IllustrationCONSUMER STATED WHILE TRAVELING ON WET ROADS THE BRAKES BECOME SOFT. ONCE DRY, THE BRAKES GRAB. *AK THE CONSUMER STATED THE FRONT AND REAR BRAKES WERE REPLACED SEVERAL TIMES. *JB
2001 Audi A6
Owner reports · Recalls · Investigations
More warning signs than most A6 years
Owner complaints for the 2001 Audi A6 are substantially higher than the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
1025–50K
1050–75K
1475–100K
18100–150K
3150K+
65 reports with mileage · 48 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
113 reportsTHIS IS IN REFERENCE TO THE AUDI RECALL REFERENCING REPLACEMENT OF TIRES TO MEET AXLE WEIGHT OF VEHICLE. NHTSA CAMPAIGN ID NO #03V143000.TIRES 225/45 R17 91Y WERE TO BE REPLACED BY 225/45 R17 94W. IN NOV 03 TOOK VEHICLE TO THE AUDI PHIL LONG DEALERSHIP IN COLORADO SPRINGS TO MEET COMPLIANCE PER RECALL LETTER. DEALERSHIP TOOK T…
Read full complaint
THIS IS IN REFERENCE TO THE AUDI RECALL REFERENCING REPLACEMENT OF TIRES TO MEET AXLE WEIGHT OF VEHICLE. NHTSA CAMPAIGN ID NO #03V143000.TIRES 225/45 R17 91Y WERE TO BE REPLACED BY 225/45 R17 94W. IN NOV 03 TOOK VEHICLE TO THE AUDI PHIL LONG DEALERSHIP IN COLORADO SPRINGS TO MEET COMPLIANCE PER RECALL LETTER. DEALERSHIP TOOK THE PERFORMANCE "ALL SEASON" TIRES OFF THE VEHICLE AND REPLACED THREE TIRES WITH 225/45 94W PERFORMANCE "SUMMER" TIRES AND ONE TIRE WITH A 225/45 91Y PERFORMANCE SUMMER TIRE. FIRST BY LOOKING AT THE SPECS OF THE TIRES THEY INSTALLED THEY PARTIALLY MET THE RECALL CRITERIA. SECONDLY, BY CHOOSING TO TAKE THE ORIGINAL PERFORMANCE "ALL SEASON" TIRES OFF THE VEHICLE IN THE PRESENT WINTER SEASON AND REPLACING THEM WITH A PERFORMANCE "SUMMER" TIRE WITHOUT TELLING ME (THE CONSUMER) OF THE TYPE OF TIRES THEY INSTALLED AND SENDING ME ON MY WAY ASSURING ME THAT MY SAFETY CONCERNS WITH THE RECALL HAD BEEN MET, BOTH AUDI USA, AND AUDI PHIL LONG DEALERSHIP CONFIGURED THE VEHICLE TO BE UNSAFE FOR NORMAL OPERATION. THE RECALL CRITERIA WAS NOT MET, ADDITIONALLY BY TAKING AWAY THE ALL SEASON TIRES AND REPLACING THEM WITH SUMMER TIRES IN WINTER SEASON WITHOUT ADVISING THE CONSUMER PRIOR TO RELEASING THE VEHICLE GENERATED A NEW HAZARD. AS A RESULT THE VEHICLE HANDLING CHARACTERISTICS CHANGED, VEHICLE DID NOT RESPOND AS DRIVER WAS ACCUSTOMED PRIOR TO RECALL, AND AS A RESULT DURING ICY ROAD CONDITIONS THE VEHICLE SLID AND SUFFERED DAMAGES. AUDI USA DOES NOT ACCEPT RESPONSIBILITY, NOR PHIL LONG DEALERSHIP. THE RECALL ATTEMPTED TO MEET ONE HAZARD, AND BY THE CHOICE OF TIRES CHOSEN AS REPLACEMENT WITHOUT CONSIDERATION OF VEHICLE LOCATION, AND FAILURE TO ADVISE CONSUMER OF REPLACEMENT TIRES SPECIFICATIONS AND LIMITATIONS GENERATED A GREATER HAZARD.*AK
2001 AUDI A6 WITH ALL ROUTINE MAINTENANCE HAD CHECK ENGINE LIGHT ON AND WAS TOLD IT WAS NOTHING TO WORRY ABOUT. A FEW WEEKS LATER THE ENGINE BASICALLY MELTED WITH OUT ANY WARNING. DEALER SAYS THE RADIATOR WAS FINE AND THE WAS NO OIL LEAK. ALL WIRES ARE MELTED ONTO THE ENGINE AND THE ENGINE IS RUINED. SUSPECT ELECTRICAL PROBLEM. …
