IllustrationMy car keeps going into limp mode seasonally, it also emits bad odors when given throttle, and it is definitely lacking power. Situation has also caused a misfire on my 3rd cylinder and a super rough idle and start
2017 Alfa Romeo Giulia
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Giulia years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
125–50K
350–75K
175–100K
0100–150K
1150K+
26 reports with mileage · 74 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports0 fire reports1 injury reports
Engine complaints
31 reportsVehicle completely lost power and quite running in the middle of the desert in Arizona. This relates to Saftey Recall 93c. I had to have the car towed and repaired in Scottsdale, AZ. I have been told that this repair (which was expensive) might not remedy the problem and it could reoccur. It's been over six months since the …
Read full complaint
Vehicle completely lost power and quite running in the middle of the desert in Arizona. This relates to Saftey Recall 93c. I had to have the car towed and repaired in Scottsdale, AZ. I have been told that this repair (which was expensive) might not remedy the problem and it could reoccur. It's been over six months since the recall was issued and yet no remedy is available and I have not received reimbursement for the repairs I had to have done to get my vehicle running. I think six months is enough time given that I cannot trust the reliability of my vehicle due to this serious problem. When a vehicle just "turns off" in the middle of the freeway it poses a huge safety risk both to the occupants and to other drivers in the area. So my complaint is that it's taking far too long for Stellates to produce parts to remedy this problem.
I was driving on the highway and my car starts sputtering, I figured I pull over and turn my car off and on. My car seemed fine and I continued to drive home from work. As soon as I got off the highway my car completely shut off mid ride, stalls out and my steering wheel locked up. I was able to get my car turned back on and get…
Read full complaint
I was driving on the highway and my car starts sputtering, I figured I pull over and turn my car off and on. My car seemed fine and I continued to drive home from work. As soon as I got off the highway my car completely shut off mid ride, stalls out and my steering wheel locked up. I was able to get my car turned back on and get back home. Filled with anxiety at least. Luckily I have a code reader in my car as soon as I pulled into my driveway and the codes showing where P008A which is directly related to a fuel pump/ fuel delivery issue. This happened on February 28th. I have been scared to drive the car since
the vehicle has read off warnings seconds from simply stopping and cutting off in traffic. this has happened at least two times now. it may say full throttle service and flash lights before simply slowing down and the check engine light flashing while on the highway unable to speed up no matter how far down on the gas pedal I pu…
Read full complaint
the vehicle has read off warnings seconds from simply stopping and cutting off in traffic. this has happened at least two times now. it may say full throttle service and flash lights before simply slowing down and the check engine light flashing while on the highway unable to speed up no matter how far down on the gas pedal I push. has been taken to dealer several times. problems started soon after purchasing vehicle. On 3/1/2026 while leaving church service, my family and I were on a major highway with the speed limit at 65 mph. The vehicle just slowed down without giving any power and could not get it up to the speed to continue with traffic. This vehicle could put me and my family at risk for a possible dangerous situation.
I am filing a complaint in regard to recall 93c for my 2017 Alfa Romeo. The dealership/manufacturer has failed to provide me with a fix, parts or even just a loaner car due to the safety hazard. My car has gone limp mode several times on the highway at speeds of 70mph. This is unacceptable.
