2018 Alfa Romeo Stelvio

NHTSA safety recall 25V-586 was issued on September 9, 2025. It has now been eight months without a resolution from the manufacturer, and per the FCA recall notice (accessed at [XXX] ) "The Fuel Delivery Module (FDM) on your vehicle may contain internal parts that can be affected by heat, which can reduce fuel flow and lead to a loss of drive power while driving. A loss of drive power can cause a vehicle crash without prior warning." This is a critical safety issue and the lengthy delay in providing a remedy puts lives at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I experienced an unexpected Loss of Motive Power (LOMP) event. Late afternoon traffic was fast, estimate 75-80 MPH. I attempted to change lanes get to the righthand shoulder and was very nearly involved in a high-speed collision with a semi-petroleum tank truck. He applied his brakes to avoid hitting me and started to jackknife, but regained control and continued. The truck missed by inches. At this point I had NO remaining power and was essentially coasting until I managed to cross the remaining two lanes of traffic to the shoulder emergency lane. I reset the error codes and continued home with no further occurrences. The incident produced the following warning lamps: Electronic Throttle Control Failure, Start/Stop System Failure and Check Engine, then a few seconds later the Limp Mode/LOMP event. I carry an OBD Scanning Tool with me to be able to clear the error codes when I encounter them. They are typically a cascading event that can result in LOMP. I have experienced a total of 26 of these error lamp events since 4/19/22 which have resulted in 3 LOMP's. The remaining 23 events I was able to reset before the inevitable LOMP. This is the first LOMP that nearly caused a fatal accident, the remainder I was able to safely find a place to stop to perform the resets. There is an active Manufacturer Recall Number93C, NHTSA Recall Number25V-586 that may cover this issue. The Recall Status is "Incomplete, remedy not yet available." The Alfa Romeo dealership has noted the P0191-00 error and replaced the fuel pressure sensor on 2/23/23, but this did not solve the problem. Owner's forums, and now the Manufacturer/NHTSA recall have reported this as a known problem, so I have been clearing my own error codes in order to at least have a car to drive. In my mind, this nuisance has now become a potentially very dangerous condition.

November 26th my car went into LOMP mode. But then restored itself. December 3rd my car went into LOMP mode again and had not recovered along with a slew of ALARMS. I have been using uber and rental cars since this issue. Highly likely this is a fuel pump issue but unable to determine as the authorized shop is 2hours away and the car will not make it there. I need a remedy I have been out of a car for months now and the recall has no remedy!

I am submitting this complaint due to ongoing unresolved safety issues with my 2018 Alfa Romeo Stelvio, VIN: ZASFAKAN6J7B95955. The vehicle has an open and unresolved safety recall under Recall Number 25V-586 / Manufacturer Recall 93C relating to the fuel delivery module (FDM), which poses a risk of engine shutdown and potential crash without warning. According to the notice, no remedy is currently available, yet I continue to experience serious electrical problems that align with the warning signs outlined. Specifically, my headlights have been flickering on and off while driving, creating hazardous conditions—this occurred again as recently as January 26, 2026. These issues are not isolated. I have evidence via Carfax history that the vehicle had documented electrical problems dating back to 2019. Despite notifying FCA (now Stellantis) and being offered a low-value settlement ($4,000), I formally rejected that offer due to the unresolved safety risks, recall status, and prior documented issues. A copy of the official recall letter from FCA US LLC and NHTSA status (marked “Recall Incomplete, remedy not yet available”) are attached. At this time, I’m pursuing legal action under California’s Lemon Law and request that this complaint be recorded and escalated as this vehicle continues to pose a serious safety risk on public roads.