Read full complaint
2001 AUDI A6 WITH ALL ROUTINE MAINTENANCE HAD CHECK ENGINE LIGHT ON AND WAS TOLD IT WAS NOTHING TO WORRY ABOUT. A FEW WEEKS LATER THE ENGINE BASICALLY MELTED WITH OUT ANY WARNING. DEALER SAYS THE RADIATOR WAS FINE AND THE WAS NO OIL LEAK. ALL WIRES ARE MELTED ONTO THE ENGINE AND THE ENGINE IS RUINED. SUSPECT ELECTRICAL PROBLEM. ONLY 2 YEARS OLD BUT OFF WARRANTY. DEALER OFFERS NOTHING AND AUDI OFFERS 4000 TOWARDS A NEW AUDI PURCHASE. A NET 37000 DOLLAR LOSS IN 2 YRS FOR ME. I WAS TOLD WHEN I PURCHASED THE CAR, IT WOULD EASILY GET 90000 TO 15000 MILES BY EVERY DEALER. THEY ARE COVERING UP AN ELECTRICAL DEFECT OR SEVERLY MISREPRESENTING THEIR PRODUCT. *AK
ACCORDING TO THE VEHICLE TIRE STICKER ON THE DRIVER'S DOOR THE TIRE PRESSURE SHOULD BE 46-PSI PER TIRE. THE DEALER TECHNICIAN STATED THAT THE MAXIMUM AIR PRESSURE SHOULD BE 44 PSI PER TIRE. WHEN THE CONSUMER CONTACTED THE MANUFACTURER THEY ASKED THE CONSUMER TO IGNORE THE STICKER AND INFLATE 34 PSI AIR PRESSURE PER TIRE. SEEK…
Read full complaint
ACCORDING TO THE VEHICLE TIRE STICKER ON THE DRIVER'S DOOR THE TIRE PRESSURE SHOULD BE 46-PSI PER TIRE. THE DEALER TECHNICIAN STATED THAT THE MAXIMUM AIR PRESSURE SHOULD BE 44 PSI PER TIRE. WHEN THE CONSUMER CONTACTED THE MANUFACTURER THEY ASKED THE CONSUMER TO IGNORE THE STICKER AND INFLATE 34 PSI AIR PRESSURE PER TIRE. SEEKING NHTSA HELP IN THIS MATTER. *AK *SCC *JB
ALL FOUR ORIGINAL TIRES WERE REPLACED BY THE CONSUMER AT 14,500 MILES. THE TIRE DEALER PROVIDED 50% ON THE SECOND SET OF TIRES AND AT 25,000 MILES, THE TIRES NEEDED TO BE REPLACED AGAIN. PIRELLI, SIZE# P225/55R17. *AK THE CONSUMER NOTICED THAT THE TIRES WERE NEARLY WORN WITH HARDLY ENOUGH TREAD REMAINING. (MODEL/ALL…
Read full complaint
ALL FOUR ORIGINAL TIRES WERE REPLACED BY THE CONSUMER AT 14,500 MILES. THE TIRE DEALER PROVIDED 50% ON THE SECOND SET OF TIRES AND AT 25,000 MILES, THE TIRES NEEDED TO BE REPLACED AGAIN. PIRELLI, SIZE# P225/55R17. *AK THE CONSUMER NOTICED THAT THE TIRES WERE NEARLY WORN WITH HARDLY ENOUGH TREAD REMAINING. (MODEL/ALLROAD) *SCC *JB
OWNER IS VERY UNHAPPY WITH THE ARRANGEMENTS THAT AUDI IS MAKING IN REFERENCE TO A RECALL INVOLVING TIRES WHICH ARE THE WRONG SIZE. DEALERSHIP IS ASKING OWNERS TO MAKE AN APPOINTMENT FIRST, COME IN AND LET THE DEALERSHIP VIEW THE TIRES, THEN ASK THEM TO LEAVE THE CAR FOR SEVERAL HOURS WHILE THEY ORDER THE TIRES TO REPLACE THOS…
Read full complaint
OWNER IS VERY UNHAPPY WITH THE ARRANGEMENTS THAT AUDI IS MAKING IN REFERENCE TO A RECALL INVOLVING TIRES WHICH ARE THE WRONG SIZE. DEALERSHIP IS ASKING OWNERS TO MAKE AN APPOINTMENT FIRST, COME IN AND LET THE DEALERSHIP VIEW THE TIRES, THEN ASK THEM TO LEAVE THE CAR FOR SEVERAL HOURS WHILE THEY ORDER THE TIRES TO REPLACE THOSE THAT WARRANT AN EXCHANGE. THERE IS NO COST TO THE CONSUMER. HOWEVER, TIME WISE IT IS AN INCONVENIENCE. *AK THE TIRES WERE BEING REPLACED. *SCC *JB
