NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
51 reports80,000 miles · Jan 2, 2012
Exterior Lighting
THE BMW E46 (3 SERIES BMW) THAT WAS MADE FROM 1999 TO 2006. IN SOME CASES DURING THESE YEARS THEY USED A LIGHTING MANUFACTURER "ZKW" FOR THEIR XENON HEADLIGHTS. UNFORTUNATELY THESE LIGHTS HAVE A COMMON FAILURE ISSUE COMMONLY REFERRED TO AS A "BURNT REFLECTOR" ON THE INTERNET AND ON BMW FORUMS. THIS IS A NON-CONSUMER REPLACEABL…
Read full complaint
THE BMW E46 (3 SERIES BMW) THAT WAS MADE FROM 1999 TO 2006. IN SOME CASES DURING THESE YEARS THEY USED A LIGHTING MANUFACTURER "ZKW" FOR THEIR XENON HEADLIGHTS. UNFORTUNATELY THESE LIGHTS HAVE A COMMON FAILURE ISSUE COMMONLY REFERRED TO AS A "BURNT REFLECTOR" ON THE INTERNET AND ON BMW FORUMS. THIS IS A NON-CONSUMER REPLACEABLE PART. WHEN THIS PART FAILS IT CAUSES THE VEHICLE TO NOT HAVE EFFECTIVE HEADLIGHTS. I PERSONALLY HAVE HAD TIMES WHERE MY FIELD OF VISION COULD NOT SEE ITEMS ON THE ROAD DUE TO THE DIM LIGHTS. THE ONLY REMEDY APPEARS TO BE TO REPLACE THE ENTIRE HEADLIGHT ASSEMBLY TO THE TUNE OF HUNDREDS OF DOLLARS (WELL OVER A THOUSAND IF YOU DO BOTH SIDES). IN MY OPINION BMW SHOULD CORRECT THIS ISSUE FOR THE CONSUMER. HEADLIGHTS ARE AN IMPORTANT SAFETY ITEM. TO HAVE A PART FAIL THAT IS NOT CONSUMER REPLACEABLE IS UNACCEPTABLE. MANY PEOPLE HAVE THIS ISSUE BUT HAVE NO WAY TO REMEDY IT. JUST GOOGLE IT OR CHECK E46FANATICS.COM. YOU WILL SEE THAT THERE ARE PLENTY OF PEOPLE THAT REALIZE THIS IS AN ISSUE. *TR
NHTSA ODI #10442114
90,000 miles · Dec 13, 2011
Electrical SystemLatches/locks/linkagesStructure
PASSENGER SIDE DOOR AND BOTH REAR DOORS FAILED TO OPEN. ALL THREE DOORS REMAINED LOCKED AND COULD NOT BE OPEN FROM INSIDE BY USING THE MECHANICAL HANDLES. NEITHER THE REMOTE KEY NOR THE REGULAR KEY WAS ABLE TO UNLOCK THE DOORS. *TR
NHTSA ODI #10439773
105,952 miles · Dec 11, 2011
Exterior Lighting
MY BMW 2003 330I IS EQUIPPED WITH ZKW HEADLIGHT ASSEMBLIES THAT HAVE PLASTIC XENON PROJECTOR BOWLS INSTALLED INSIDE THE HEADLIGHT ASSEMBLIES. AFTER SEVERAL YEARS OF USAGE THESE PROJECTOR BOWLS BURN OUT AND AS A RESULT, THE REFLECTIVE COATING THAT ALLOWS LIGHT TO BE FOCUSED THROUGH THE PROJECTORS ARE BURNED OFF REDUCING EFFECTIVE…
Read full complaint
MY BMW 2003 330I IS EQUIPPED WITH ZKW HEADLIGHT ASSEMBLIES THAT HAVE PLASTIC XENON PROJECTOR BOWLS INSTALLED INSIDE THE HEADLIGHT ASSEMBLIES. AFTER SEVERAL YEARS OF USAGE THESE PROJECTOR BOWLS BURN OUT AND AS A RESULT, THE REFLECTIVE COATING THAT ALLOWS LIGHT TO BE FOCUSED THROUGH THE PROJECTORS ARE BURNED OFF REDUCING EFFECTIVE LIGHT OUTPUT FROM THE HEADLIGHT ASSEMBLY. UPON INSPECTION, BOTH MY HEADLIGHT ASSEMBLIES SUFFERED APPROXIMATELY 50% LOSS IN EFFECTIVE LIGHT OUTPUT DUE TO BURNED OUT XENON PROJECTOR BOWLS AND I FOUND THAT MY FOG LIGHTS WERE PUTTING OUT MORE LIGHT THAN BOTH MY ZKW HEADLIGHTS. THIS PROBLEM AFFECTS ALL 3-SERIES SEDANS MADE FROM 2002 - 2005. THERE HAVE BEEN MANY PEOPLE WHO HAVE, AS A RESULT OF BMW INACTION TO DO THE RIGHT THING AND CORRECT THIS SERIOUS SAFETY DEFICIENCY, EITHER REPLACED THEIR ORIGINAL ZKW HEADLIGHT ASSEMBLIES WITH DEPOT AFTERMARKET HEADLIGHT ASSEMBLES OR HAVE REPLACED THE DEFECTED ZKW PROJECTOR BOWLS WITH AL PROJECTOR BOWLS OR FX-R PROJECTOR BOWLS. THIS PROBLEM NEEDS TO BE ADDRESSED AS IT IS A SERIOUS ROAD SAFETY ISSUE WHILE DRIVING AT NIGHT. *TR
