IllustrationTHE BRACE HOLDING ONE OF THE FUEL TANK STRAPS BROKE OFF. IT SEEMS IF BROKE OFF AT THE WELDS. THE STRAP WAS JUST HANGING AND ONLY THE OTHER WAS HOLDING THE FUEL TANK IN PLACE. *TR
1994 BMW 325I
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all 325I years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 17 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
17 reportsTL* THE CONTACT OWNS A 1994 BMW 325I. THE CONTACT STATED THAT THE ODOMETER READING WAS INCORRECT. THE MILEAGE INDICATED THAT THE VEHICLE HAD 28,000 MILES WHEN THE TITLE INDICATED THAT THE MILEAGE WAS 128,000. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR A DIAGNOSTIC TEST. THE DEALER ADVISED THE CONTACT THAT ANOTHER MECHANIC HAD …
Read full complaint
TL* THE CONTACT OWNS A 1994 BMW 325I. THE CONTACT STATED THAT THE ODOMETER READING WAS INCORRECT. THE MILEAGE INDICATED THAT THE VEHICLE HAD 28,000 MILES WHEN THE TITLE INDICATED THAT THE MILEAGE WAS 128,000. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR A DIAGNOSTIC TEST. THE DEALER ADVISED THE CONTACT THAT ANOTHER MECHANIC HAD ALTERED THE ODOMETER. THE CONTACT ALSO NOTICED THAT THE ANTI-FREEZE WAS LEAKING, THE FRONT WINDOWS FOGGED AND THE SEAT BELTS WERE DEFECTIVE. THE VEHICLE WAS AT THE DEALERSHIP AWAITING REPAIR AT THE TIME OF THE COMPLAINT. THE APPROXIMATE MILEAGE WAS APPROXIMATELY 28,000. THE CURRENT MILEAGE WAS UNKNOWN.
CONSUMER'S WIFE WAS LOCKED IN THEIR 1994 BMW 325I AND THE DOORS WOULD NOT OPEN. *NJ THE CONSUMER STATED THE WINDOWS AND HORN DID NOT WORK EITHER. *JB
FUEL GAUGE INTERMITTENT FAILURE. BMW'S FROM 70'S TO '07 HAVE BEEN NOTED BY OWNERS AS BEING A PERSISTENT PROBLEM. MOST DUE TO FAILURE OF THE SENDING UNITS. MANY OWNERS END UP HAVING THE SENDERS REPLACED MULTIPLE TIMES D/T MULTIPLE FAILURES OF THE SENDING UNITS. MY E36 HAS 2 SENDING UNITS AND I HAVE BEEN STUCK ON THE SIDE OF THE R…
Read full complaint
FUEL GAUGE INTERMITTENT FAILURE. BMW'S FROM 70'S TO '07 HAVE BEEN NOTED BY OWNERS AS BEING A PERSISTENT PROBLEM. MOST DUE TO FAILURE OF THE SENDING UNITS. MANY OWNERS END UP HAVING THE SENDERS REPLACED MULTIPLE TIMES D/T MULTIPLE FAILURES OF THE SENDING UNITS. MY E36 HAS 2 SENDING UNITS AND I HAVE BEEN STUCK ON THE SIDE OF THE ROAD MULTIPLE TIMES. AND THE SAME FOR MANY OTHER OWNERS ON BMW ONLINE BOARDS/FORUMS. I'VE BEEN STUCK IN TRAFFIC WHERE I MERELY MISSED AN ACCIDENT BY MANEUVERING W/O ENGINE POWER. PLEASE LOOK INTO THIS. BMW HAS CONTINUED TO HAVE THESE PROBLEMS AND SHOULD RECALL THE FAILED UNITS THAT JUST KEEP FAILING. *TR
DEFECTIVE TRANSMISSION JUMPED OUT OF 1ST GEAR WITH ENGINE LOAD. *BF THE CONSUMER REQUESTED ASSISTANCE TO REMEDY THE PROBLEM THE CONSUMER DISCOVERED A TECHNICAL SERVICE BULLETIN HAD BEEN ISSUED FOR MANUAL TRANSMISSIONS. *SC *JB
WHEN DRIVING THE VEHICLE AT AN UNDETERMINED SPEED, THE BRAKE LIGHT ILLUMINATED ON THE DASHBOARD. THE CONSUMER INFORMED THE DEALER ABOUT THIS ISSUE, HOWEVER THE MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. *NM THE REAR BRAKE LIGHT BULBS BURNED OUT. *SC *JB
CHILD SEAT WOULD NOT LATCH ONTO LEFT SIDE OF BASE. *MR PH
CONSUMER IS UNABLE TO OPEN LEFT REAR DOOR FROM BOTH INSIDE AND OUTSIDE. DEALER AND MANUFACTURER WERE NOTIFIED.*AK CONSUMER STATED THE BRAKE LIGHT SWITCH WAS REPLACED.*JB
VEHICLE WILL STALL IN RAIN. DEALER DETERMINED THAT COMPUTER MODULE GOT WET AND VEHICLE WILL EITHER STALL OR NOT START. COMPUTER MODULE HAS BEEN REPLACED 3 TIMES. *AK
FUEL LINE LEAKS REALLY BAD CAN CAUSE FIRE HAZARD IN THE ENGINE IS HOT BUT THE BMW DEALER JUST SAID THAT THE RUBBER HOSE CAN FAIL AT ANY TIME.*AK
Official recalls
398V178000 · Engine And Engine Cooling:cooling System
Aug 4, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
97V131000 · Vehicle Speed Control
Aug 19, 1997
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
96V111000 · Exterior Lighting:brake Lights:switch
Jul 1, 1996
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.