My 2017 Alfa Romeo Giulia, VIN [XXX] , is currently disabled and inoperable at the authorized dealer, Alfa Romeo Fiat of Daytona (Service Advisor: Kevin Chapman). The vehicle is subject to the active and known Safety Recall 93C (Low-Pressure Fuel Pump). My vehicle is experiencing a total loss of motive power and engine stall, wh…
Read full complaint
My 2017 Alfa Romeo Giulia, VIN [XXX] , is currently disabled and inoperable at the authorized dealer, Alfa Romeo Fiat of Daytona (Service Advisor: Kevin Chapman). The vehicle is subject to the active and known Safety Recall 93C (Low-Pressure Fuel Pump). My vehicle is experiencing a total loss of motive power and engine stall, which is the exact safety hazard described in the recall. Furthermore, the initial failure of the low-pressure fuel system appears to have caused secondary consequential damage to the expensive High-Pressure Fuel Pump (HPFP), and the vehicle is also exhibiting a severe and recurring electrical defect (new battery dying, random dash warnings/brake lights flashing). The manufacturer, FCA/Stellantis (Customer Care Case #XXX...), and the dealer are engaging in a runaround to deny basic safety recall provisions: 1. Refusal to Cover Consequential Damage: FCA Customer Care stated that if the issue is 'not the 93C recall then it will all be customer pay,' which conflicts with NHTSA guidelines requiring the manufacturer to remedy the primary defect and all damage proximately caused by it. 2. Refusal to Provide Loaner/Rental Car: FCA stated the loaner is up to the dealer, and the dealer stated it is up to the diagnostic. This runaround has created an unreasonable delay in the repair of a federally mandated safety recall, leaving the owner without transportation for a disabled, unsafe vehicle. I am requesting NHTSA intervention to compel FCA/Stellantis to: a) Authorize a complimentary rental car/loaner until the vehicle is fully repaired. b) Provide a formal commitment that all damage proven to be a direct, proximate consequence of the 93C fuel pump failure will be covered at no cost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Oil Pump Solenoid will get stuck and will cause the car to go into LOMP mode or in worse cases cause the drivetrain to lock up and a lose all power. It can happen at random.
The oil pump is defective and is a known issue at Alfa Romeo which causes the car restrict function which could result in loss of control of the vehicle.
This has been an issue slowly getting worse over the last few months and escalated this week. June 20th, 2025 my car has literary died over (4) times during traffic and I had to try and stay calm while using a code reader to clear the codes to get the engine to start. Very scary, I have a 2017 Giulia Ti that just hit 100k miles.…
Read full complaint
This has been an issue slowly getting worse over the last few months and escalated this week. June 20th, 2025 my car has literary died over (4) times during traffic and I had to try and stay calm while using a code reader to clear the codes to get the engine to start. Very scary, I have a 2017 Giulia Ti that just hit 100k miles. Even took it to the dealership and they couldn't explain it. Parasitic draw on my battery and they gave it a pass :( Codes: P2510-ECM/PCM POWER RELAY SENSE CKT RANGE/PERFORMANCE P0103-VAF CIRCUIT HIGH INPUT P0100- VAF CIRCUIT MALFUNCTION P0451-EVAP SYSTEM PRESSURE SENSOR/SWITCH 'A' RANGE/PERFORMANCE P0106-MANIFOLD ABSOLUTE PRESSURE/BAROMETRIC PRESSURE SENSOR CIRCUIT
Multiple times the check engine light will come on while driving. It shuts engine down at any speed. This usually happens during warm up phase of vehicle. You have to pull over and cycle power off and on multiple times before it starts and runs again. It has stalled in intersections causing traffic delays. Once it starts and co…
Read full complaint
Multiple times the check engine light will come on while driving. It shuts engine down at any speed. This usually happens during warm up phase of vehicle. You have to pull over and cycle power off and on multiple times before it starts and runs again. It has stalled in intersections causing traffic delays. Once it starts and codes clear it typically runs fine for long periods. Symptom codes include throttle system failure, fuel pump low pressure, miss fire, bcm communication error. Cycling off and on clears codes and car operates normally until next cold start. Symptoms seem to worsen when driving in n or a mode. Symptoms seem to worsen when remote starting vehicle.
Official recalls
725V586000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 9, 2025
Chrysler (FCA US, LLC) is recalling certain 2017-2019 Alfa Romeo Giulia and 2018-2019 Alfa Romeo Stelvio vehicles. The fuel pump may fail, which can result in a loss of fuel flow and loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the fuel delivery module, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 7, 2025. Additional letters will be sent once the final remedy is available, anticipated July 2026. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 93C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 16, 2025. The information in your report suggests that Chrysler (FCA US, LLC) may have been aware of this issue more than five business days before filing a report with NHTSA. Please be reminded that under Federal law, this agency is to be notified of all safety defect and/or noncompliance decisions within five business days. 49 CFR 573.6 Significant civil penalties can be assessed for this violation.
24V510000 · Air Bags:frontal; Seat Belts:front
Jul 3, 2024
Chrysler (FCA US, LLC) is recalling certain 2017-2024 Alfa Romeo Giulia, 2018-2025 Alfa Romeo Stelvio, 2019-2023 Fiat 500X, Jeep Renegade, and 2024 Fiat 500E vehicles. A seat belt buckle switch sensor may be improperly connected, preventing the front seat air bag from deploying as intended.
