IllustrationOEM PROJECTOR HEADLIGHTS BURNT BEHIND PROJECTOR CAUSING VERY DIM LIGHTS. *TR
2003 BMW 3 Series
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 BMW 3 Series do not stand out strongly from the model-year median of 23.
About this comparison →How this year compares
Owner complaints by model year
Compare all 3 Series years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
125–50K
950–75K
875–100K
11100–150K
4150K+
34 reports with mileage · 17 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports3 injury reports
What owners actually said
51 reportsI WAS LOCKED IN MY CAR FOR 1 HOUR. MY KEY FOB WOULD NOT UNLOCK MY DOORS, SO I MANUALLY OPENED THE DOOR, STARTED THE CAR, CLOSED THE DOOR, AND TRIED TO WARM UP THE CAR (IT IS WINTER IN CHICAGO AND MY WINDOWS WERE ALSO FROZEN SHUT). I THEN PRESSED THE DOOR LOCK BUTTON TWICE IN AN ATTEMPT TO UNLOCK THE DOORS AND AT THAT POINT I LE…
Read full complaint
I WAS LOCKED IN MY CAR FOR 1 HOUR. MY KEY FOB WOULD NOT UNLOCK MY DOORS, SO I MANUALLY OPENED THE DOOR, STARTED THE CAR, CLOSED THE DOOR, AND TRIED TO WARM UP THE CAR (IT IS WINTER IN CHICAGO AND MY WINDOWS WERE ALSO FROZEN SHUT). I THEN PRESSED THE DOOR LOCK BUTTON TWICE IN AN ATTEMPT TO UNLOCK THE DOORS AND AT THAT POINT I LEARNED I WAS LOCKED IN MY CAR. I TRIED DRIVING THE CAR A BLOCK TO SEE IF THE LOCKS WOULD RESET AND NOTHING WORKED (NEITHER THE DOOR LEVERS, KEY FOB OR LOCK BUTTON). I CALLED A DEALER AND THEY SUGGESTED I DRIVE IT TO THE SERVICE CENTER. WHEN I ARRIVED AT THE SERVICE CENTER AN HOUR LATER, MY WINDOW WAS NO LONGER FROZEN SO I HANDED THE KEY TO THE AGENT AND ALTHOUGH THE MANUAL DOOR HANDLES AND UNLOCK BUTTON WOULD NOT WORK, THE KEY FOB WAS ABLE TO UNLOCK THE DOORS. THE AGENT AGREED THAT THERE WAS A PROBLEM THAT NEEDED TO BE INSPECTED. I DROVE THE CAR HOME. TWO DAYS LATER I TRIED TO START THE CAR AND THE BATTERY WAS DEAD. WE JUMPED IT AND I DROVE THE CAR TO A DEALER. THE DEALER REPLACED AND PROGRAMMED THE GENERAL MODULE BEHIND THE GLOVE BOX. THEY SAID THAT IT HAD CAUSED THE PROBLEM WITH THE DOORS AND DRAINED THE BATTERY. THE BMW REPRESENTATIVES DO NOT SEEM SURPRISED BY THE PROBLEM, BUT I WAS QUITE FRIGHTENED BY THE FACT THAT I HAD TO DRIVE MY CAR WHILE LOCKED INSIDE THE VEHICLE. *TR
MY TAIL LIGHTS AND TURN SIGNALS WORK FOR A WHILE THEN QUITE WORKING. THE EXACT SAME SYMPTOMS AS RECALL #11V438000 FOR THE SAME TYPE, MODEL AND YEAR AS MY CAR, BUT BMW SAYS MY VEHICLE IS NOT INCLUDED. *TR
THE PASSENGER SIDE DOOR LOCK WILL NOT WORK. THE DOOR STAYS LOCKED AND WHEN IT FIRST OCCURED THE PASSENGER HAD TO CRAWL OUT THE WINDOW. NEITHER THE ELECTRONIC KEY LOCK NOR THE PUSHBUTTON LOCK CONTROL ON THE CONSOLE WILL OPEN THE DOOR LOCK ON THE PASSENGER SIDE. ALL OTHER LOCKS WORK FINE, INCLUDING THE TRUNK. THE MANUAL DOOR O…
Read full complaint
THE PASSENGER SIDE DOOR LOCK WILL NOT WORK. THE DOOR STAYS LOCKED AND WHEN IT FIRST OCCURED THE PASSENGER HAD TO CRAWL OUT THE WINDOW. NEITHER THE ELECTRONIC KEY LOCK NOR THE PUSHBUTTON LOCK CONTROL ON THE CONSOLE WILL OPEN THE DOOR LOCK ON THE PASSENGER SIDE. ALL OTHER LOCKS WORK FINE, INCLUDING THE TRUNK. THE MANUAL DOOR OPENER WILL NOT OPEN THE PASSENGER DOOR EITHER. THIS IS EXTREMELY DANGEROUS SINCE, IN THE CASE OF AN ACCIDENT, THE PASSENGER WOULD BE TRAPPED IN THE VEHICLE. *TR
