IllustrationLOW SPEED, LOW RPM POWER LOSS. TOTAL ENGINE POWER LOSS (ENGINE DIES). SUSPECTED TPS FAILURE. TOOK MOTORCYCLE TO DEALER SHIP FOR REPAIR. PROBLEM STILL EXISTS. TOOK A SECOND TIME TO DEALER, DID NOT REPLACE TPS, SAID IT CHECKED OUT OK. I UNDERSTAND THERE IS A 3RD GENERATION TPS THAT CAN BE USED. *TR
2004 Yamaha YZF-R1
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all YZF-R1 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
330–25K
025–50K
150–75K
075–100K
0100–150K
0150K+
34 reports with mileage · 3 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports0 fire reports6 injury reports
Tires complaints
2 reportsI RECENTLY PURCHASED YAMAHA'S NEW 125 VINO SCOOTER AND AFTER ONLY 400 MILES AT RATED SPEED OF 50 MPH (FASTER THAN MOST SCOOTERS), WITH NORMAL DRIVING, I WAS THROWN AND HIT THE PAVEMENT MAKING DOG MEAT OF MY BODY. I SUSPECT THE SMALL FRONT TIRE DESIGN AT HIGH SPEEDS IS A DEATH TRAP. CAN SUPPLY MORE DETAILS.*AK
Official recalls
106V371000 · Vehicle Speed Control
Sep 28, 2006
ON CERTAIN MOTORCYCLES, AN IMPROPERLY DESIGNED THROTTLE POSITION SENSOR COULD CAUSE AN INTERMITTENTLY UNSTABLE IDLE WHEN THE ENGINE IS AT IDLING SPEED WHEN THE MOTORCYCLE IS STOPPED OR DURING LOW-SPEED OPERATIONS. THE ENGINE COULD STALL AS A RESULT.
Consequence & remedy
Consequence: IF THE ENGINE STALLS AFTER THE OPERATOR DISENGAGES THE CLUTCH IN A LOW GEAR WHILE RIDING, THE REAR TIRE MIGHT SLIP MOMENTARILY IF THE OPERATOR ABRUPTLY RE-ENGAGES THE CLUTCH. THIS COULD RESULT IN A CRASH WITH INJURY OR DEATH.
Remedy: DEALERS WILL REPLACE THE THROTTLE POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2006. OWNERS MAY CONTACT YAMAHA AT 1-888-88-YAMAHA.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06020 · Motorcycle Stalling
Opened May 23, 2006 · Closed Oct 5, 2006
Status: closed (inferred from source dates) · Fuel System, Other:fuel Injection System
OPERATORS REPORT THE MOTORCYCLE STALLS WHEN ROLLING OFF THE THROTTLE (E.G., TIP-OUT STALL WHILE APPROACHING A STOP) ALLEGEDLY DUE TO A FAULTY THROTTLE POSITION SENSOR (TPS).TO CORRECT THIS CONDITION, YAMAHA IS RECALLING THE SUBJECT VEHICLES TO INSTALL AN IMPROVED TPS.