AUDI 2001 A6 2.7T TIPTRONIC WHILE IN D TRANSMISSION MODE, CAR DOES NOT ACCELERATE PER ACCELERATOR INPUT AFTER USING THE BRAKES. THERE IS A DELAY OF ABOUT A COUPLE OF SECONDS BEFORE CAR ACCELERATES. THIS HAPPENS AFTER BRAKING FROM LOW SPEEDS FOLLOWED BY GENTLE ACCELERATION AND ALSO WHEN BRAKING FROM HIGHER SPEEDS FOLLOWED BY…
Read full complaint
AUDI 2001 A6 2.7T TIPTRONIC WHILE IN D TRANSMISSION MODE, CAR DOES NOT ACCELERATE PER ACCELERATOR INPUT AFTER USING THE BRAKES. THERE IS A DELAY OF ABOUT A COUPLE OF SECONDS BEFORE CAR ACCELERATES. THIS HAPPENS AFTER BRAKING FROM LOW SPEEDS FOLLOWED BY GENTLE ACCELERATION AND ALSO WHEN BRAKING FROM HIGHER SPEEDS FOLLOWED BY EITHER GENTLE OR AGGRESSIVE ACCELERATION. OFTEN THERE WILL BE A PRONOUNCED JERK WHEN THE CAR STARTS TO ACCELERATE AFTER THE DELAY. *LA SAFETY ISSUE TYPICAL SITUATION: WHEN CROSSING MEDIANS TO MERGE WITH TRAFFIC IN THE OPPOSITE DIRECTION, ONCOMING TRAFFIC HAVE TO BRAKE HEAVILY TO AVOID A COLLISION BECAUSE THE CAR IS UNABLE TO ACCELERATE SMARTLY AFTER BRAKING. THE SAME CROSSING IN PREVIOUSLY OWNED AUDI A4 1.8T AND AUDI A4 2.8 (BOTH WITHOUT FLY BY WIRE THROTTLE) COULD BE SAFELY NEGOTIATED WITHOUT ANY ACCELERATION DELAY. THIS SITUATION IS UNACCEPTABLE AND HIGHLY DANGEROUS IN NORMAL EVERYDAY DRIVING. REFERENCES FROM AUDIWORLD.COM FORUMS IT IS APPARENT THAT THERE ARE MANY OWNERS EXPERIENCING THIS PROBLEM. ALL HAVE THE AUDI TIPTRONIC TRANSMISSION AND FLY BY WIRE THROTTLE SYSTEM, NOT LIMITED TO THE 2.7T MODEL. HERE IS THE LINK TO THE LATEST MESSAGES HTTP://FORUMS.AUDIWORLD.COM/A6/MSGS/304185.PHTML ALSO, CONSUMER REPORTS HAVE NOTED THE DELAY IN ACCELERATION WHEN TESTING THIS CAR. HERE IS THE LINK. HTTP://WWW.CONSUMERREPORTS.ORG/MAIN/DETAILV2.JSP?CONTENT%3C%3ECNT_ID=302773&FOLDER%3C%3EFOLDER_ID=97851&ASSORTMENT%3C%3EAST_ID=333137&BMUID=1066370138539 SEVERAL OTHER REVIEWS IN THE U.S. AUTOMOBILE PRESS HAVE ALSO NOTED THE DELAY. REPAIR LOCAL AUDI DEALER IS UNABLE TO OFFER A SOLUTION SINCE THEIR TROUBLESHOOTING TECHNIQUES ONLY INDICATE A "NO FAULT FOUND" OR "UNABLE TO DUPLICATE" SITUATION (SEVERAL VISITS). ESCALATION TO AUDI HEADQUARTERS ELICITS STATEMENTS SUCH AS "WORKING AS PER DESIGN, "SAFETY FEATURE (PREVENT OVER REVVING DAMAGE TO ENGINE/TRANSMISSION)", AND "SYSTEM HAS TO PROCESS A LOT OF DATA". *LA
DURING INCLEMENT WEATHER DRIVER MUST PUMP THE BRAKE PEDAL TO STOP THE VEHICLE. ALSO, THE BRAKES GRAB IN THE REAR. DEALER REPLACED THE BRAKES FOUR TIMES, BUT PROBLEM STILL EXISTS. *AK
I HAVE A 2001 AUDI A6 2.7T AND IT HAS ALMOST CAUSED ME TO GET INTO SEVERE ACCIDENTS WHERE I WOULD HAVE BEEN SERIOUSLY INJURED OR KILLED IN A SIDE IMPACT COLLISION. THE CULPRIT IS THIS: IF YOU DEPRESS THE BRAKE (AS IF YOU WERE STOPPING OR COMING TO A COMPLETE STOP) AND TRY TO REACCELERATE, THERE IS LITTLE TO NO ACCELERATION. THIS…
