IllustrationTHE FUEL GAUGE WAS DEFECTIVE, IT READ HALF A TANK WHEN IT WAS REALLY EMPTY. CONSUMER RAN OUT OF GAS ON A BUSY HIGHWAY. VEHICLE WAS SERVICED BY THE DEALER. UNDER THE CERTIFICATION PROGRAM THE DEFECT SHOULD HAVE BEEN FOUND. *AK *TC
2001 Audi A6
Owner reports · Recalls · Investigations
More warning signs than most A6 years
Owner complaints for the 2001 Audi A6 are substantially higher than the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
1025–50K
1050–75K
1475–100K
18100–150K
3150K+
65 reports with mileage · 48 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
113 reportsI NOTICED THAT MY FUEL GAUGE WAS INCORRECT. I TOOK CAR TO THE DEALER AND WAS TOLD THERE WAS A BAD FUEL SENDER UNIT. THE REPAIR WAS ESTIMATED TO COST $1000. I TOOK THE CAR TO AN INDEPENDENT MECHANIC WHO CONFIRMED THE PROBLEM BUT TOLD ME THERE HAD BEEN A RECALL ON THE CAR FOR THIS PROBLEM. HE GAVE ME A PRINTOUT OF THE RECALL NOTI…
Read full complaint
I NOTICED THAT MY FUEL GAUGE WAS INCORRECT. I TOOK CAR TO THE DEALER AND WAS TOLD THERE WAS A BAD FUEL SENDER UNIT. THE REPAIR WAS ESTIMATED TO COST $1000. I TOOK THE CAR TO AN INDEPENDENT MECHANIC WHO CONFIRMED THE PROBLEM BUT TOLD ME THERE HAD BEEN A RECALL ON THE CAR FOR THIS PROBLEM. HE GAVE ME A PRINTOUT OF THE RECALL NOTICE, WHICH HAD BEEN ISSUED IN 2001. I SPOKE WITH AUDI OF AMERICA AND WAS TOLD THAT I WOULD HAVE TO CONFIRM WITH THE DEALER THAT THIS RECALL WORK HAD BEEN DONE ON MY CAR. IN THE DATABASE, THE DEALER FOUND THAT MY CAR HAD BEEN CHECKED FOR THIS PROBLEM IN SEPT 2001 (BEFORE I PURCHASED IT) AND IT HAD BEEN DETERMINED THAT NO ACTION WAS NECESSARY. I SPOKE AGAIN WITH AUDI OF AMERICA AND AFTER THEIR REPRESENTATIVE HAD "RESEARCHED" THE ISSUE, I WAS TOLD THAT THE CORRECT FUEL SENDING UNIT MUST HAVE BEEN IN MY CAR OR THEY WOULD HAVE REPLACED IT. SO I AM LEFT WITH A NONFUNCTIONING FUEL GAUGE AND NO HELP FROM AUDI ON FIXING THIS SAFETY PROBLEM.
