Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
1125–50K
750–75K
1375–100K
15100–150K
4150K+
51 reports with mileage · 26 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Exterior Lighting. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports3 fire reports2 injury reports
What owners actually said
77 reports
120,000 miles · Mar 22, 2019
Exterior Lighting
HEADLAMP BULB OUT AND UPON REPLACEMENT IT WAS NOTED THE COATED WIRING TO THE XENON SYSTEM TO RIGHT AND LEFT HEADLIGHT IS BRITTLE (THE WIRES PLASTIC COATING IS FALLING OFF)AND IN SOME PLACES EXPOSED WIRING WAS FOUND. ELECTRICAL TAPE NEED TO WRAP THE WIRING TO AVOID POTENTIAL FIRE. LATE NOTICE TO THIS SITE I WAS UNAWARE TO FILE A …
Read full complaint
HEADLAMP BULB OUT AND UPON REPLACEMENT IT WAS NOTED THE COATED WIRING TO THE XENON SYSTEM TO RIGHT AND LEFT HEADLIGHT IS BRITTLE (THE WIRES PLASTIC COATING IS FALLING OFF)AND IN SOME PLACES EXPOSED WIRING WAS FOUND. ELECTRICAL TAPE NEED TO WRAP THE WIRING TO AVOID POTENTIAL FIRE. LATE NOTICE TO THIS SITE I WAS UNAWARE TO FILE A REPORT. OTHERS ALSO HAVE COMPLAINED ABOUT THE SAME ISSUES.
NHTSA ODI #11190961
30 miles · Aug 9, 2018
Service BrakesCrashInjury
NEW DEFECTIVE BRAKE PADS CAUSED A TRAFFIC ACCIDENT WITH TOTAL LOSS OF THE VEHICLES INVOLVED. BRAKE PADS ARE CONTAMINATED AND EMBEDDED WITH A SLIPPERY SUBSTANCE. PADS ARE FROM PRIME CHOICE AUTO PARTS 42832 STATE ROUTE 12, ALEXANDRIA BAY, NY, 13607-2216 CAN YOU INVESTIGATE AND ANALYZE THE BRAKE PADS IN ORDER TO STOP THE …
Read full complaint
NEW DEFECTIVE BRAKE PADS CAUSED A TRAFFIC ACCIDENT WITH TOTAL LOSS OF THE VEHICLES INVOLVED. BRAKE PADS ARE CONTAMINATED AND EMBEDDED WITH A SLIPPERY SUBSTANCE. PADS ARE FROM PRIME CHOICE AUTO PARTS 42832 STATE ROUTE 12, ALEXANDRIA BAY, NY, 13607-2216 CAN YOU INVESTIGATE AND ANALYZE THE BRAKE PADS IN ORDER TO STOP THE SELLING OF DEFECTIVE AND DANGEROUS BRAKE PADS? I AM ABLE TO SHIP TO YOU A BRAKE PAD SAMPLE. THE VEHICLE WAS IN MOTION, BUT UNABLE TO STOP BEFORE TURNING ON A CITY STREET.
NHTSA ODI #11118862
100,000 miles · Nov 18, 2017
Electrical System
VEHICLE ADAPTIVE XENON HEADLIGHT WIRING IS FAULTY . WIRE INSULATION IS CRACKING/DETERIORATING AND ENTIRE WIRES ARE BREAKING APART. SYMPTOMS START WITH FLICKERING XENON HEADLIGHT EVENTUALLY (ABOUT A WEEK LATER) STOPS WORKING AT ALL. VEHICLE IS MOVING OR STATIONARY, ENGINE ON. THE FAULTY WIRES ARE IN A WEATHER SEALED COMPARTM…
Read full complaint
VEHICLE ADAPTIVE XENON HEADLIGHT WIRING IS FAULTY . WIRE INSULATION IS CRACKING/DETERIORATING AND ENTIRE WIRES ARE BREAKING APART. SYMPTOMS START WITH FLICKERING XENON HEADLIGHT EVENTUALLY (ABOUT A WEEK LATER) STOPS WORKING AT ALL. VEHICLE IS MOVING OR STATIONARY, ENGINE ON. THE FAULTY WIRES ARE IN A WEATHER SEALED COMPARTMENT OF THE HEADLIGHT AND HAVE NEVER (TO MY KNOWLEDGE) EVEN BEEN UNSEALED/ACCESSED SINCE LEAVING THE FACTORY. THE ISSUE IS ON THE PASSENGER SIDE, UNKNOWN IF IT IS ON THE DRIVER SIDE AS WELL. THE ATTACHED PHOTO SHOWS BACK SIDE OF THE HEADLIGHT HOUSING LOOKING DOWN, WITH THE WEATHER-SEALED COMPARTMENT OPEN. ALL EXPOSED WIRE IS AS A RESULT OF THE ISSUE, NOBODY HAS ACTIVELY CUT OR STRIPPED THE WIRES. PROBLEM FIRST NOTICED IN SEPT OF 2016, ATTEMPTS WERE MADE TO REPAIR BUT NOW IT HAS HAPPENED AGAIN, WORSE.