Consequence & remedy
Consequence: A front seat air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will repair the connection, free of charge. Owner notification letters were mailed beginning August 27, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 82B.
Additional source detail variants (2)
Seat Belts:front
Chrysler (FCA US, LLC) is recalling certain 2017-2024 Alfa Romeo Giulia, 2018-2025 Alfa Romeo Stelvio, 2019-2023 Fiat 500X, Jeep Renegade, and 2024 Fiat 500E vehicles. A seat belt buckle switch sensor may be improperly connected, preventing the front seat air bag from deploying as intended.
Consequence: A front seat air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will repair the connection, free of charge. Owner notification letters were mailed beginning August 27, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 82B.
Air Bags:frontal
Chrysler (FCA US, LLC) is recalling certain 2017-2024 Alfa Romeo Giulia, 2018-2025 Alfa Romeo Stelvio, 2019-2023 Fiat 500X, Jeep Renegade, and 2024 Fiat 500E vehicles. A seat belt buckle switch sensor may be improperly connected, preventing the front seat air bag from deploying as intended.
Consequence: A front seat air bag that does not deploy as intended can increase the risk of injury in a crash.
Remedy: Dealers will repair the connection, free of charge. Owner notification letters were mailed beginning August 27, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 82B.
24V512000 · Equipment:other:labels
Jul 3, 2024
Chrysler (FCA US, LLC) is recalling certain 2017-2024 Alfa Romeo Giulia and 2021-2024 Alfa Romeo Stelvio vehicles. The tire pressure and size information on the tire placard and manufacturer labels are incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Incorrect tire information can result in under-inflated tires or installing the incorrect-size tires, increasing the risk of a crash.
Remedy: FCA will mail corrected tire placards and manufacturer overlay labels. Owners may bring the labels into a dealer for free installation. Some interim notification letters, notifying owners of the safety risk, were mailed August 27, 2024. Owner notification letters were mailed August 5, 2024 through November 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 81B.
23V382000 · Service Brakes, Hydraulic
May 30, 2023
Chrysler (FCA US, LLC) is recalling certain 2017-2020 Alfa Romeo Giulia and 2018-2020 Alfa Romeo Stelvio vehicles equipped with carbon ceramic matrix brakes. During certain driving maneuvers, the brake system may exert an excessive clamp force that may fracture the rotor, decreasing the brake performance.
Consequence & remedy
Consequence: An unexpected decrease in brake performance increases the risk of a crash.
Remedy: Dealers will update the brake system module (BSM) software, free of charge. Owner notification letters were mailed July 20, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 68A.
19V148000 · Forward Collision Avoidance: Adaptive Cruise Control; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Mar 1, 2019
FCA US LLC (Alfa Romeo) is recalling certain 2018-2019 Alfa Romeo Stelvio and 2017-2019 Giulia vehicles. The Brake System Module (BSM) software may prevent the driver from disabling the Adaptive Cruise Control (ACC) after the traction control system detects a specific wheel slip.
Consequence & remedy
Consequence: The driver's inability to deactivate the ACC can increase the risk of crash.
Remedy: Alfa Romeo has notified owners, and dealers will update the BSM software, free of charge. The recall began March 25, 2019. Owners may contact Alfa Romeo customer service 1-800-853-1403. The Alfa Romeo number for this recall is V27.
Additional source detail variants (2)
Forward Collision Avoidance: Adaptive Cruise Control
FCA US LLC (Alfa Romeo) is recalling certain 2018-2019 Alfa Romeo Stelvio and 2017-2019 Giulia vehicles. The Brake System Module (BSM) software may prevent the driver from disabling the Adaptive Cruise Control (ACC) after the traction control system detects a specific wheel slip.
Consequence: The driver's inability to deactivate the ACC can increase the risk of crash.
Remedy: Alfa Romeo has notified owners, and dealers will update the BSM software, free of charge. The recall began March 25, 2019. Owners may contact Alfa Romeo customer service 1-800-853-1403. The Alfa Romeo number for this recall is V27.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
FCA US LLC (Alfa Romeo) is recalling certain 2018-2019 Alfa Romeo Stelvio and 2017-2019 Giulia vehicles. The Brake System Module (BSM) software may prevent the driver from disabling the Adaptive Cruise Control (ACC) after the traction control system detects a specific wheel slip.
