TL*THE CONTACT OWNS A 1993 BMW 325I. THE CONTACT STATED THAT THE AIR CONDITIONING SYSTEM STOPPED WORKING AND THE TEMPERATURE WOULD NOT MAINTAIN ACCURATE TEMPERATURES. LATER, THE HEATING UNIT FAILED AS WELL. THE VEHICLE WAS TAKEN TO THE DEALER, BUT REPAIRS WERE NOT MADE BECAUSE THE FAILURES WERE OUTSIDE OF THE WARRANTY AND THE…
Read full complaint
TL*THE CONTACT OWNS A 1993 BMW 325I. THE CONTACT STATED THAT THE AIR CONDITIONING SYSTEM STOPPED WORKING AND THE TEMPERATURE WOULD NOT MAINTAIN ACCURATE TEMPERATURES. LATER, THE HEATING UNIT FAILED AS WELL. THE VEHICLE WAS TAKEN TO THE DEALER, BUT REPAIRS WERE NOT MADE BECAUSE THE FAILURES WERE OUTSIDE OF THE WARRANTY AND THERE WERE NO RECALLS. THE CONTACT LOCATED A RECALL, BUT WAS UNSURE IF HER VIN WAS INCLUDED BECAUSE SHE NEVER RECEIVED A NOTIFICATION. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.
NHTSA ODI #10255912
Mileage unknown · Nov 28, 2000
Equipment
JACK LUG WRENCH THAT COMES EQUIPPED WITH VEHICLE WILL BEND AND BREAK, CAUSING VEHICLE TO COLLAPSE. CONSUMER ONLY HAD USED JACK ONES.*AK
NHTSA ODI #875623
Mileage unknown · Apr 26, 2000
EquipmentFuel System, GasolineSteering
STEERING LOCKS UP INTERMITTENLY IN THE START POSITION, WINDOWS AND SUNROOF INOPERATIVE, GAS INTERMITTENLY GIVES INCORRECT READING OF FUEL
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1993 BMW 325I Problems, Complaints & Recalls | Skip That Year
Illustration