CONSUMER STATED VIA E-MAIL I FUMANI SHISANA WHILE DRIVING ON JUNE 3 2004 HIT A PATCH OF WATER IN THE ROAD. VEHICLE STARTED SLIDING FROM SIDE TO SIDE UNCONTROLLABLY. TRIED TO REGAIN CONTROL OF THE VEHICLE AND IT SLID OFF THE ROAD ONTO THE GRASS ON DRIVER'S SIDE. CONSUMER REMOVED SAFETY BELT AND JUMPED OUT OF THE FRONT PASSENG…
Read full complaint
CONSUMER STATED VIA E-MAIL I FUMANI SHISANA WHILE DRIVING ON JUNE 3 2004 HIT A PATCH OF WATER IN THE ROAD. VEHICLE STARTED SLIDING FROM SIDE TO SIDE UNCONTROLLABLY. TRIED TO REGAIN CONTROL OF THE VEHICLE AND IT SLID OFF THE ROAD ONTO THE GRASS ON DRIVER'S SIDE. CONSUMER REMOVED SAFETY BELT AND JUMPED OUT OF THE FRONT PASSENGER'S DOOR. UPON IMPACT, NONE OF THE AIR BAGS DEPLOYED. WHILE REACHING INTO THE VEHICLE TO RETRIEVE CELLULAR PHONE CONSUMER NOTICED FLAMES EMERGING FROM THE FRONT PASSENGER SIDE INDICATOR LIGHT. THEN, VEHICLE WAS ENGULFED IN FLAMES. CONSUMER NARROWLY ESCAPED WITH HIS LIFE. REPORTED INCIDENT TO THE POLICE AND VOLKSWAGEN AUDI. VOLKSWAGEN AUDI SEEMED TO ACT QUIT SLOWLY ON TAKING ACTION TO RECTIFY THE SITUATION. *AK
PROBLEMS WITH TRANSMISSION FAILURE. *MR THE DRAIN HOLES WERE NOT APART OF THE 20K MILES MAINTENANCE. THE CONSUMER LEARNED THAT THE PLENUM CHAMBER COVER SHOULD HAVE BEEN REMOVED DURING MAINTENANCE AT WHICH TIME ANY EVIDENCE OF DEBRIS WOULD HAVE BEEN OBVIOUS TO THE TECHNICIAN. THE PROBLEM WAS DUE TO WATER DAMAGE UNDER THE C…
Read full complaint
PROBLEMS WITH TRANSMISSION FAILURE. *MR THE DRAIN HOLES WERE NOT APART OF THE 20K MILES MAINTENANCE. THE CONSUMER LEARNED THAT THE PLENUM CHAMBER COVER SHOULD HAVE BEEN REMOVED DURING MAINTENANCE AT WHICH TIME ANY EVIDENCE OF DEBRIS WOULD HAVE BEEN OBVIOUS TO THE TECHNICIAN. THE PROBLEM WAS DUE TO WATER DAMAGE UNDER THE COWL, WHICH DESTROYED THE TRANSMISSION COMPUTER. *SC *JB
SINCE I BOUGHT MY CAR IN 2001, I'VE HAD NUMEROUS PROBLEMS WITH THE BRAKES. WITHIN THE FIRST 4 MONTHS, MY ROTORS WARPED. THEY'VE WARPED TWICE SINCE THAT TIME. ALSO, EVERY 4 MONTHS OR SO, I HAVE TO TAKE MY CAR IN TO HAVE THE BRAKES RESURFACED. I'VE BEEN TOLD THAT I HAVE TO BRAKE AGGRESSIVELY RATHER THAN SLOW TO A STOP. SO, I'VE …
Read full complaint
SINCE I BOUGHT MY CAR IN 2001, I'VE HAD NUMEROUS PROBLEMS WITH THE BRAKES. WITHIN THE FIRST 4 MONTHS, MY ROTORS WARPED. THEY'VE WARPED TWICE SINCE THAT TIME. ALSO, EVERY 4 MONTHS OR SO, I HAVE TO TAKE MY CAR IN TO HAVE THE BRAKES RESURFACED. I'VE BEEN TOLD THAT I HAVE TO BRAKE AGGRESSIVELY RATHER THAN SLOW TO A STOP. SO, I'VE TRIED THAT. THE BREAKS STILL WARP AND NEED RESURFACING MORE OFTEN THAN THEY SHOULD. I'VE BEEN TOLD BY TWO MECHANICS AT TWO DIFFERENT DEALERSHIPS THAT THIS IS A KNOWN PROBLEM WITH SOME, BUT NOT ALL, AUDI A6 2.7 TURBOS AND 4.0'S (8 CYLINDER VERSION). THEY'VE SAID THAT THE TECHNICAL