Air Bags. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports1 fire reports5 injury reports

Seat Belts complaints

12 reports

Clear category filter

Mileage unknown · Jan 11, 2012

Air BagsSeat Belts

Read full complaint

THE AIRBAG WARNING LIGHTS AND SEATBELT WARNING LIGHTS ARE LIT IN RED. AFTER DIAGNOSIS FROM THE DEALER'S SERVICE DEPARTMENT, IT WAS CONCLUDED THAT THE SENSOR EMBEDDED IN THE PASSENGER SIDE IS MALFUNCTIONING AND MUST BE REPLACED. THERE WAS A RECALL IN 2008 FOR THE SAME MODEL YEAR WITH A SIMILAR MALFUNCTION OF THE AIRBAG SENSOR (NHTSA CAMPAIGN ID NUMBER: 08V384000) ALSO, IN THAT RECALL IT STATES: " BMW IS EXTENDING THE WARRANTY TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT TO THE FOLLOWING VEHICLES: MY 2006 6-SERIES, 3-SERIES (STANDARD SEAT), MY 2004-2005 Z4, MY 2004-2006 7-SERIES, MY 2006 X5, AND MY 2004-2006 5-SERIES (COMFORT SEAT). UNDER THE EXTENDED WARRANTY PROGRAM, THE OCCUPANT DETECTION MAT IN A VEHICLE THAT EXPERIENCES THIS SPECIFIC ISSUE WILL BE REPLACED AT NO CHARGE TO THE CUSTOMER" HOWEVER, THE LOCAL BMW DEALER SAYS THEY CANNOT HONOR THAT WARRANTY. *TR

NHTSA ODI #10443512

95,000 miles · Dec 14, 2010

Air BagsSeat Belts

Read full complaint

THIS COMPLAINT IS IN REGARDS TO NHTSA ID #08V384000. THE AIR BAG WARNING LAMP, SEAT BELT LAMP AND THE PASSENGER AIR BAG "ON-OFF" LAMP WILL NOT TURN OFF . I CONTACTED BMW VIA THE PHONE NUMBER PROVIDED BY YOUR DEPARTMENT AND ALSO VISITED MY LOCAL BMW DEALER AND THEY BOTH SAY THAT MY CAR DOESN'T FALL UNDER SAID RECALL. MY CAR IS A BMW 2006 330I WITH SPORTS SEATS, WHICH IS ONE OF THE CARS LISTED AS BEING DEFECTIVE BY YOUR DEPARTMENT. HOWEVER, BMW STATED THAT THE RECALL IS FOR A SPECIFIC NUMBER OF AIRBAG SENSOR MATTS THAT WERE DAMAGED DURING SHIPPING AND THAT MY CAR'S MATT WAS NOT PART OF THIS BATCH. SINCE MY CAR IS EXPERIENCING THE SAME SYMPTOMS AS THOSE UNDER THE RECALL, AND IS ACTUALLY ONE OF THE CARS LISTED IN YOUR REPORT, IT'S SAFE TO SAY THAT THE FAULTY AIRBAG SENSOR ISSUE GOES BEYOND JUST THE BATCH BMW IS CLAIMING WERE DAMAGED. EVEN IF THIS IS TRUE, AND THAT SPECIFIC BATCH OF AIR BAG SENSORS WERE DAMAGED DURING SHIPPING, THEN WHAT'S TO SAY THAT MY AIR BAG SENSOR WASN'T ALSO DAMAGED DURING SHIPPING EVEN IF IT WAS PART OF ANOTHER BATCH. THE LOGICAL CONCLUSION, HOWEVER, WOULD INDICATE THAT THE SENSORS BEING DAMAGED DURING SHIPPING IS FALSE AND THAT THERE IS IN FACT A FLAW WITH THE SENSOR ITSELF. THIS IS EVIDENT IN THE FACT THAT BMW PRODUCED AN UPDATED VERSION OF THE SENSOR AND THAT MY SENSOR THOUGH NOT PART OF THE SO CALLED DAMAGED BATCH IS ALSO EXPERIENCING THE SAME EXACT SYMPTOMS. IF THE CAUSE OF THE FAULTY SENSORS WERE DUE TO BEING DAMAGED DURING SHIPPING THEN WHY NEED TO CREATE AN UPDATED VERSION. THE LOGICAL THING TO DO WOULD BE TO ENSURE THE SAFE DELIVERY OF THE SENSORS, NOT CREATE A NEW VERSION. I'VE OWNED MANY VEHICLES WITH THIS SAME FEATURE AND HAVE NEVER HAD ANY PROBLEMS. BMW CLAIMING THAT THE SYMPTOMS OF MY SENSOR HAVING THE SAME SYMPTOMS AS THE DAMAGED BATCH IS JUST A COINCIDENCE IS A FAR CRY. AT THE VERY LEAST A NEW INVESTIGATION SHOULD BE DONE. THANK YOU.

NHTSA ODI #10371428

Official recalls

22V119000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Mar 2, 2022

BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

Consequence & remedy

Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.

Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.

08V384000 · Air Bags:frontal

Aug 5, 2008

BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.

Consequence & remedy

Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.

Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

06V400000 · Suspension:front:control Arm

Oct 18, 2006

ON CERTAIN VEHICLES, ONE OF THE SUSPENSION CONTROL ARM AND SWIVEL BEARING CONNECTION BOLTS WAS NOT TIGHTENED CORRECTLY. THE BOLTED CONNECTION COULD LOOSEN.

Consequence & remedy

Consequence: THE BOLTED CONNECTION COULD BREAK WHICH COULD IMPAIR VEHICLE HANDLING AND CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE BOLTED CONNECTION AND, IF NECESSARY, ADJUST THE CONNECTION. IN SOME CASES, IT MAY BE NECESSARY TO REPLACE THE SUSPENSION CONTROL ARM AND THE SWIVEL BEARING. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA08001 · BMW Airbag Light Illumination

Opened Jan 4, 2008 · Closed Dec 31, 2008

Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE

BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.

Additional source detail variants (3)

Air Bags

Air Bags:frontal

Air Bags:frontal:sensor/control MODULE-INACTIVE