THE PROJECTOR BOWLS ON THE ZKW HEADLIGHTS WERE BURNT OUT DUE TO A DESIGN FLAW. I SEE LOT OF COMPLAINTS ONLINE WITH THE SAME ISSUE. DRIVING IN NIGHT IS REALLY DIFFICULT AND DANGEROUS. *TT
DOORS FAIL TO UNLOCK, EITHER USING THE KEYFOB, THE INSIDE BUTTON OR MANUALLY BY PULLING THE DOOR HANDLE. THIS IS A VERY DANGEROUS SITUATION AS OCCUPANTS ARE TRAPPED INSIDE. NO METHOD OF OPENING THE DOOR WORK. THIS APPEARS TO BE INTERMITTENT AND EVENTUALLY THE DOORS UNLOCK MECHANISM STARTS WORKING AGAIN. THE GM5 MODULE SEEMS AT F…
Read full complaint
DOORS FAIL TO UNLOCK, EITHER USING THE KEYFOB, THE INSIDE BUTTON OR MANUALLY BY PULLING THE DOOR HANDLE. THIS IS A VERY DANGEROUS SITUATION AS OCCUPANTS ARE TRAPPED INSIDE. NO METHOD OF OPENING THE DOOR WORK. THIS APPEARS TO BE INTERMITTENT AND EVENTUALLY THE DOORS UNLOCK MECHANISM STARTS WORKING AGAIN. THE GM5 MODULE SEEMS AT FAULT. THIS COULD BE VERY DANGEROUS IN AN EMERGENCY SITUATION. *TR
DUE TO THE PLASTIC BOWELS IN THE HEADLIGHT PROJECTORS, WHICH ARE CHROME LIKE LINED, AND THE HIGH HEAT OF THE HID BULBS, THIS CHROME LIKE COATING HAS BURNED OFF MAKING THE LIGHT OUTPUT OF MY HID HEAD LIGHTS VERY DIM. THE OUTSIDE OF THE BOWELS HAVE GONE FROM A CHROME LIKE COATING TO A BRONZE/CARAMEL COLOR/COATING. THIS PROBLEM IS …
Read full complaint
DUE TO THE PLASTIC BOWELS IN THE HEADLIGHT PROJECTORS, WHICH ARE CHROME LIKE LINED, AND THE HIGH HEAT OF THE HID BULBS, THIS CHROME LIKE COATING HAS BURNED OFF MAKING THE LIGHT OUTPUT OF MY HID HEAD LIGHTS VERY DIM. THE OUTSIDE OF THE BOWELS HAVE GONE FROM A CHROME LIKE COATING TO A BRONZE/CARAMEL COLOR/COATING. THIS PROBLEM IS VERY OBVIOUS. I HAVE HAD OTHER VEHICLES WITH HID HEADLIGHTS, AND THE LIGHT OUTPUT OF THOSE CARS IS EASILY DOUBLE OR MORE, TO THE POINT WHERE ALOT OF TIMES I HAVE TO DRIVE WITH MY FOG LIGHTS ON JUST TO LIGHT THE ROAD UP TO BE ABLE TO SEE WELL ENOUGH SO THAT I DON'T HAVE A ACCIDENT. I HAVE PICTURES I TOOK OF THE DISCOLORED BOWELS IM TALKING ABOUT ON MY PHONE THAT I WOULD BE ABLE TO SEND. *TR
BOTH REAR SPRINGS OF MY BMW 2003 325I WERE CRACKED & REPLACED FEB. 23, 2009. THEY NOW BOTH ARE BROKEN AGAIN. ANY TYPE WARRANTY ON THE PARTS ? RIDICULOUS !!!! *TT
ZKW XENON HEADLIGHT REFLECTOR BOWL IS BURNED RESULTING IN VERY DIM LIGHT OUTPUT. I AM OFTEN AFRAID OF DRIVING AT NIGHT BECAUSE I FEEL IT IS A DANGER TO MY SAFETY.
TL* THE CONTACT OWNS A 2003 BMW 323. THE CONTACT STATED THAT THE HEADLIGHTS WOULD FLICKER ON AND OFF. THE TURN SIGNAL LIGHT WOULD ALSO FLICKER ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THE TAILLIGHT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER …
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW 323. THE CONTACT STATED THAT THE HEADLIGHTS WOULD FLICKER ON AND OFF. THE TURN SIGNAL LIGHT WOULD ALSO FLICKER ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THE TAILLIGHT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V438000 (EXTERIOR LIGHTING:TAIL LIGHTS). THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.