2007 Yamaha FJR1300

MY ENGINE DIED WHILE I WAS COMING TO A STOP ON MY 2007 FJR1300 MOTORCYCLE. I NOTICED THAT THERE WAS NO ELECTRICAL INDICATIONS AND THE IGNITION SWITCH DID NOT RESPOND. I GOT THE BIKE BACK TO THE DEALER IN HOUSTON AND THEY IMMEDIATELY THOUGHT THE PROBLEM WAS SWITCH FAILURE. THE FJR FORUM AT WWW.FJRFORUM.COM/FORUM/INDEX.PHP?SHOWTOPIC=103354 HAS SHOWN THAT THIS IS A RECURRING PROBLEM. THE DEALER WAS ABLE TO GET A REPLACEMENT SWITCH IN ABOUT 10 DAYS AND REPLACED IT FOR APPROXIMATELY $250. I BELIEVE THIS IS A DEFINITE SAFETY ISSUE AND SHOULD BE ADDRESSED WITH YAMAHA CORP. USA. *TR

IGNITION SWITCH FAILURE. WHILE PULLING AWAY FROM A STOP LIGHT, THE MOTORCYCLE SUFFERED A COMPLETE ELECTRICAL FAILURE. THIS CAUSED THE ENGINE AND ALL ACCESSORIES, INCLUDING ALL LIGHTS, TO FAIL, NEARLY RESULTING IN A REAR END COLLISION. MOVING THE WIRE HARNESS AT THE BACK OF THE IGNITION SWITCH CAUSES THE ELECTRICAL SYSTEM TO FLICKER ON AND OFF. *TR

WHEN THE ENGINE IS DECELERATING OR BRAKING FUEL IS TURNED OFF AND WHEN TRYING TO ACCELERATE AGAIN THERE IS A DELAY IN FUEL DELIVERY. WHEN TRYING TO ENTER A HIGHWAY FROM THE RAMP YOU DECELERATE TO TIME YOUR ENTRANCE AND WHEN YOU ACCELERATE THE MOTORCYCLE PAUSES THEN LURCHES FORWARD EFFECTING YOUR MERGE INTO SPEEDING TRAFFIC. THIS ALSO HAPPENS TO A SMALLER DEGREE ON EACH SHIFT OF THE TRANSMISSION. IT APPEARS THAT AN AIR PRESSURE SENSOR IN THE INTAKE MANIFOLD PREVENTS THE FLOW OF FUEL DURING INCREASED VACUUM AND THAT THE FUEL IS NOT TURNED ON AGAIN UNTIL THE VACUUM IS REDUCED BY AN OPEN THROTTLE. YOU OPEN THE THROTTLE, THE VACUUM GOES DOWN THE FUEL TURNS ON AND THE MOTORCYCLE LURCHES FORWARD. *TR

I WAS DRIVING THE MOTORCYCLE WHEN IT HAD A TOTAL ELECTRICAL FAILURE, THE ENGINE SHUT OFF, AND I HAD TO COAST TO A STOP IN THE MEDIAN. THERE WAS NO LIGHTS OF ANY KIND AND NO REACTION TO THE IGNITION SWITCH OR STARTER BUTTON. I WAS ABLE TO GET POWER BACK BY MOVING THE HANDLEBARS ALL THE WAY TO THE LEFT. I WENT ANOTHER 3 BLOCKS AND IT DIED AGAIN. I DID THE HANDLEBAR MOTION AGAIN AND POWER CAME BACK. IT DIED IN ANOTHER 3 BLOCKS AND I WAS ABLE TO PUSH IT HOME. I REMOVED THE IGNITION SWITCH/KEY MECHANISM AND DISASSEMBLED IT, AND THE RED WIRE HAD PULLED CLEANLY OFF THE CIRCUIT BOARD. THE DAMAGE WAS SIMILAR TO THE POST AT HTTP://WWW.FJRFORUM.COM/FORUM/INDEX.PHP?SHOWTOPIC=103354 EXCEPT IT WAS THE RED WIRE IN MY CASE INSTEAD OF THE BROWN. AS YOU CAN SEE BY SEARCHING THE FORUM, THERE HAS BEEN A LOT OF THESE FAILURES. THE PAGE AT HTTP://WWW.FJRFORUM.COM/FORUM/INDEX.PHP?SHOWTOPIC=26098 LISTS SIMILAR OCCURRENCES EXPERIENCED BY FORUM MEMBERS. THERE WAS A VERY TIGHT "ZIP-TIE" NEAR THE SWITCH IN THE WIRING LOOM, AND IT IS MY OPINION THAT THIS EXERTED ENOUGH STRESS TO EVENTUALLY PULL THE WIRE OFF. I CORRECTED THE PROBLEM BY REMOVING THE ZIP TIE AND RE-SOLDERING THE WIRE TO THE CIRCUIT BOARD. AN UNEXPECTED LOSS OF POWER MIGHT BE VERY DANGEROUS IF SOMEONE IS PULLING OUT INTO TRAFFIC. IT WAS EVEN MORE DANGEROUS SINCE IT WAS AT NIGHT AND OTHER DRIVERS COULDN'T SEE ME BECAUSE I NO LONGER HAD LIGHTS. *TR

