TL*THE CONTACT OWNS A 1992 BMW 325I. WHENEVER THE CONTACT LOCKS THE DOORS FROM THE OUTSIDE OF THE VEHICLE, HE IS UNABLE TO UNLOCK THEM FROM INSIDE THE PASSENGER COMPARTMENT. ONCE HE LOCKS THE DOORS, THE DOOR HANDLES AND LOCKS FAIL INSIDE THE PASSENGER COMPARTMENT. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT…
Read full complaint
TL*THE CONTACT OWNS A 1992 BMW 325I. WHENEVER THE CONTACT LOCKS THE DOORS FROM THE OUTSIDE OF THE VEHICLE, HE IS UNABLE TO UNLOCK THEM FROM INSIDE THE PASSENGER COMPARTMENT. ONCE HE LOCKS THE DOORS, THE DOOR HANDLES AND LOCKS FAIL INSIDE THE PASSENGER COMPARTMENT. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 200,000.
NHTSA ODI #10238739
68,000 miles · Aug 17, 2008
Latches/locks/linkagesInjury
I LOCKED MY 1992 BMW 325I WITH THE KEY FROM THE OUTSIDE WITH MY FRIEND INSIDE (I DID NOT REALIZE HE HAD NOT GOTTEN OUT OF THE VEHICLE YET). I HAD DROPPED THE KEY WHEN I HEARD HIM POUND ON THE WINDOW (LOOSING THE KEY IN SOME BRUSH). WHEN THIS SITUATION HAD TRANSPIRED I FOUND OUT THAT HE COULD NOT OPEN ANY OF THE DOORS FROM INSIDE…
Read full complaint
I LOCKED MY 1992 BMW 325I WITH THE KEY FROM THE OUTSIDE WITH MY FRIEND INSIDE (I DID NOT REALIZE HE HAD NOT GOTTEN OUT OF THE VEHICLE YET). I HAD DROPPED THE KEY WHEN I HEARD HIM POUND ON THE WINDOW (LOOSING THE KEY IN SOME BRUSH). WHEN THIS SITUATION HAD TRANSPIRED I FOUND OUT THAT HE COULD NOT OPEN ANY OF THE DOORS FROM INSIDE OF THE VEHICLE IN ANY MANNER. IF THIS WERE A SMALL CHILD AND LETS SAY A FORGETFUL GRANDPARENT THE CHILD WOULD NOT BE ABLE TO GET OUT OF THE CAR IN ANY MANNER. (OR WITH THE WEIRD MOTHER DROWNING KIDS AND UNCLES LOCKING KIDS IN HIS BASEMENT THAT WE HEAR ABOUT ON THE NEWS) THIS CAR COULD BE USED AS A POTENTIAL PRISON. IF THIS WERE ANY PERSON(S) WHO ARE NOT VERY MUSCULAR THE CAR COULD POTENTIALLY BE A DEATH TRAP IF SOMEONE HAD NOT KNOWN THEY WERE INSIDE OF THE CAR. IN ADDITION, KNOWING THEY ARE INSIDE THE CAR AND CALLING A LOCKSMITH, THE LOCKSMITH IS NOT ABLE TO GET INSIDE OF THE CAR WITHOUT DOING SUPER EXCESSIVE DAMAGE TO THE LOCKS OR BREAKING A WINDOW. IN WHICH CASE BREAKING A WINDOW IN SUCH A SMALL SEDAN COULD AND IN MY CASE RESULTED FROM MY FRIEND ENDING UP WITH CHUCKS OF GLASS IN HIS SKIN AND I BROKE MY HAND GETTING THROUGH THE WINDOW BECAUSE WE WERE IN THE DESERT WITH NOTHING AROUND TO BE ABLE TO BREAK THE WINDOW. IF IT IS REQUIRED TO HAVE A TRUNK RELEASE INSIDE OF A TRUNK TO LET OCCUPANTS OUT. WHY CAN YOU BE LOCKED INSIDE OF YOUR OWN CAR? *TR
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.
Remedy: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.
THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1992 BMW 325I Problems, Complaints & Recalls | Skip That Year
Illustration