Consequence: The driver's inability to deactivate the ACC can increase the risk of crash.
Remedy: Alfa Romeo has notified owners, and dealers will update the BSM software, free of charge. The recall began March 25, 2019. Owners may contact Alfa Romeo customer service 1-800-853-1403. The Alfa Romeo number for this recall is V27.
18V828000 · Engine And Engine Cooling:exhaust System; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
Nov 26, 2018
Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia vehicles equipped with GME 280HP engines and All Wheel Drive ("AWD"). The brake fluid line may contact a coolant hose clamp, possibly causing brake fluid to leak onto the exhaust.
Consequence & remedy
Consequence: Brake fluid leaking onto the exhaust can increase the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will install a bracket on the brake fluid line to prevent contact with the coolant hose clamp. If damage is found on the brake line, it will be replaced, free of charge. The recall began January 10, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is UB9.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System
Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia vehicles equipped with GME 280HP engines and All Wheel Drive ("AWD"). The brake fluid line may contact a coolant hose clamp, possibly causing brake fluid to leak onto the exhaust.
Consequence: Brake fluid leaking onto the exhaust can increase the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will install a bracket on the brake fluid line to prevent contact with the coolant hose clamp. If damage is found on the brake line, it will be replaced, free of charge. The recall began January 10, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is UB9.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia vehicles equipped with GME 280HP engines and All Wheel Drive ("AWD"). The brake fluid line may contact a coolant hose clamp, possibly causing brake fluid to leak onto the exhaust.
Consequence: Brake fluid leaking onto the exhaust can increase the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will install a bracket on the brake fluid line to prevent contact with the coolant hose clamp. If damage is found on the brake line, it will be replaced, free of charge. The recall began January 10, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is UB9.
18V636000 · Electrical System:wiring; Engine And Engine Cooling:engine
Sep 14, 2018
Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia and 2018 Alfa Romeo Stelvio vehicles, equipped with 2.0L engines. These engines may misfire causing the catalytic converter to overheat, possibly resulting in damage to the nearby wiring and engine components.
Consequence & remedy
Consequence: Heat damage to the engine compartment wiring or components can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the vehicles for diagnostic codes, and update the engine control module software, free of charge. The recall began October 10, 2018. Owners may contact Chrysler customer service at 1-844-253-2872. Chrysler's number for this recall is UA4.
Additional source detail variants (2)
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia and 2018 Alfa Romeo Stelvio vehicles, equipped with 2.0L engines. These engines may misfire causing the catalytic converter to overheat, possibly resulting in damage to the nearby wiring and engine components.
Consequence: Heat damage to the engine compartment wiring or components can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the vehicles for diagnostic codes, and update the engine control module software, free of charge. The recall began October 10, 2018. Owners may contact Chrysler customer service at 1-844-253-2872. Chrysler's number for this recall is UA4.
Engine And Engine Cooling:engine
Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia and 2018 Alfa Romeo Stelvio vehicles, equipped with 2.0L engines. These engines may misfire causing the catalytic converter to overheat, possibly resulting in damage to the nearby wiring and engine components.
