2018 Alfa Romeo Stelvio

The contact owns a 2018 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. In addition, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was taken to an Auto Zone, where it was diagnosed, and DTC: P008A (Low-pressure fuel system pressure is too low) was retrieved. The vehicle was not repaired. The dealer was made aware of the failure. The contact was waiting for an available service appointment. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The low-pressure fuel pump (fuel delivery module) appears to be failing, consistent with Recall 25V-586 / Alfa Romeo Campaign 93C. This causes fuel starvation and loss of motive power. 2. How was your safety or the safety of others put at risk? The vehicle has experienced loss of motive power (LOMP) while driving. At times it jerks or hesitates when accelerating from a stop, and while climbing a hill it suddenly lost power, displayed a Service Electronic Throttle warning, and went into limp mode. This created a risk of being unable to accelerate safely in traffic, increasing the chance of being rear-ended or unable to merge. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. I described the symptoms to Alfa Romeo Service dept, and they told me it is related to the recall and that other customers have reported the same symptoms and warning lights. However, they advised that there is currently no remedy available, and I must wait for the fix before scheduling an appointment. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not yet. Alfa Romeo advised that no remedy is available at this time, so the vehicle has not been formally inspected by the dealer or manufacturer. Advised not to drive long distances until fix determined. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Check Engine Light and Service Electronic Throttle came on as car lost power and entered limp mode with code P0299. Alfa Romeo Service Dept tech said these warnings match the recall. Rep said this shows how loss of motive power from fuel starvation manifests electronically & ECU interprets fuel starvation as underboost, which then triggers limp mode.

Description of the Problem: While operating the vehicle, multiple warning lights illuminated including the Electronic Stability Control (ESC) warning light, the check engine light, and other unknown warning indicators. In addition, several warning messages were displayed, including “Service Engine Soon” and other unknown messages. When this occurs, the vehicle begins to overheat, the auto start/stop function becomes disabled, and the vehicle loses power and will not accelerate as expected. Component or System Failed / Malfunctioned: The exact component is unknown at this time. The failure appears to be related to the engine, powertrain, or electronic control systems. The vehicle and components are available for inspection upon request. Safety Risk: The vehicle’s failure to accelerate and overheating while in motion creates a serious safety hazard. This puts the driver and passengers at risk, especially if the loss of acceleration occurs in high-speed traffic, intersections, or on highways. Reproduction of the Problem: The issue has recurred multiple times. It has not yet been officially reproduced or confirmed by a dealer or independent service center. Inspections: At this time, the vehicle has not been formally inspected by the manufacturer, police, or insurance representatives. Warning Lamps, Messages, and Symptoms Prior to Failure: The problem is preceded by the illumination of the ESC light, the check engine light, and other unknown warning lights. The messages “Service Engine Soon” and others appear immediately prior to or during the failure. These warnings occur before the loss of acceleration and overheating. Additional Notes: The failures are ongoing and have occurred more than once, raising concerns about reliability and safety.

I had my radiator fail, lost all fluid and had to be towed. The car has 73,000 miles on it, is well maintained and garage kept. Alfa has sent the dealerships a Service Bulletin item about the issue, but never contacted the consumers about fixing it proactively. My son broke down on a highway, was able to limp the vehicle to a parking lot where the car had to be towed. The repair was done by Alfa and cost almost $3,000 No issues showed up prior. Once the fail happened the car was

The car never showed signs of an issue, I got on the car with my two children, when I attempted to start the car. The engine started smoking and smelled like burned plastic. We got out of the car, the smoke went on for about 15-30 seconds. After that the car did not start. The engine's wiring was charred. I was informed by the dealer a ground strap failed. This ground strap is exposed to the elements at the bottom of the engine and it's prone to corrode, rendering it useless and causing the electrical wiring to overheat and potentially start a fire.

My 2018 Alfa Romeo Stelvio was diagnosed by a certified Alfa Romeo dealer with a major engine defect involving coolant mixing with oil. The diagnosis revealed internal failure likely stemming from the oil cooler or head gasket, and the parts estimate alone was over $17,000 — not including labor. The dealer confirmed the issue but stated no recalls apply and denied warranty coverage. The car showed early signs like minor overheating and coolant loss, but no clear warning lamps or check engine lights until the issue escalated. This defect significantly increases the risk of engine failure, overheating, or loss of power while driving — posing a serious safety concern. I have since discovered multiple other owners reporting the exact same problem in Alfa Romeo forums and consumer complaint sites. The dealer has confirmed the issue but refused support. I believe this may reflect a broader design flaw affecting many vehicles and should be investigated for potential recall.

The engine has shut down in traffic on the following occasions: 1) July 2023 in The Woodlands, Texas. 2) Later that same day on [XXX] in Plantersville, Texas. 3) In August 2024, on [XXX] and 4) on [XXX] . My vehicle is available to the NHTSA upon request. On each occasion, except one, I was fortunate to be in the right hand lane and was able to pull over onto the shoulder before any could hit me. On [XXX] , near Richards, there was no shoulder and I was stopped within the single lane of westbound traffic. I was fortunate that traffic was light at that time and that it was daylight. After the first two incidents in 2023, I took it to Northside Imports in Spring, Texas (XXX) They were unable to duplicate the problem or determine what was the cause. On [XXX], I took the car back to Northside Imports and they determined that it needed a new fuel pump, seal and control module. (I was informed on Friday, [XXX] that the parts have been received and can be installed on [XXX].) Between the time that the fault was identified and the time the parts were available the car has failed on the highway twice, once on [XXX] and once on [XXX] . The vehicle has not been inspected by anyone but Northside Imports in Spring, Texas. There were no warnings in advance of the shutdown. I was able to restart the vehicle after a short period of time after disconnecting the battery. Each time, it restarted in "limp" mode. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Alfa Romeo Stelvio. The contact stated while driving 40 MPH and attempting to accelerate, the accelerator pedal travelled down to the floorboard, and the vehicle stalled. The ESC warning light, the check engine warning light, and other unknown warning lights were illuminated. Additionally, the message “Service Engine Soon" and other unknown messages were displayed. The contact was able to pull to the side of the road. The contact was able to restart the vehicle, and the contact drove to the residence. Additionally, the contact received notification of NHTSA Campaign Number: 24V510000 (Air Bags, Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and informed the contact that the repair could not be covered because the vehicle was out of warranty. The failure mileage was approximately 120,000. VIN tool confirms parts not available.

I was in the process of merging on the the express way when my vehicle threw a warning light, "service electronic throttle control" along with a "service engine" message and a check engine light. The vehicle went into a "limp" and had extremely poor acceleration, I was almost rear ended because the vehicle couldn't reach highways speeds fast enough. The vehicle has not yet been inspected my the manufacturer but I did some research on this issue and found it to be alarmingly common. There seems to be no clear answer to the reason for this and no sure repairs for the problem. This poses a safety risk to drivers as this problem seems to happen while accelerating. It can be dangerous if someone on the expressway is attempting to merge into 60mph traffic and hit "limp mode" at roughly 30. I believe an investigation need to be conducted regarding this followed by a recall of the affected part.