NHTSA ODI #10439285
111,000 miles · Dec 11, 2011
Exterior Lighting
ZKW BI XENON HEADLIGHTS REFLECTORS BURN OUT OVER TIME. THE BOWLS ARE SHOT AND THEY WERE BLACK, BURNED TO A CRISP. THEY WERE MADE OUT OF A PLASTIC MATERIAL WITH A CHROME COATING, INSTEAD OF A METAL REFLECTOR. THIS SHOULD BE A RECALL FOR BMW. THEY GOT THE TAIL LIGHT WHICH WORKS FINE IN MY CAR, I NEED MY HEADLIGHTS TO SEE! *TR
NHTSA ODI #10439284
80,000 miles · Dec 9, 2011
Exterior Lighting
TL* THE CONTACT OWNS A 2003 BMW 3SERIES. THE CONTACT STATED THAT THE REAR TAIL LIGHT WARNING INDICATOR ILLUMINATED ON THE INSTRUMENTAL PANEL. AFTER CHECKING THE REAR OF THE VEHICLE, THE TAIL LIGHT APPEARED TO BE OPERATING AS DESIGNED. THE WARNING LIGHT WOULD ILLUMINATE ON AN INTERMITTENT BASIS. THE VEHICLE WAS NOT INSPECTED BY …
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW 3SERIES. THE CONTACT STATED THAT THE REAR TAIL LIGHT WARNING INDICATOR ILLUMINATED ON THE INSTRUMENTAL PANEL. AFTER CHECKING THE REAR OF THE VEHICLE, THE TAIL LIGHT APPEARED TO BE OPERATING AS DESIGNED. THE WARNING LIGHT WOULD ILLUMINATE ON AN INTERMITTENT BASIS. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V438000 (EXTERIOR LIGHTING:TAIL LIGHTS). THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
NHTSA ODI #10439132
95,000 miles · Dec 7, 2011
Electrical SystemPower TrainService Brakes, Hydraulic
IN 2010 THE SUNROOF WENT BAD I TALKED TO A BMW DEALER AND THEY TOLD ME THEY HAVE PROBLEMS WITH THEM, IN AUGUST OF 2011 I NOTICED THAT MY TAIL LIGHTS AND BLINKERS WERE NOT WORKING PROPER,NOR WAS MY HORN,AND THE DRIVERS WINDOW REGULATORS ARE BINDING UP, ALSO A BRAKE HOSE FROM MY BRAKE BOOSTER TO THE ENGINE IS COLLAPSED IN TWO SPOT…
Read full complaint
IN 2010 THE SUNROOF WENT BAD I TALKED TO A BMW DEALER AND THEY TOLD ME THEY HAVE PROBLEMS WITH THEM, IN AUGUST OF 2011 I NOTICED THAT MY TAIL LIGHTS AND BLINKERS WERE NOT WORKING PROPER,NOR WAS MY HORN,AND THE DRIVERS WINDOW REGULATORS ARE BINDING UP, ALSO A BRAKE HOSE FROM MY BRAKE BOOSTER TO THE ENGINE IS COLLAPSED IN TWO SPOTS. ??*TR
NHTSA ODI #10438952
69,000 miles · Nov 16, 2011
Engine And Engine Cooling
THE COOLING FAN BROKE LOOSE SPONTANEOUSLY AND FLEW THROUGH THE AIR CUTTING THROUGH THE HOOD OF THE CAR AND RIPPING THROUGH THE ENTIRE ENGINE COMPARTMENT. MOMENTS PRIOR THE HOOD HAD BEEN OPEN WITH PEOPLE STANDING AROUND LOOKING AT THE HOSES. HAD THE FAN BROKE LOOSE AT THIS TIME, I WOULD HAVE SERIOUSLY INJURED OR KILLED PEOPLE. *…
Read full complaint