Consequence: Heat damage to the engine compartment wiring or components can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the vehicles for diagnostic codes, and update the engine control module software, free of charge. The recall began October 10, 2018. Owners may contact Chrysler customer service at 1-844-253-2872. Chrysler's number for this recall is UA4.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE24003 · Low Pressure Fuel Pump Assembly Failure
Opened Jan 8, 2024 · Closed Sep 26, 2025
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:fuel Pump:control/drive Module
On January 8, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE24003) to assess allegations of loss of motive power resulting from low-pressure fuel pump failures in certain MY 2017–2019 Alfa Romeo Giulia vehicles. The subject vehicles are equipped with 2.0L 4-cylinder and 2.9L 6-cylinder turbocharged engines and manufactured by Fiat Chrysler Automobiles US LLC (FCA US). Reports received by ODI alleged stall and loss of motive power at speeds above 25 mph, with several reporting that the condition resulted in permanent disablement of the vehicle. Many reports described recurrence of the failure after an initial repair. During the investigation, ODI determined that the subject vehicles were equipped with fuel delivery pumps supplied by Vitesco Technologies Germany GmbH. ODI also confirmed that MY 2018–2019 Alfa Romeo Stelvio vehicles were equipped with the same pump. ODI’s analysis identified an elevated failure rate associated with the original pumps installed in the subject vehicles. The failure mode involves interruption of fuel flow, resulting in fuel starvation and an unexpected loss of motive power, typically with little to no advance warning. In responses to ODI Information Requests submitted in April and June 2024, FCA US reported 2,162 customer reports (complaints, field reports, and legal claims) and 464 warranty claims related to the alleged defect. Combined with ODI’s data, the investigation identified 1,900 unique VIN experiencing failures. Review of the combined data confirmed one crash and no injuries, fatalities, or fires. On September 9, 2025, FCA US filed recall 25V-586, covering 29,467 MY 2017–2019 Alfa Romeo Giulia vehicles and 24,382 MY 2018 Alfa Romeo Stelvio vehicles, all equipped with the suspect Vitesco fuel delivery pump. FCA US reported that the remedy is under development, with dealer notifications planned on or about September 16, 2025, and owner notifications scheduled to begin on or about October 29, 2025. The recall action initiated by FCA US addresses the alleged defect identified in this PE. Accordingly, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances, including an evaluation of the remedy once available. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (6)
Fuel System, Gasoline
On January 8, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE24003) to assess allegations of loss of motive power resulting from low-pressure fuel pump failures in certain MY 2017–2019 Alfa Romeo Giulia vehicles. The subject vehicles are equipped with 2.0L 4-cylinder and 2.9L 6-cylinder turbocharged engines and manufactured by Fiat Chrysler Automobiles US LLC (FCA US). Reports received by ODI alleged stall and loss of motive power at speeds above 25 mph, with several reporting that the condition resulted in permanent disablement of the vehicle. Many reports described recurrence of the failure after an initial repair. During the investigation, ODI determined that the subject vehicles were equipped with fuel delivery pumps supplied by Vitesco Technologies Germany GmbH. ODI also confirmed that MY 2018–2019 Alfa Romeo Stelvio vehicles were equipped with the same pump. ODI’s analysis identified an elevated failure rate associated with the original pumps installed in the subject vehicles. The failure mode involves interruption of fuel flow, resulting in fuel starvation and an unexpected loss of motive power, typically with little to no advance warning. In responses to ODI Information Requests submitted in April and June 2024, FCA US reported 2,162 customer reports (complaints, field reports, and legal claims) and 464 warranty claims related to the alleged defect. Combined with ODI’s data, the investigation identified 1,900 unique VIN experiencing failures. Review of the combined data confirmed one crash and no injuries, fatalities, or fires. On September 9, 2025, FCA US filed recall 25V-586, covering 29,467 MY 2017–2019 Alfa Romeo Giulia vehicles and 24,382 MY 2018 Alfa Romeo Stelvio vehicles, all equipped with the suspect Vitesco fuel delivery pump. FCA US reported that the remedy is under development, with dealer notifications planned on or about September 16, 2025, and owner notifications scheduled to begin on or about October 29, 2025. The recall action initiated by FCA US addresses the alleged defect identified in this PE. Accordingly, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances, including an evaluation of the remedy once available. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On January 8, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE24003) to assess allegations of loss of motive power resulting from low-pressure fuel pump failures in certain MY 2017–2019 Alfa Romeo Giulia vehicles. The subject vehicles are equipped with 2.0L 4-cylinder and 2.9L 6-cylinder turbocharged engines and manufactured by Fiat Chrysler Automobiles US LLC (FCA US). Reports received by ODI alleged stall and loss of motive power at speeds above 25 mph, with several reporting that the condition resulted in permanent disablement of the vehicle. Many reports described recurrence of the failure after an initial repair. During the investigation, ODI determined that the subject vehicles were equipped with fuel delivery pumps supplied by Vitesco Technologies Germany GmbH. ODI also confirmed that MY 2018–2019 Alfa Romeo Stelvio vehicles were equipped with the same pump. ODI’s analysis identified an elevated failure rate associated with the original pumps installed in the subject vehicles. The failure mode involves interruption of fuel flow, resulting in fuel starvation and an unexpected loss of motive power, typically with little to no advance warning. In responses to ODI Information Requests submitted in April and June 2024, FCA US reported 2,162 customer reports (complaints, field reports, and legal claims) and 464 warranty claims related to the alleged defect. Combined with ODI’s data, the investigation identified 1,900 unique VIN experiencing failures. Review of the combined data confirmed one crash and no injuries, fatalities, or fires. On September 9, 2025, FCA US filed recall 25V-586, covering 29,467 MY 2017–2019 Alfa Romeo Giulia vehicles and 24,382 MY 2018 Alfa Romeo Stelvio vehicles, all equipped with the suspect Vitesco fuel delivery pump. FCA US reported that the remedy is under development, with dealer notifications planned on or about September 16, 2025, and owner notifications scheduled to begin on or about October 29, 2025. The recall action initiated by FCA US addresses the alleged defect identified in this PE. Accordingly, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances, including an evaluation of the remedy once available. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:delivery:fuel Pump
On January 8, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE24003) to assess allegations of loss of motive power resulting from low-pressure fuel pump failures in certain MY 2017–2019 Alfa Romeo Giulia vehicles. The subject vehicles are equipped with 2.0L 4-cylinder and 2.9L 6-cylinder turbocharged engines and manufactured by Fiat Chrysler Automobiles US LLC (FCA US). Reports received by ODI alleged stall and loss of motive power at speeds above 25 mph, with several reporting that the condition resulted in permanent disablement of the vehicle. Many reports described recurrence of the failure after an initial repair. During the investigation, ODI determined that the subject vehicles were equipped with fuel delivery pumps supplied by Vitesco Technologies Germany GmbH. ODI also confirmed that MY 2018–2019 Alfa Romeo Stelvio vehicles were equipped with the same pump. ODI’s analysis identified an elevated failure rate associated with the original pumps installed in the subject vehicles. The failure mode involves interruption of fuel flow, resulting in fuel starvation and an unexpected loss of motive power, typically with little to no advance warning. In responses to ODI Information Requests submitted in April and June 2024, FCA US reported 2,162 customer reports (complaints, field reports, and legal claims) and 464 warranty claims related to the alleged defect. Combined with ODI’s data, the investigation identified 1,900 unique VIN experiencing failures. Review of the combined data confirmed one crash and no injuries, fatalities, or fires. On September 9, 2025, FCA US filed recall 25V-586, covering 29,467 MY 2017–2019 Alfa Romeo Giulia vehicles and 24,382 MY 2018 Alfa Romeo Stelvio vehicles, all equipped with the suspect Vitesco fuel delivery pump. FCA US reported that the remedy is under development, with dealer notifications planned on or about September 16, 2025, and owner notifications scheduled to begin on or about October 29, 2025. The recall action initiated by FCA US addresses the alleged defect identified in this PE. Accordingly, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances, including an evaluation of the remedy once available. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:delivery:fuel Pump
On January 8, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE24003) to assess allegations of loss of motive power resulting from low-pressure fuel pump failures in certain MY 2017–2019 Alfa Romeo Giulia vehicles. The subject vehicles are equipped with 2.0L 4-cylinder and 2.9L 6-cylinder turbocharged engines and manufactured by Fiat Chrysler Automobiles US LLC (FCA US). Reports received by ODI alleged stall and loss of motive power at speeds above 25 mph, with several reporting that the condition resulted in permanent disablement of the vehicle. Many reports described recurrence of the failure after an initial repair. During the investigation, ODI determined that the subject vehicles were equipped with fuel delivery pumps supplied by Vitesco Technologies Germany GmbH. ODI also confirmed that MY 2018–2019 Alfa Romeo Stelvio vehicles were equipped with the same pump. ODI’s analysis identified an elevated failure rate associated with the original pumps installed in the subject vehicles. The failure mode involves interruption of fuel flow, resulting in fuel starvation and an unexpected loss of motive power, typically with little to no advance warning. In responses to ODI Information Requests submitted in April and June 2024, FCA US reported 2,162 customer reports (complaints, field reports, and legal claims) and 