS NOT COVERED UNDER RECALL NOTICE (98V-178). *YC
NHTSA ODI #546010
Mileage unknown · Sep 1, 1998
Electrical SystemEngine And Engine CoolingEquipment
INSIDE DOOR PANEL SEPARATED FROM THE DOOR.
NHTSA ODI #539511
Mileage unknown · Jul 23, 1997
Engine And Engine CoolingExterior LightingFuel System, Gasoline
REAR DOOR WILL NOT OPEN FROM INSIDE.
NHTSA ODI #515007
Mileage unknown · Mar 11, 1997
Electrical SystemEngine And Engine CoolingExterior Lighting
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1990 BMW 525I Problems, Complaints & Recalls | Skip That Year
Illustration