Air Bags. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports1 fire reports5 injury reports

Exterior Lighting complaints

2 reports

Clear category filter

146,000 miles · Feb 9, 2019

Electrical SystemExterior Lighting

Read full complaint

I WAS RECEIVING A IMAGINE ON THE ON BOARD COMPUTER SAYING THAT MY HEADLIGHTS WERE NOT WORKING. UPON INSPECTION INSIDE THE HEADLIGHT'S CASING, I SAW THAT ALL OF THE WIRING'S PROTECTION HAD COMPLETELY FELL OFF (PROBABLY DUE TO THE HUMID SOUTHERN CLIMATE OF NORTH TEXAS) LEAVING ALMOST ALL OF THE WIRING ON BOTH SIDES OF MY HEADLIGHTS (DRIVER AND PASSENGER SIDE) COMPLETELY EXPOSED. THE COPPER WIRING INSIDE IS ALMOST ALL EXPOSED. OBVIOUSLY THIS IS CAUSING THE HEADLIGHTS TO SHORT AND LEAVING ME WITH NO VISIBILITY WHILE DRIVING AT NIGHT. THIS IS A MODEL WITHOUT ANGEL EYES, SO MY DRL DO NOT WORK WHAT SO EVER. THESE HEADLIGHTS ARE COMPLETELY STOCK, SO THIS IS A FACTORY FAULT. VERY UNHAPPY WITH THIS. THANKS BMW FOR THE "FANTASTIC" ENGINEERING! SHOULD BE COVERED UNDER A RECALL.

NHTSA ODI #11175801

110,000 miles · Apr 26, 2016

Electrical SystemExterior Lighting

Read full complaint

I OWN A 2006 BMW 325I. ABOUT A YEAR OR TWO AGO, THE REVERSE LIGHTS WILL NOT ILLUMINATE WHILE REVERSING. I TOOK THE VEHICLE TO THE DEALERSHIP, EXPLAINED THE PROBLEM, AND MENTIONED MULTIPLE ONLINE ACCOUNTS OF THIS PROBLEM EXTENDING AT LEAST FROM 2003 THROUGH 2008. IT COULD HAVE BEEN LONGER. I ALSO REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TURN SIGNAL) AND NHTSA ID NUMBER: 10443539 (TAIL LIGHT FAILURE). THE DEALER ADVISED ME THAT THIS VEHICLE YEAR WAS NOT INCLUDED IN ANY RECALL CAMPAIGN FOR THIS PROBLEM. IN ADDITION, THE DEALER ADVISED THAT THE FRM MODULE NEEDED TO BE REPLACED DUE TO A WIRING MALFUNCTION. FROM ONLINE REPORTS AND PICTURES, I CONFIRMED MY REVERSE LIGHT FAILURE WAS ALSO A WIRING ISSUE CAUSED FROM A VERY POOR WIRE ROUTING DESIGN BY BMW. THE FAILURE MILEAGE WAS AT APPROXIMATELY 110,000 AND THE COST TO REPAIR WAS OUTRAGEOUS! SINCE THAT TIME EVEN WITH MULTIPLE DOCUMENTED CASES, BMW HAS BEEN UNWILLING TO ADMIT THIS IS THEIR DESIGN FAILURE AND TO SHARE IN ANY OF THE REPAIR COSTS.

NHTSA ODI #10861603

Official recalls

22V119000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Mar 2, 2022

BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

Consequence & remedy

Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.

Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.

08V384000 · Air Bags:frontal

Aug 5, 2008

BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.

Consequence & remedy

Consequence: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.

Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

06V400000 · Suspension:front:control Arm

Oct 18, 2006

ON CERTAIN VEHICLES, ONE OF THE SUSPENSION CONTROL ARM AND SWIVEL BEARING CONNECTION BOLTS WAS NOT TIGHTENED CORRECTLY. THE BOLTED CONNECTION COULD LOOSEN.

Consequence & remedy

Consequence: THE BOLTED CONNECTION COULD BREAK WHICH COULD IMPAIR VEHICLE HANDLING AND CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE BOLTED CONNECTION AND, IF NECESSARY, ADJUST THE CONNECTION. IN SOME CASES, IT MAY BE NECESSARY TO REPLACE THE SUSPENSION CONTROL ARM AND THE SWIVEL BEARING. THE RECALL BEGAN ON NOVEMBER 21, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA08001 · BMW Airbag Light Illumination

Opened Jan 4, 2008 · Closed Dec 31, 2008

Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE

BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.

Additional source detail variants (3)

Air Bags

Air Bags:frontal

Air Bags:frontal:sensor/control MODULE-INACTIVE