464 warranty claims related to the alleged defect. Combined with ODI’s data, the investigation identified 1,900 unique VIN experiencing failures. Review of the combined data confirmed one crash and no injuries, fatalities, or fires. On September 9, 2025, FCA US filed recall 25V-586, covering 29,467 MY 2017–2019 Alfa Romeo Giulia vehicles and 24,382 MY 2018 Alfa Romeo Stelvio vehicles, all equipped with the suspect Vitesco fuel delivery pump. FCA US reported that the remedy is under development, with dealer notifications planned on or about September 16, 2025, and owner notifications scheduled to begin on or about October 29, 2025. The recall action initiated by FCA US addresses the alleged defect identified in this PE. Accordingly, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances, including an evaluation of the remedy once available. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:delivery:fuel Pump:control/drive Module
On January 8, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE24003) to assess allegations of loss of motive power resulting from low-pressure fuel pump failures in certain MY 2017–2019 Alfa Romeo Giulia vehicles. The subject vehicles are equipped with 2.0L 4-cylinder and 2.9L 6-cylinder turbocharged engines and manufactured by Fiat Chrysler Automobiles US LLC (FCA US). Reports received by ODI alleged stall and loss of motive power at speeds above 25 mph, with several reporting that the condition resulted in permanent disablement of the vehicle. Many reports described recurrence of the failure after an initial repair. During the investigation, ODI determined that the subject vehicles were equipped with fuel delivery pumps supplied by Vitesco Technologies Germany GmbH. ODI also confirmed that MY 2018–2019 Alfa Romeo Stelvio vehicles were equipped with the same pump. ODI’s analysis identified an elevated failure rate associated with the original pumps installed in the subject vehicles. The failure mode involves interruption of fuel flow, resulting in fuel starvation and an unexpected loss of motive power, typically with little to no advance warning. In responses to ODI Information Requests submitted in April and June 2024, FCA US reported 2,162 customer reports (complaints, field reports, and legal claims) and 464 warranty claims related to the alleged defect. Combined with ODI’s data, the investigation identified 1,900 unique VIN experiencing failures. Review of the combined data confirmed one crash and no injuries, fatalities, or fires. On September 9, 2025, FCA US filed recall 25V-586, covering 29,467 MY 2017–2019 Alfa Romeo Giulia vehicles and 24,382 MY 2018 Alfa Romeo Stelvio vehicles, all equipped with the suspect Vitesco fuel delivery pump. FCA US reported that the remedy is under development, with dealer notifications planned on or about September 16, 2025, and owner notifications scheduled to begin on or about October 29, 2025. The recall action initiated by FCA US addresses the alleged defect identified in this PE. Accordingly, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances, including an evaluation of the remedy once available. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:delivery:fuel Pump:control/drive Module
On January 8, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE24003) to assess allegations of loss of motive power resulting from low-pressure fuel pump failures in certain MY 2017–2019 Alfa Romeo Giulia vehicles. The subject vehicles are equipped with 2.0L 4-cylinder and 2.9L 6-cylinder turbocharged engines and manufactured by Fiat Chrysler Automobiles US LLC (FCA US). Reports received by ODI alleged stall and loss of motive power at speeds above 25 mph, with several reporting that the condition resulted in permanent disablement of the vehicle. Many reports described recurrence of the failure after an initial repair. During the investigation, ODI determined that the subject vehicles were equipped with fuel delivery pumps supplied by Vitesco Technologies Germany GmbH. ODI also confirmed that MY 2018–2019 Alfa Romeo Stelvio vehicles were equipped with the same pump. ODI’s analysis identified an elevated failure rate associated with the original pumps installed in the subject vehicles. The failure mode involves interruption of fuel flow, resulting in fuel starvation and an unexpected loss of motive power, typically with little to no advance warning. In responses to ODI Information Requests submitted in April and June 2024, FCA US reported 2,162 customer reports (complaints, field reports, and legal claims) and 464 warranty claims related to the alleged defect. Combined with ODI’s data, the investigation identified 1,900 unique VIN experiencing failures. Review of the combined data confirmed one crash and no injuries, fatalities, or fires. On September 9, 2025, FCA US filed recall 25V-586, covering 29,467 MY 2017–2019 Alfa Romeo Giulia vehicles and 24,382 MY 2018 Alfa Romeo Stelvio vehicles, all equipped with the suspect Vitesco fuel delivery pump. FCA US reported that the remedy is under development, with dealer notifications planned on or about September 16, 2025, and owner notifications scheduled to begin on or about October 29, 2025. The recall action initiated by FCA US addresses the alleged defect identified in this PE. Accordingly, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances, including an evaluation of the remedy once available. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.