NHTSA ODI #11047229
204,000 miles · Nov 8, 2017
Electrical SystemFireInjury
MY VEHICLE UNEXPECTEDLY STARTED ON FIRE AS MY DAUGHTER WAS DRIVING TO SCHOOL. IT WAS DETERMINED THAT IT WAS AN ELECTRICAL FIRE, AND RESULTED IN THE CAR BEING TOTALED. THE 2004 MODELS NEED TO BE INCLUDED IN THE RECALL (NOT THAT IT WILL HELP WITH THE LOSS OF MY CAR).
HEADLIGHTS PROJECT ALMOST NO LIGHT. JUST PAID $130 TO HAVE LENSES CLEANED, NO IMPROVMENT. I THOUGHT IT WAS MY EYES AND COMPLAINED TO OPTHAMOLOGIST TWICE BUT MY EYES ARE OK. I'VE READ THT THE REFLECTOR BOWLS IN THIS MODEL MELT FROM THE HEAT OF THE BULB. I NEED TO REMEDY THIS SITUATION ASAP SO I WILL NOT BE ABLE TO WAIT FOR AN …
Read full complaint
HEADLIGHTS PROJECT ALMOST NO LIGHT. JUST PAID $130 TO HAVE LENSES CLEANED, NO IMPROVMENT. I THOUGHT IT WAS MY EYES AND COMPLAINED TO OPTHAMOLOGIST TWICE BUT MY EYES ARE OK. I'VE READ THT THE REFLECTOR BOWLS IN THIS MODEL MELT FROM THE HEAT OF THE BULB. I NEED TO REMEDY THIS SITUATION ASAP SO I WILL NOT BE ABLE TO WAIT FOR AN INVESTIGATION.
NHTSA ODI #10939058
Mileage unknown · Dec 12, 2016
Air Bags
TAKATA RECALL I RECEIVED A LETTER DATED JULY 2015 CONCERNING THE RECALL OF THE DRIVER'S SIDE AIR BAG. I CALLED MY LOCAL BMW ON 11/24/15 AND THEY SAID THEY PUT MY NAME ON THE LIST AND WOULD CALL ME WHEN THE REPLACEMENT CAME IN. I CALLED AGAIN ON 4/14/16 AND [XXX] SAID SHE WOULD CHECK TO MAKE SURE MY NAME IS ON THE LIST AND WOU…
Read full complaint
TAKATA RECALL I RECEIVED A LETTER DATED JULY 2015 CONCERNING THE RECALL OF THE DRIVER'S SIDE AIR BAG. I CALLED MY LOCAL BMW ON 11/24/15 AND THEY SAID THEY PUT MY NAME ON THE LIST AND WOULD CALL ME WHEN THE REPLACEMENT CAME IN. I CALLED AGAIN ON 4/14/16 AND [XXX] SAID SHE WOULD CHECK TO MAKE SURE MY NAME IS ON THE LIST AND WOULD CALL ME BACK WHEN THE PARTS ARRIVED. IT'S BEEN A YEAR AND A HALF AND I HAVE NOT RECEIVED A CALL BACK. THIS IS SO CONCERNING TO ME AS THIS CAR IS MY MAIN MODE OF TRANSPORTATION AND I AM SO AFRAID I WILL HAVE A FRONT END COLLISION RESULTING IN DEATH OR DISMEMBERMENT. IF THAT SHOULD HAPPEN I OR MY ESTATE WILL MOST CERTAINLY SUE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10934783
Mileage unknown · Oct 13, 2016
Air Bags
TAKATA RECALL I RECEIVED A AIR BAG RECALL NOTICE FROM BMW IN JUNE 2015 AND ANOTHER RECALL NOTICE IN SEPTEMBER 2016.OVER A YEAR + I HAVE BEEN CALLING SOUTH BAY BMW IN TORRANCE CA. AND THEY KEEP ON TELLING ME THEY DO NOT HAVE THE PARTS YET. CAN YOU PLEASE HELP ME..
