Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
Mileage unknown · May 8, 2024
Electrical SystemFuel/propulsion System
My 2020 Zero SR/F is BEV motorcycle. I purchased it new in July 2020 and by February 2023 the total range on a full battery charge was approximately 25% of the original specifications. Where I would get between 100 and 160 miles on a full charge depending on speed in 2020, in February 2023 I was consistently getting 30 miles on …
Read full complaint
My 2020 Zero SR/F is BEV motorcycle. I purchased it new in July 2020 and by February 2023 the total range on a full battery charge was approximately 25% of the original specifications. Where I would get between 100 and 160 miles on a full charge depending on speed in 2020, in February 2023 I was consistently getting 30 miles on a full charge at 55mph. The motorcycle was also recharging on level 1 charging at 11A from 10% to 100% in less than an hour, which should not be possible normally using a 5-15 household outlet to charge the 14.4kWh battery. The manufacturer warrantied battery capacity to be ≥ 80% of original capacity for 5 years/200,000miles. The manufacturer replaced the original 14.4kWh battery pack in October 2023 with ~2200 miles on the odometer with a new chemistry battery pack. This followed range tests by two authorized dealers and an engineer from the manufacturer. The safety risk was being stranded by the motorcycle because the battery pack was failing prematurely. I have had no range/capacity issues with the replacement battery pack that has a different capacity than the original battery pack.
Zero Motorcycles Inc. (Zero) is recalling certain 2020 SR/F motorcycles. The rear rotor bolts were insufficiently tightened.
Consequence & remedy
Consequence: The loose bolts may damage the caliper or swingarm, reducing rear braking capability and increasing the risk of a crash.
Remedy: Dealers will correctly tighten and replace the rear rotor bolts as necessary, free of charge. Owner notification letters were mailed November 1, 2021. Owners may contact Zero customer service at 1-888-841-8085. Zero's number for this recall is SV-ZMC-020-417.
Zero Motorcycles Inc. (Zero) is recalling certain 2020 SR/F and SR/S motorcycles. The front brake switch can fail from water getting into the switch.
Consequence & remedy
Consequence: An inoperable front brake switch will not illuminate the brake light when the rider applies the front brakes. Following vehicles may not realize the motorcycle is braking. Cruise control will not shut off with the application of the front brakes. Both conditions increase the risk of a crash.
Remedy: Zero will notify owners, and dealers will the replace the front brake switch, free of charge. The recall began November 30, 2020. Owners may contact Zero customer service at 1-888-841-8085. Zero's number for this recall is SV-ZMC-021-020.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2020 Zero Sr/F Problems, Complaints & Recalls | Skip That Year
Illustration