PEOPLE KNOW THERE'S A PROBLEM, BUT CORPORATE KEEPS DENYING IT. THE LAST MECHANIC SAID THERE ARE SOME THINGS THEY CAN DO TO TRY TO HELP THE PROBLEM, BUT THEY'RE NOT GUARANTEED TO WORK. NONE OF THE FIXES INCLUDED USING THICKER OR BETTER BRAKES, WHICH EVIDENTLY ARE AVAILABLE AT A HIGH COST! SOME OF THE TWEAKS THEY CAN DO INCLUDE PRECISION BALANCING OF THE TIRES AND MAKING THE SUSPENSION EVEN TIGHTER THAN IT ALREADY IS. *JB
WHILE DRIVING 50 MPH IN A RAIN STORM VEHICLE SWERVED AND LOST CONTROL, CAUSING IT TO CRASH HEAD ON INTO A WALL. UPON IMPACT, NONE OF THE SIX AIR BAGS DEPLOYED. TWO WEEKS LATER, CONSUMER RECEIVED A RECALL NOTICE FOR THE AIR BAG ELECTRICAL SYSTEM. DRIVER SUSTAINED NECK AND BACK INJURIES. *AK
WHILE DRIVING IN VERY COLD SNOWY WEATHER MY AIRBAG LIGHT FLASHED THEN STAYED ON. THIS OCCURRED 3 TIMES DURING THE WINTER MONTHS AND HAS NOT REOCCURRED DURING WARMER MONTHS. AFTER TURNING OFF THE CAR THE LIGHT WENT OFF. ACCORDING TO THE DRIVERS MANUAL THE AIRBAGS WILL NOT DEPLOY WITH LIGHT ON. ACCORDING TO ODI 756137 WITH SAME SY…
Read full complaint
WHILE DRIVING IN VERY COLD SNOWY WEATHER MY AIRBAG LIGHT FLASHED THEN STAYED ON. THIS OCCURRED 3 TIMES DURING THE WINTER MONTHS AND HAS NOT REOCCURRED DURING WARMER MONTHS. AFTER TURNING OFF THE CAR THE LIGHT WENT OFF. ACCORDING TO THE DRIVERS MANUAL THE AIRBAGS WILL NOT DEPLOY WITH LIGHT ON. ACCORDING TO ODI 756137 WITH SAME SYMPTOMS INDICATES NO AIRBAG WILL FUNCTION EVEN WITH AIRBAG LIGHT OUT AFTER THE INTERMITTENT LIGHT FLASHING. I TOOK IT TO THE DEALER 2 TIMES, BUT COULD NOT DETERMINE PROBLEM AND WOULD NOT REPLACE ANYTHING. DEALER TOLD ME UNLESS THERE IS A SOLID FAILURE OR THEY CAN DUPLICATE IT THEY COULD NOT FIX IT. CAR IS STILL UNDER WARRANTY AND FEEL LIKE I HAVE BEEN GETTING RUN AROUND. CALLED AUDI CUSTOMER SERVICE (REF# 40192796), BUT HAVE NOT HEARD ANYTHING. *AK
THERE APPEARS TO BE A POSSIBLE DESIGN DEFECT THAT I BELIEVE MERITS REPORTING AND POSSIBLE INVESTIGATION. I HAVE 2001 AUDI A6. THE REPLACEMENT OF THE OIL FILTER AT A JIFFY LUBE RESULTED IN DAMAGE TO THE OIL COOLER WHICH CAUSE ME TO SUFFER A $800 PLUS REPAIR BILL AT THE DEALER. THE DEALER TECHNICIAN ADVISED JIFFY LUBE THAT THEY AR…
Read full complaint
THERE APPEARS TO BE A POSSIBLE DESIGN DEFECT THAT I BELIEVE MERITS REPORTING AND POSSIBLE INVESTIGATION. I HAVE 2001 AUDI A6. THE REPLACEMENT OF THE OIL FILTER AT A JIFFY LUBE RESULTED IN DAMAGE TO THE OIL COOLER WHICH CAUSE ME TO SUFFER A $800 PLUS REPAIR BILL AT THE DEALER. THE DEALER TECHNICIAN ADVISED JIFFY LUBE THAT THEY ARE AWARE OF THE POTENTIALITY OF PROBLEMS IN REPLACEMENT OF THE OIL FILTER AND AS RESULT HAVE ONE MECHANIC SECURE THE COOLER WITH CHANNEL LOCKS WHILE THE OTHER REMOVES THE OIL FILTER. THERE ARE NO PRESENT WARNINGS FOR SHOPS OF THIS METHOD TO ASSURE NO DAMAGE TO THE OIL COOLER. I PRESENTED A B.A.R. COMPLAINT IN CA. AND TOOK UP A SMALL CLAIMS ACTION FOR RECOVERY, JIFFY LUBE STEPPED UP BUT AUDI REFUSES AND DENIES ANY POSSIBLE DESIGN FLAW IN THEIR VEHICLE. AS A CONSUMER I CANNOT UNDERSTAND HOW IT SHOULD REQUIRE TWO TECHNICIANS TO REMOVE AND REPLACE AN OIL FILTER.*AK