I received a manufacturer recall notice (Recall 93C / NHTSA 25V-586) for my 2021 Alfa Romeo Giulia concerning a defective rear fuel line quick connector that may leak fuel and cause an engine compartment fire. I contacted Alfa Romeo of Brandon (FL) several times to schedule an inspection and request a temporary vehicle as recommended by FCA. My service advisor, Lenny Patram, confirmed that the remedy is not yet available and advised me to wait for further notice. Despite expressing safety concerns, I was told that no loaner or temporary vehicle could be provided. This situation puts my safety and the safety of others at risk. The recall notice specifically warns that a fuel leak could lead to a fire, yet I have been advised to continue parking the vehicle outside and avoid driving it if possible. I rely on this vehicle for daily transportation and have not been offered any safe alternative or clear timeframe for repair. In addition to the recall, my check engine light has been on for several weeks, and the “A!” warning light appears intermittently. These indicators began appearing after I received the recall notice and may be related to the same underlying defect. The dealer has not inspected the vehicle because parts are unavailable. The issue has not been reviewed by the manufacturer, insurance, or any third party. The vehicle is currently at my residence and available for inspection upon request. Warning lights prior to failure: Yes — check engine light and “A!” warning. Reproduced/confirmed by dealer: No — recall acknowledged but not inspected. Component available for inspection: Yes.

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The low-pressure fuel pump (fuel delivery module) appears to be failing, consistent with Recall 25V-586 / Alfa Romeo Campaign 93C. This causes fuel starvation and loss of motive power. 2. How was your safety or the safety of others put at risk? The vehicle has experienced loss of motive power (LOMP) while driving. At times it jerks or hesitates when accelerating from a stop, and while climbing a hill it suddenly lost power, displayed a Service Electronic Throttle warning, and went into limp mode. This created a risk of being unable to accelerate safely in traffic, increasing the chance of being rear-ended or unable to merge. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. I described the symptoms to Alfa Romeo Service dept, and they told me it is related to the recall and that other customers have reported the same symptoms and warning lights. However, they advised that there is currently no remedy available, and I must wait for the fix before scheduling an appointment. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not yet. Alfa Romeo advised that no remedy is available at this time, so the vehicle has not been formally inspected by the dealer or manufacturer. Advised not to drive long distances until fix determined. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Check Engine Light and Service Electronic Throttle came on as car lost power and entered limp mode with code P0299. Alfa Romeo Service Dept tech said these warnings match the recall. Rep said this shows how loss of motive power from fuel starvation manifests electronically & ECU interprets fuel starvation as underboost, which then triggers limp mode.

With temperatures around 90 degrees and engine is up to temperature the engine just stopped in the middle of the road blocking traffic This also happened 2 additional times and wouldn’t start for about 45 minutes. Recently paid $2,000 to replace the fuel pump and controller at a dealership. They told me there was no recall Had to wait 4 weeks for parts and didn’t know if they fixed the problem as there have not been any 90 degree days since the repair was done

2018 Stelvio Quad 7/2025 Taking off from a red light with multiple cars behind and beside me, my car lost power throwing multiple warning lights, swapped itself from "D" to "N" driving mode and had to be limped off the road and restarted. It would not swap modes from "N". Displayed "check engine light. Contacted my service manager, completed 10 restarts, issues cleared. Car would drive in all modes without issue. 2 weeks later having had no issues and assuming bad fuel, at the same light I was nearly rear ended because it did the same thing as before. There is a barrier to the left lane and I could not get my car out of the road. People were flying around, honking and yelling. After traffic cleared I was able to restart the vehicle. Called my service manager. 10 restarts cleared it and scheduled to bring it to Knoxville the next day. Obd reading indicated fuel starvation and delivery issues. The next day the dealership could not find an issue with the car. I took it home and drove it 2 more weeks without any issues until unfortunately, traveling about 70mph on the highway the lights came on again, same issue and lost power nearly causing an accident. Called the service manager. 10 restarts to clear it and drove it to the dealership about 100 miles away the next day using back roads to avoid the freeway. About 40 miles from the service center, it died while traveling about 30mph but thankfully, there were no other vehicles near me at that time and I was unfortunately prepared for the possibility. Once at the service center, it was determined that the fuel pump needed to be replaced and I paid significant money to have this part ordered and installed. I was without my car for about a week however this dealership does provide a loaner. I had the car back since mid August without any further issue - until last week, on start giving me the same dash warning lights, unable to swap from "N" mode. Called the service center and the coil pack was replaced yesterday.