Read full complaint
I HAVE A 2001 AUDI A6 2.7T AND IT HAS ALMOST CAUSED ME TO GET INTO SEVERE ACCIDENTS WHERE I WOULD HAVE BEEN SERIOUSLY INJURED OR KILLED IN A SIDE IMPACT COLLISION. THE CULPRIT IS THIS: IF YOU DEPRESS THE BRAKE (AS IF YOU WERE STOPPING OR COMING TO A COMPLETE STOP) AND TRY TO REACCELERATE, THERE IS LITTLE TO NO ACCELERATION. THIS "HESITATION" HAS ALMOST GOT ME KILLED SEVERAL TIMES. THERE ARE HUNDREDS OF OTHER AUDI A6 CONSUMERS REGARDLESS OF MODEL ENGINE (2.8, 2.7T, 3.0 AND 4.2) THAT HAVE EXPERIENCED THIS PROBLEM. THUS, IT IS UNACCEPTABLE FOR AUDI USA TO SAY THIS IS "NORMAL" AND "INHERENT IN THE OPERATION OF TURBOCHARGERS" AS THIS IS WHAT THEY HAVE TOLD ME BEFORE WHILE THE CAR WAS BEING SERVICED. ALTHOUGH I DO UNDERSTAND THAT TURBOCHARGERS CREATE WHAT IS DEEMED AS "TURBO LAG" ON ACCELERATION, I EXPERIENCE MAJOR DELAYS IN ANY ACCELERATION IMMEDIATELY AFTER I HAVE DEPRESSED THE BRAKE (AT ANY SPEED) AND THEN TRY TO REACCELERATE. THIS IS A SERIOUS ISSUE AND NEEDS TO BE FIXED OR REMEDIED IMMEDIATELY. PLEASE SEE THE POSTING AT AUDIWORLD (THE LARGEST ONLINE FORUM FOR AUDI OWNERS). HERE IS THE POST URL: HTTP://FORUMS.AUDIWORLD.COM/A6/MSGS/304185.PHTML . *LA
VEHICLE EXHIBITS DELAY FROM A STOP WHEN DEPRESSING THE GAS PEDAL. VERY DANGEROUS WHEN CROSSING ONCOMING TRAFFIC. *LA
Official recalls
711V267000 · Fuel System, Other:storage:tank Assembly
May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
08V157000 · Fuel System, Gasoline:storage:tank Assembly
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
03V143000 · Tires
Apr 7, 2003
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.7L ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE CALCULATED "VEHICLE NORMAL LOAD" EXCEEDS THE ALLOWABLE WEIGHT OF THE AXLE LOAD WITH TIRE DIMENSION 225/45R 17 91Y BY 19KG.
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN ON SEPTEMBER 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-800-822-2834.
01V202000 · Visibility:windshield Wiper/washer
Jun 18, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES (ALLROAD). WHEN ACTIVATING THE WINDSHIELD WIPER UNDER HEAVY LOAD CONDITIONS SUCH AS FREEZING, SNOW OR HEAVY RAIN, ONE WIPER COULD BE DELAYED BEHIND THE OTHER WIPER.
Consequence & remedy
Consequence: IF THAT HAPPENS, THE WIPER BLADES, BECAUSE THEY OVERLAP WIPING AREAS, COULD BECOME ENTANGLED WITH EACH OTHER AND CEASE FUNCTIONING. THIS COULD IMPAIR THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL REPLACE THE ENTIRE DRIVER SIDE WIPER ARM. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
01V157000 · Fuel System, Gasoline:storage:tank Assembly
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
PE02008 · Brake And Clutch Pedal Bracket
Opened Jan 23, 2002 · Closed Jul 12, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.