CONSUMER REPAIRED THE TIRES DUE TO RECALL. THE MANUFACTURER STATED THEY WON'T REIMBURSE FOR THE REPLACEMENT TIRE BECAUSE THE DAMAGE OCCURRED PRIOR TO 12/16/2002. THE MANUFACTURER ALSO SAID THAT IT WAS THE DATE GIVEN BY NHTSA. *LA THE CONSUMER STATED THE TIRE RUPTURED WHILE DRIVING AND APPARENTLY THE SIDE OF THE TIRE FAILED A…
Read full complaint
CONSUMER REPAIRED THE TIRES DUE TO RECALL. THE MANUFACTURER STATED THEY WON'T REIMBURSE FOR THE REPLACEMENT TIRE BECAUSE THE DAMAGE OCCURRED PRIOR TO 12/16/2002. THE MANUFACTURER ALSO SAID THAT IT WAS THE DATE GIVEN BY NHTSA. *LA THE CONSUMER STATED THE TIRE RUPTURED WHILE DRIVING AND APPARENTLY THE SIDE OF THE TIRE FAILED AND SUDDEN PRESSURE LOST CAUSED THE WHEEL TO COME IN DIRECT CONTACT WITH THE PAVEMENT, THE TIRE AND THE WHEEL HAD TO BE REPLACED. *JB
CONSUMER EXPERIENCE THREE TIRE CHANGES WITHIN THE FIRST YEAR OF THE LEASE.*PR TWO TIRE BLOW OUTS OCCURRED WITH MXV4 TIRE EQUIPMENT.*MR
Official recalls
711V267000 · Fuel System, Other:storage:tank Assembly
May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
08V157000 · Fuel System, Gasoline:storage:tank Assembly
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
03V143000 · Tires
Apr 7, 2003
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.7L ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE CALCULATED "VEHICLE NORMAL LOAD" EXCEEDS THE ALLOWABLE WEIGHT OF THE AXLE LOAD WITH TIRE DIMENSION 225/45R 17 91Y BY 19KG.
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN ON SEPTEMBER 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-800-822-2834.
01V202000 · Visibility:windshield Wiper/washer
Jun 18, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES (ALLROAD). WHEN ACTIVATING THE WINDSHIELD WIPER UNDER HEAVY LOAD CONDITIONS SUCH AS FREEZING, SNOW OR HEAVY RAIN, ONE WIPER COULD BE DELAYED BEHIND THE OTHER WIPER.
Consequence & remedy
Consequence: IF THAT HAPPENS, THE WIPER BLADES, BECAUSE THEY OVERLAP WIPING AREAS, COULD BECOME ENTANGLED WITH EACH OTHER AND CEASE FUNCTIONING. THIS COULD IMPAIR THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL REPLACE THE ENTIRE DRIVER SIDE WIPER ARM. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
01V157000 · Fuel System, Gasoline:storage:tank Assembly
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
PE02008 · Brake And Clutch Pedal Bracket
Opened Jan 23, 2002 · Closed Jul 12, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.