NHTSA ODI #10915874
Mileage unknown · Oct 12, 2016
Exterior Lighting
MY HEADLIGHTS ARE SO DIM AT NIGHT IT IS IMPOSSIBLE TO SEE WITHOUT HIGH BEAMS ON AT ALL TIMES. THE FOG LIGHTS ARE BRIGHTER THAN MY NEW HEADLIGHT BULBS. ONLY SOLUTION SEEMS TO REPLACE THE WHOLE ASSEMBLY BUT AFTER RESEARCHING THIS SEEMS TO BE AN ONGOING ISSUE WITH BMW SO WHY SHOULD I HAVE TO SPEND OVER 1500.00 WHEN THEY SHOULD HAVE…
Read full complaint
MY HEADLIGHTS ARE SO DIM AT NIGHT IT IS IMPOSSIBLE TO SEE WITHOUT HIGH BEAMS ON AT ALL TIMES. THE FOG LIGHTS ARE BRIGHTER THAN MY NEW HEADLIGHT BULBS. ONLY SOLUTION SEEMS TO REPLACE THE WHOLE ASSEMBLY BUT AFTER RESEARCHING THIS SEEMS TO BE AN ONGOING ISSUE WITH BMW SO WHY SHOULD I HAVE TO SPEND OVER 1500.00 WHEN THEY SHOULD HAVE TO REPLACE THEM WITH A RECALL.
NHTSA ODI #10915585
112,000 miles · Sep 29, 2016
Air Bags
TAKATA RECALL. THIS COMPLAINT IS DUE TO THE SLOW RESPONSE OF NALLEY BMW IN DECATUR GEORGIA TO REPLACE MY AIRBAG. I RECEIVED MY RECALL LETTER AND IMMEDIATELY CALLED THE BMW DEALER ON SEPT 7TH. I WAS TOLD THAT PARTS WERE ORDERED AND I WOULD BE CALLED WHEN THEY ARRIVED. BY SEPT 16TH I HAD HEARD NOTHING AND CALLED AGAIN. NALLE…
Read full complaint
TAKATA RECALL. THIS COMPLAINT IS DUE TO THE SLOW RESPONSE OF NALLEY BMW IN DECATUR GEORGIA TO REPLACE MY AIRBAG. I RECEIVED MY RECALL LETTER AND IMMEDIATELY CALLED THE BMW DEALER ON SEPT 7TH. I WAS TOLD THAT PARTS WERE ORDERED AND I WOULD BE CALLED WHEN THEY ARRIVED. BY SEPT 16TH I HAD HEARD NOTHING AND CALLED AGAIN. NALLEY SAID THEY HAD NO RECORD OF MY HAVING ORDERED PARTS. I WAS TRANSFERRED TO THE PARTS DEPARTMENT WHERE NO ONE ANSWERED THE PHONE. SO I CALLED BMW NATIONAL CUSTOMER RELATIONS. THEY SAID THEY WOULD CONTACT THE DEALER AND HAVE THEM GET IN TOUCH WITH ME DIRECTLY. NOTHING HAPPENED, SO TODAY VISITED THE DEALER PERSONALLY TO GET THE PARTS ORDERED. I WAS TOLD IT WOULD TAKE AN ADDITIONAL TWO WEEKS TO RECEIVE PARTS. THIS IS UNACCEPTIBLE. MY RECALL LETTER FROM BMW CLEARLY STATES "WE HAVE THE NECESSARY PARTS TO COMPLETE THIS RECALL," "PLEASE CONTACT YOUR AUTHORIZED BMW CENTER IMMEDIATELY TO SCHEDULE AN APPOINTMENT TO HAVE THIS IMPORTANT FREE RECALL PERFORMED AS SOON AS POSSIBLE," AND "...METAL FRAGMENTS STRIKING THE DRIVER OR OTHER PASSENGERS POTENTIALLY RESULTING IN SERIOUS INJURY OR DEATH." BMW HAS BUILT CARS WITH SHRAPNEL GRENADES INSTEAD OF AIRBAGS AND NOW THEY DON'T CARE ABOUT FIXING IT. BMW SHOULD NOT E ALLOWED TO SELL ANOTHER VEHICLE IN THE US UNTIL THEY HAVE COMPLETED ALL OF THESE CRITICAL RECALLS.
NHTSA ODI #10910699
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
2004 BMW 3 Series Problems, Complaints & Recalls | Skip That Year
Illustration