2014 Audi Q5

My Q5 has a defective subframe. The system is defective because plastic coverings on the subframes of Audi Q5s and SQ5s trap moisture and other elements, causing the subframe to rust, rot, and corrode undetected, which creates a dangerous safety hazard, the existence and extent of which is concealed by the plastic coverings. This results in a myriad of negative consequences for the Class Vehicles and their safe and reliable operation. The defect, which can only be discovered after removing the plastic covering on the vehicles’ steel subframe, leaves an affected Audi vulnerable to “structural instability.”

Post fix EDR cooler failure causing coolant fluid loss " enough complaints =pressure on Audi Reference EA189 emissions fix Subject: Goodwill Assistance Request – 2014 Q5 TDI EGR Cooler – VIN [XXX] Audi Customer Experience Team, I am writing to request goodwill assistance for my 2014 Audi Q5 TDI, VIN [XXX] , with 105,000 miles. Vehicle Issue The car is losing engine coolant with no external leaks. Symptoms are consistent with a failed EGR cooler: low coolant warnings every few weeks, white smoke on cold starts, and no puddles or visible leaks. This is a documented failure mode on the 3.0L TDI V6 engine, especially after the emissions modification. Warranty Background - Original in-service date: [XXX] - Emissions modification completed: 2018 - Current mileage: 105,000 I understand the EGR cooler is a covered component under the TDI Extended Emissions Warranty as an emissions-related part. While the 10-year time provision from the in-service date expired [XXX], I am well under the 120,000-mile limit. The 4 years/48k miles from the 2018 modification also places the failure directly within the spirit of the extended coverage. Basis for Goodwill Request The EPA-approved emissions modification increased EGR duty cycles and thermal stress on the cooler. This failure is a direct consequence of that modification. Repair quotes from Audi dealers are $1,200-$2,000 due to the labor involved to access the cooler in the V of the engine. The vehicle has been maintained with VW 507.00 specification oil and has no aftermarket modifications. I intend to keep the vehicle long-term if repaired. Request I respectfully request Audi cover the diagnosis and replacement of the EGR cooler under goodwill. I am happy to have the work performed at an authorized Audi dealer in Houston. I appreciate your consideration and can provide service records or additional photos if needed. I can be reached at [XXX] or this email. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)

Severe corrosion of the rear subframe crossmember on a 2014 Audi Q5 Premium Plus, purchased with 65,464 miles. Two independent inspections in South Carolina confirmed structural failure. Audi of Greenville, an authorized Audi dealership, marked the condition as VERY DANGEROUS on the service invoice and quoted $4,711.52 for subframe replacement. They were unable to perform a wheel alignment due to the severity of the corrosion. Yoder's Automotive in Westminster, SC independently confirmed the subframe was rusted beyond repair on both sides. Fist-sized holes have corroded through the structural metal on both sides of the subframe. The vehicle has plastic stone guard covers bolted over the subframe from the factory. These covers trapped road salt and moisture against unpainted mild steel, accelerating concealed corrosion that was invisible until the covers were removed during inspection. The vehicle is undriveable and has not been driven since the defect was discovered in approximately March 2026. This defect pattern is documented in at least 16 prior NHTSA complaints for Audi Q5 models spanning model years 2010 through 2018. Audi has revised the subframe part number at least five times (8R0505235F through 8R0505235N) but has issued zero recalls and zero consumer notifications.

This vintage 2014 Audi A5 has a well known serious rust perforation issue with the rear subframe. The corrosion / rust through of two major holes, approx 3 inches in diameter, causing structural failure of the sub frame. This is a major saftey concern with these cars from model year 2009 thru 2017. The only remedy is replacement of the sub frame under Audi's 12 year rust perforation warranty or good will.

The contact owns a 2014 Audi Q5. The contact stated that while driving at an undisclosed speed, there was an abnormal fuel odor inside the vehicle. The contact stated that while exiting the vehicle, the fuel odor was also outside the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a leaking fuel pump. The contact was informed of NHTSA Campaign Number: 17V298000 (Fuel System, Gasoline). The dealer was made aware of the failure, and the contact was informed that the recall repair was performed in 2017. The contact was informed that a protective film was applied during the recall repair. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the recall repair had a one-year warranty. The failure mileage was approximately 108,000.

I am filing a safety complaint regarding a progressive engine defect. Beginning as early as 2019 (approximately 84,000 miles), I repeatedly reported excessive oil consumption and related engine concerns to authorized Audi dealerships. These complaints continued over several years. At no point was I informed that these symptoms could be associated with a known defect pattern or progressive engine failure. The condition has now escalated to a severe engine malfunction. The vehicle began exhibiting engine misfires, flashing check engine light, EPC warning, and unstable operation. The dealership confirmed misfire fault codes and oil contamination affecting the ignition system. Engine replacement was initially recommended. Excessive oil consumption leading to internal contamination and misfires presents a significant safety hazard. Loss of engine power or sudden failure while driving can create dangerous conditions, particularly at highway speeds or in traffic. Despite the long history of reported symptoms, Audi of America has declined to provide assistance, citing only warranty status and failing to address the defect progression. The vehicle has now been inoperable at an Audi dealership for approximately 60 days (nearly two months), with no resolution. This situation raises concerns regarding a safety-related defect, failure to disclose a known issue, and a potential broader pattern affecting similar vehicles equipped with this engine. I am requesting that this issue be reviewed for potential defect investigation. The dealer provided diagnostic findings with Failure Codes via a temporary link that is no longer accessible. I am requesting a copy of the full report and will upload this (once received), along with other documentation.

Vehicle rear subframe comes with plastic covers that trap road salt and cause severe corrosion. Issue only presents itself when plastic covers are removed, revealing rust/corrosion and lost material, and a risk of the subframe to split resulting in lost of vehicle control on the road. This was found as a preventative action due to reports from other car owners and is confirmed by Audi Dealers as a common issue. Labor and parts estimate around $6000 (including $2000 in parts)

On Tuesday, September 2nd, I was in a car accident on the freeway. A car jump out in front of me and did not go quickly enough, I hit my breaks, but still hit them going around 55-60 MPH. When the impact occurred, my car turned itself off and I saw smoke coming out of the dash / center area of the car. I was able to start my car and get it off of the freeway safely. My airbag did not deploy, and it appeared the charge went off. The airbag light is now illuminated on the dash. There are no open recalls on my car, and I am truly concerned there is an issue with the airbags and do not want anyone else to get hurt if their airbags do not go off. I spoke with the local dealership on Friday, and they recommended that I reach out directly to Audi. I contacted Audi, answered all of their questions, sent photos and the police report. This is the response I received from them today, 9/22: "Our engineer has completed the review of all the documentation you provided. Here is his assessment: Damage to this vehicle is to sheet metal and composite material components of the hood, fender, headlight, bumper cover, and radiator core support. The impact is offset to the right, outside the bumper reinforcement system with no apparent damage or longitudinal compression of the bumper deformation elements or frame long members. The progressive deformation of the components listed above absorbs crash energy over a longer period of time, lowering the vehicles rate of deceleration below the threshold criteria for airbag deployment. This vehicle performed as designed." I do not believe this is accurate because there was smoke inside the car, and now the airbag light is illuminated.