2018 Alfa Romeo Stelvio

I experienced an unexpected Loss of Motive Power (LOMP) event. Late afternoon traffic was fast, estimate 75-80 MPH. I attempted to change lanes get to the righthand shoulder and was very nearly involved in a high-speed collision with a semi-petroleum tank truck. He applied his brakes to avoid hitting me and started to jackknife, but regained control and continued. The truck missed by inches. At this point I had NO remaining power and was essentially coasting until I managed to cross the remaining two lanes of traffic to the shoulder emergency lane. I reset the error codes and continued home with no further occurrences. The incident produced the following warning lamps: Electronic Throttle Control Failure, Start/Stop System Failure and Check Engine, then a few seconds later the Limp Mode/LOMP event. I carry an OBD Scanning Tool with me to be able to clear the error codes when I encounter them. They are typically a cascading event that can result in LOMP. I have experienced a total of 26 of these error lamp events since 4/19/22 which have resulted in 3 LOMP's. The remaining 23 events I was able to reset before the inevitable LOMP. This is the first LOMP that nearly caused a fatal accident, the remainder I was able to safely find a place to stop to perform the resets. There is an active Manufacturer Recall Number93C, NHTSA Recall Number25V-586 that may cover this issue. The Recall Status is "Incomplete, remedy not yet available." The Alfa Romeo dealership has noted the P0191-00 error and replaced the fuel pressure sensor on 2/23/23, but this did not solve the problem. Owner's forums, and now the Manufacturer/NHTSA recall have reported this as a known problem, so I have been clearing my own error codes in order to at least have a car to drive. In my mind, this nuisance has now become a potentially very dangerous condition.

The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while the vehicle was parked, the vehicle was started and was shaking abnormally with the check engine warning light illuminated. The vehicle then shut off unexpectedly. The vehicle was towed to an independent mechanic where it was diagnosed with fuel pump failure. The contact was informed that the failure was caused by an unrepaired recall. The vehicle was not repaired. The contact was informed that parts were not available for the repair. The dealer was made aware of the failure, and the contact was informed that parts were not available for the repair. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part for the recall repair was unavailable. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 93,200.

The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2018 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at various speeds and attempting to accelerate, the vehicle hesitated before accelerating. The dealer was contacted and informed of the failure. The dealer confirmed that there was no fix available for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was 60,545.

November 26th my car went into LOMP mode. But then restored itself. December 3rd my car went into LOMP mode again and had not recovered along with a slew of ALARMS. I have been using uber and rental cars since this issue. Highly likely this is a fuel pump issue but unable to determine as the authorized shop is 2hours away and the car will not make it there. I need a remedy I have been out of a car for months now and the recall has no remedy!

The contact's father owns a 2018 Alfa Romeo Stelvio. The owner received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact expressed safety concerns because the owner was an elderly cancer patient. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue, and the contact requested a special circumstance review for vehicle rental assistance based on the owner's condition; however, the claim was denied. The vehicle owner had not experienced a failure.

Subject: Safety Complaint – Open Recall with No Remedy Available I am filing a safety complaint regarding my vehicle, which currently has an open recall with no available remedy. Manufacturer Recall Number: 93C NHTSA Recall Number: 25V-586 VIN: [XXX] After learning about this recall, I have experienced the exact issues described. When the vehicle is exposed to very hot or very cold temperatures, the Electronic Throttle Control (ETC) warning light illuminates, along with the check engine light and the auto stop-start warning light. When this occurs, the vehicle begins to sputter and loses power. It will not properly a-ccelerate and significantly reduces speed while driving. This creates a serious safety hazard, especially in traffic or at highway speeds. A sudden loss of power or inability to accelerate could easily result in a collision, potentially causing serious injury or death. There is currently no remedy available for this recall, yet the vehicle remains in operation on public roads. I do not feel the vehicle is safe to drive under these conditions. I am requesting that NHTSA investigate this issue further and require the manufacturer to provide an immediate and effective remedy. Owners should not be placed in a position where they must operate an unsafe vehicle while waiting for a repair solution. Thank you for your attention to this matter. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

It's well known by Alfa Romeo/Chrystler, Stelvio owners and certified Alfa Romeo mechanics that the O-ring in the oil send/receive/turbo lines is faulty. Spewing oil into the engine compartment and engine components and accessories i.e., belts, brake components creating a major liability for Alfa Romeo. The smoke from burning oil is overwhelming and visible inside the cabin throughout the interior of this car. THIS IS A MAJOR SAFETY HAZARD TO ALL ALFA ROMEO STELVIO OWNERS WITH THE 2018 MODEL.

I am submitting this complaint due to ongoing unresolved safety issues with my 2018 Alfa Romeo Stelvio, VIN: ZASFAKAN6J7B95955. The vehicle has an open and unresolved safety recall under Recall Number 25V-586 / Manufacturer Recall 93C relating to the fuel delivery module (FDM), which poses a risk of engine shutdown and potential crash without warning. According to the notice, no remedy is currently available, yet I continue to experience serious electrical problems that align with the warning signs outlined. Specifically, my headlights have been flickering on and off while driving, creating hazardous conditions—this occurred again as recently as January 26, 2026. These issues are not isolated. I have evidence via Carfax history that the vehicle had documented electrical problems dating back to 2019. Despite notifying FCA (now Stellantis) and being offered a low-value settlement ($4,000), I formally rejected that offer due to the unresolved safety risks, recall status, and prior documented issues. A copy of the official recall letter from FCA US LLC and NHTSA status (marked “Recall Incomplete, remedy not yet available”) are attached. At this time, I’m pursuing legal action under California’s Lemon Law and request that this complaint be recorded and escalated as this vehicle continues to pose a serious safety risk on public roads.