THE COOLING FAN BROKE LOOSE SPONTANEOUSLY AND FLEW THROUGH THE AIR CUTTING THROUGH THE HOOD OF THE CAR AND RIPPING THROUGH THE ENTIRE ENGINE COMPARTMENT. MOMENTS PRIOR THE HOOD HAD BEEN OPEN WITH PEOPLE STANDING AROUND LOOKING AT THE HOSES. HAD THE FAN BROKE LOOSE AT THIS TIME, I WOULD HAVE SERIOUSLY INJURED OR KILLED PEOPLE. *TR
NHTSA ODI #10436090
50,000 miles · Oct 25, 2010
Exterior Lighting
TL*THE CONTACT OWNS A 2003 BMW 330I. THE CONTACT STATED THAT WHEN THE BRAKE CAUTION LIGHT ILLUMINATED, THE BRAKE LIGHT, TAIL LIGHT AND TURN SIGNALS FAILED SUDDENLY. THE CONTACT REPLACED THE REAR BULB SEVERAL TIME. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT PLANNED TO SPEAK WITH THE MANUFACTURER. THE FAILURE MILE…
Read full complaint
TL*THE CONTACT OWNS A 2003 BMW 330I. THE CONTACT STATED THAT WHEN THE BRAKE CAUTION LIGHT ILLUMINATED, THE BRAKE LIGHT, TAIL LIGHT AND TURN SIGNALS FAILED SUDDENLY. THE CONTACT REPLACED THE REAR BULB SEVERAL TIME. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT PLANNED TO SPEAK WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 60,000.
NHTSA ODI #10362231
70,000 miles · Jul 23, 2010
Exterior Lighting
REAL LIGHT ASSEMBLY (TURN SIGNAL, PARKING LIGHT BRAKE LIGHT) MALFUNCTIONS OCCASIONALLY AND NONE OF THE LIGHTS WORK THUS, POSING A DANGEROUS SITUATION WHEN VEHICLE IN MOTION, TURNING AND ESPECIALLY AT NIGHT. PROBLEM HAS BEEN GOING ON FOR AT LEAST A YEAR. IT APPEARS THAT THE WIRE CONNECTOR IN THE ASSEMBLY IS BURNING OUT THUS CAUS…
Read full complaint
REAL LIGHT ASSEMBLY (TURN SIGNAL, PARKING LIGHT BRAKE LIGHT) MALFUNCTIONS OCCASIONALLY AND NONE OF THE LIGHTS WORK THUS, POSING A DANGEROUS SITUATION WHEN VEHICLE IN MOTION, TURNING AND ESPECIALLY AT NIGHT. PROBLEM HAS BEEN GOING ON FOR AT LEAST A YEAR. IT APPEARS THAT THE WIRE CONNECTOR IN THE ASSEMBLY IS BURNING OUT THUS CAUSING A SHORT, I HAVE TEMPORARILY REPAIRED THE PROBLEM MYSELF BY CLEANING THE BURNED PARTS OF THE WIRE AND RECONNECTING AND PROTECTING WITH ELECTRIC TAPE. *TR
NHTSA ODI #10344930
Mileage unknown · Nov 28, 2005
Tires
I WAS TOLD THAT MY TIRE HAD A DEFECT BUT IT WAS SAFE TO DRIVE. ONE PERSON TOLD ME THAT IT WAS A TIRE DEFECT BUT HE WOULD NOT BE ABLE TO SAY ANYTHING SINCE HE WORKED FOR THE COMPANY. THEN I WAS TOLD THAT IT HAD A BULGE CAUSED BY A POT HOLE BUT IT WAS NOT DANGEROUS. WHILE DRIVING THE TIRE BLEW OUT AND LITERALLY LIFTED THE CAR UP O…
Read full complaint
I WAS TOLD THAT MY TIRE HAD A DEFECT BUT IT WAS SAFE TO DRIVE. ONE PERSON TOLD ME THAT IT WAS A TIRE DEFECT BUT HE WOULD NOT BE ABLE TO SAY ANYTHING SINCE HE WORKED FOR THE COMPANY. THEN I WAS TOLD THAT IT HAD A BULGE CAUSED BY A POT HOLE BUT IT WAS NOT DANGEROUS. WHILE DRIVING THE TIRE BLEW OUT AND LITERALLY LIFTED THE CAR UP ON TWO WHEELS. I WAS SO SCARED AND UPSET AFTER I REGAINED CONTROL THAT I CALLED THE COMPANY AND THEY SAID OH WELL. I HAVE BEEN COMPLAINING ABOUT THE TIRES SINCE THEY WERE PUT ON LAST SUMMER. THEY BOUNCE CONSTANTLY BUT YET COOPER DOES NOT STAND BEHIND THEIR SO CALLED HIGH PERFORMANCE TIRES. *JB
NHTSA ODI #10143744
NHTSA investigations
3EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Illustration