IGNITION SWITCH FAILURE AT APPROXIMATELY 21,000, 28,000, 33,000 AND 44,000 MILES. THE FAILURE HAS NOT YET OCCURRED WHILE THE MOTORCYCLE IS IN MOTION. THE IGNITION SWITCH FAILS TO ENGAGE, OR TURN ON. INSTRUMENT PANEL FLASHES ON MOMENTARILY THEN GOES DEAD. MULTIPLE ATTEMPTS AT TURNING ON/OFF EVENTUALLY RESULT IN A FUNCTIONING IGNITION. LOCAL YAMAHA DEALER CONTINUES TO ADVISE USING CONTACT CLEANER AND EVENTUALLY CONTACTING MANUFACTURER TO SEE IF THEY WILL REPLACE UNDER WARRANTY. CURRENT INDICATIONS FROM OTHER OWNERS IS THAT THE PARTS ARE NOT AVAILABLE AND THAT YAMAHA HAS YET TO ACKNOWLEDGE THIS AS A MANUFACTURING DEFECT. *TR

WHILE RIDING THE 2007 YAMAHA FJR1300 THE MOTORCYCLE SHUT OFF ABRUPTLY. IT WAS AS IF THE KEY WAS TURNED OFF, ALL LIGHTS AND INSTRUMENTS WENT DARK. I WAS ABLE TO CLEAR TRAFFIC AND GET OFF THE ROAD WITHOUT BEING HIT, COULD HAVE BEEN UGLY. THE DEALER AT FIRST CLAIMED NO KNOWLEDGE OF SIMILAR FAILURES, WHEN PRESSED THEY ADMITTED THAT YAMAHA KNOWS THAT 2006 AND 2007 FJR IGNITION SWITCHES ARE FAILING WITH REGULARITY, YAMAHA PROVIDED A REPLACEMENT IGNITION SWITCH. TEARING THE OLD SWITCH APART REVEALED THAT PART OF THE PLASTIC WAS MELTED AND THE MAIN FEED OUT OF THE SWITCH HAD UNSOLDERED ITSELF FROM ITS POST. HAVING THE ENGINE SHUT OFF UNEXPECTEDLY ON A MOTORCYCLE IN TRAFFIC CAN BE DEADLY. YAMAHA ASKED IF I HAD ANY ACCESSORIES WIRED ONTO THE BIKE WHICH COULD HAVE CAUSED ADDITIONAL LOAD ON THE SWITCH. I DO NOT, THE ONLY LOAD ON THE IGNITION SWITCH IS WHAT IS DESIGNED IN BY YAMAHA. THE DEALER KEPT THE OLD SWITCH AFTER IT WAS TAKEN APART. I WAS NOT ALLOWED TO PHOTOGRAPH THE FAILED COMPONENTS. *TR

RIDING UP HILL SEVERE LOSS OF POWER AND POWER SURGES. SEVERAL TIMES ALWAYS RIDING UPHILL I HAVE HAD SEVERE POWER LOSSES AND POWER SURGES. CAUSED ME TO MISS TURN AND SLOW DOWN TO A STOP. I SHUT DOWN BIKE AND RESTARTED. TURNED AROUND AND WENT DOWNHILL AND THE BIKE OPERATED FINE. HAVE NOT HAD ANY REPAIRS OR MODIFICATIONS TO BIKE. THIS OCCURRED ON THE FIRST RIDE ON THIS BIKE UPHILL AND SEVERAL TIMES AFTER. HAVE ONLY RIDDEN 600 MILES ON THIS BIKE. *TR