2021 Audi E-TRON

I own a 2021 Audi e-tron with approximately 58000 miles. Beginning in March 2026, the vehicle developed intermittent Virtual Cockpit/instrument-cluster problems with blank display. I reported the condition to Audi dealer of Princeton NJ. The vehicle subsequently experienced two dead 12-volt battery incidents and became inoperable. The second 12 volt battery was new. Following the most recent incident, the Audi dealer diagnosed the Virtual Cockpit/instrument cluster as causing a drain on the 12-volt battery and recommended replacement at a cost of approximately $3,500. The replacement part is unavailable, and Audi has provided no estimated delivery date. The vehicle has remained out of service since July 03rd 2026. This condition presents a potential safety concern because failure of the instrument cluster may prevent the driver from reliably viewing speed, warning indicators, vehicle status, range, and other safety-related information. The recurring 12-volt battery discharge may also leave the vehicle unexpectedly disabled. The vehicle is additionally showing an indicated range of only approximately 160 miles at 100% charge. Audi has not established whether this is related to the instrument-cluster failure, high-voltage battery condition, battery-management system, software, or another electrical defect. Audi has not provided documentation of a comprehensive high-voltage battery health and capacity evaluation. Audi issued a recall or service campaign affecting other 2021 Audi vehicles for substantially similar Virtual Cockpit/display problems. However, Audi states that my VIN is excluded and has not provided a technical explanation identifying a different component, part number, software version, supplier, or failure mechanism. I request that NHTSA evaluate whether the recurring instrument-cluster failure and 12-volt battery discharge constitute a broader safety defect and whether the existing Audi recall or service-campaign population should include this car.

Moisture build-up in the high-voltage electrical system through a faulty seal on the charging socket, which can cause a short circuit and significantly increase the risk of a vehicle fire. If you get a warning light saying "electrical system: fault," you should stop driving immediately, park outdoors away from structures, and not charge the vehicle. Braking problems caused by sub-standard welding within the ABS rotor and shaft. High-voltage battery modules that may overheat, also increasing the risk of fire. An infotainment unit that can become internally damaged when the vehicle is shut off, resulting in an inoperative rearview camera display a federal safety standard violation. This clearly shows the vehicle was badly manufactured, during a chip shortage in 2020. This vehicle is a complete failure by Audi and puts so many innocent peoples lives at risk.

What component or system failed or malfunctioned, and is it available for inspection upon request? - While on highway the vehicle loosed all Power indicating Electrical Malfunction How was your safety or the safety of others put at risk? It happened on I-35 Freeway twice putting me in danger of 18 wheelers around me. I am afraid to be in the vehicle even if they return it to me. Based on records this issue has been present on the car since it rolled off manufacturing. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes and Dealer has reproduced it and has the car with them for 5 Plus months. Have replaced many components and are not able to resolve it. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? South Austin Audi Dealer has been working with Audi Corporate Technical team and have replaced 5 parts to no resolution. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Electrical Malfunction - Red light flashing to pull the care over to the emergency lane but there is no acceleration - you are left to depend on whatever momentum is left on the car. Based on records this issue has been present on the car since it rolled off manufacturing. Based on records this issue has been present on the car since it rolled off manufacturing.

Audi dealership charged fee for a repair that they the,selves acknowledged is under a technical service bulletin and despite my having extended warranty that is supposed to cover such repairs. This is for the main media interface going blank repeatedly every ~5 minutes or so while driving. Audi charged me for a repair that is a known safetyissue and is covered under warranty.

Tied with NHTSA Recall 25V900 - Review Camera Software. Dealer was unable to complete the recall due to internal malfunction of USB Interface on vehicle. Dealer quoted a non itemized Repair Estimate of $1,045.50 to replace the interface in order to be able to complete the open recall. No visible user caused damage to interface and prior Technical Support Bulletin (2066315) for issues with USB covering specific vehicle. Given the dependence on software within our vehicles, the USB interface used to perform required recall work should be covered when failure is internal to the interface module.

The vehicle's central locking system does not properly communicate with the keyfob resulting in the doors not unlocking as intended. I have had my child in the car seat in the back and if i accidentantly touch the handle the wrong way the doors will lock and I am unable to use the unlock feature to get my kid out. This could be a serious safety issue if someone becomes trapped in the rear seat and the central locking system does not allow unlocking of the doors.

The contact owns a 2021 Audi E-Tron. The contact received notification of NHTSA Campaign Number: 23V867000 (Electrical System). The part to do the recall repair was not yet available. The vehicle was taken to the dealer, where it was diagnosed, and determined that the battery module had failed and needed to be replaced. The dealer confirmed that parts were not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, and a case was opened. The contact had not experienced a failure.

On five separate occasions across two separate drivers, we have experienced a partial brake failure in this vehicle. We strongly believe this to be a software defect and not a mechanical fault. On the e-Tron, the first portion of the brake pedal swing typically activates the regenerative braking. About mid-way through pressing the pedal, it changes to "real" mechanical brakes. When this brake failure occurs, we get to that midway point and the car lets off the regenerative braking but does NOT apply the mechanical brakes, so the end result is that the more you press the brake pedal, the less it works. Three of these five occasions occurred in one day, so by the time the third time came around, I was really paying attention and I'm very confident this wasn't driver error. In at least one case, the only reason that a crash was avoided is because the automatic braking / forward collision system activated. The vehicle has been inspected by a dealer, who found "No Repairs Recommended". We requested an update to the ABS module software, as this software update is known to resolve multiple other problems with the braking system (see TSBs 2072977, 2061906) but we were denied the update.

The contact owns a 2021 Audi E-Tron. The contact received notification of NHTSA Campaign Number: 23V867000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.